key: cord-012066-8anhcyia authors: Stams, Alfons J. M.; Huisman, Jacco; Garcia Encina, Pedro A.; Muyzer, Gerard title: Citric acid wastewater as electron donor for biological sulfate reduction date: 2009-07-01 journal: Appl Microbiol Biotechnol DOI: 10.1007/s00253-009-1995-7 sha: doc_id: 12066 cord_uid: 8anhcyia Citrate-containing wastewater is used as electron donor for sulfate reduction in a biological treatment plant for the removal of sulfate. The pathway of citrate conversion coupled to sulfate reduction and the microorganisms involved were investigated. Citrate was not a direct electron donor for the sulfate-reducing bacteria. Instead, citrate was fermented to mainly acetate and formate. These fermentation products served as electron donors for the sulfate-reducing bacteria. Sulfate reduction activities of the reactor biomass with acetate and formate were sufficiently high to explain the sulfate reduction rates that are required for the process. Two citrate-fermenting bacteria were isolated. Strain R210 was closest related to Trichococcus pasteurii (99.5% ribosomal RNA (rRNA) gene sequence similarity). The closest relative of strain S101 was Veillonella montepellierensis with an rRNA gene sequence similarity of 96.7%. Both strains had a complementary substrate range. The biological sulfur cycle plays an important role in nature. In addition, the biological sulfur cycle can be applied in biotechnology to remove and recover sulfur from wastewater and gas (Buisman et al. 1989; Janssen et al. 1995a Janssen et al. , 2001 Lens et al. 1998; Muyzer and Stams 2008) . Chemolithotrophic sulfide-oxidizing bacteria oxidize sulfide to sulfate, but under oxygen-limiting conditions, mainly elemental sulfur is formed (Janssen et al. 1995a ). This property of sulfide-oxidizing bacteria is applied to convert hydrogen sulfide in biogas or natural gas to elemental sulfur (Janssen et al. 2001) . Presently, about 100 of such full-scale installations are in operation worldwide. Biological processes can also be applied for the removal of sulfate from wastewater (Buisman et al. 1989; Johnson 2000; Lens et al. 1998 ). The sulfate-containing stream is led into an anaerobic bioreactor, in which, by the activity of dissimilatory sulfatereducing bacteria, hydrogen sulfide is formed. In a second micro-aerobic bioreactor, sulfide-oxidizing bacteria then oxidize sulfide to elemental sulfur. This biological sulfate removal process is an attractive and economical feasible alternative for the well-known lime process for flue gas desulfurization, in which gypsum is formed (Hulshoff Pol et al. 2001; Janssen et al. 2001) . Presently, a full-scale biological sulfate removal installation is in operation with a capacity to produce 12 t of sulfur per day (www.paques.nl). The biological process is operated at low temperature, and a citrate-containing wastewater stream is used as electron donor for biological sulfate reduction. Dissimilatory sulfate-reducing bacteria are able to use a wide variety of organic compounds as electron donor for sulfate reduction (Hansen 1994; Muyzer and Stams 2008; Widdel and Hansen 1992) . Hydrogen, formate, lactate, malate, and ethanol are well known substrates for Desulfovibrio, Desulfomicrobium, and Desulfotomaculum species. In general, these bacteria oxidize organic compounds incompletely to acetate. Short chain and long chain fatty acids are substrates for different genera of sulfate-reducing bacteria like Desulfobulbus, Desulfococcus, Desulfosarcina, and Desulfonema. Acetate is only a good electron donor for some specialized bacteria like Desulfobacter postgatei and Desulfobacca acetoxidans (Dar et al. 2007; Oude Elferink et al. 1994 , 1999 . Hydrogen-rich gas is being used as electron donors for biological sulfate reduction at low temperature at full scale (Van Houten et al. 2006; Weijma et al. 2002) , while at moderately thermophilic conditions (65°C), methanol was found to be an excellent electron donor for biological sulfate reduction as well Weijma et al. 2000) . In a recent study, methanogenesis and sulfate reduction with citrate was studied (Gámez et al. 2008 ), but citrate is not a known common substrate for sulfate-reducing bacteria. In fact, citrate is rarely tested as growth substrate for newly isolated species. Desulfovibrio oxamicus is able to grow with citrate (López-Cortés et al. 2006) , while Desulfomicrobium apsheronum was tested but was not able to grow with citrate (Rozanova et al. 1988) . The aim of the present study was to elucidate the pathway of citrate conversion coupled to sulfate reduction in the above-mentioned fullscale bioreactor and to identify the microorganisms involved. We mainly focused our research on the conversion of citrate and the microorganisms involved. The sulfatereducing community of the starting sludge had been analyzed previously (Dar et al. 2007) . This sludge contained different types of sulfate-reducing bacteria, including bacteria from the genera Desulfovibrio/Desulfomicrobium, Desulfobulbus, and Desulfobacca. The samples originate from a biological sulfate reduction installation at Yixing (People's Republic of China). The sulfate-reducing bioreactors were started up with sludge from a sulfate-reducing bioreactor from a chemical plant located at Emmen, The Netherlands. The installation is operated at low temperature. The wastewater to be treated is mixed with a citrate-containing waste stream and fed to three anaerobic bioreactors, in which sulfate is reduced to sulfide. The granular sludge bed reactors are equipped with internal settlers for biomass retention. They are operated at a hydraulic retention time of approximately 6 h and an influent flow rate of around 800 m 3 /h, depending on the availability of the wastewater. The total reactor volume was approximately 5,000 m 3 . There is no active sludge management (e.g., sludge harvesting) as the slow growth rate of anaerobic bacteria results in a small biomass production. The biomass entered with the feed stream and was washed-out with the effluent. Consequently, a reliable sludge age cannot be determined. The effluent sulfide concentration of the anaerobic bioreactors is maintained at 150 mg/l or higher. Methanogenesis did not occur. In the overall process, the dissolved sulfide is converted into elemental sulfur in an aerobic bioreactor with air as oxidation agent. The elemental sulfur is removed from the liquid by gravity settling. These two steps are not of relevance for this study. Two sludges from the full-scale reactors were used in this study; sludge S was taken near the influent point of the reactor, while sludge R was from the central part of the reactor. The biomass in the reactor was not homogeneous in appearance. Sludge R had a more compact structure than sludge S. The dry weight content of sludge R and sludge S was about 3.9% and 0.8%, respectively, and the volatile suspended solids (VSS, a measure of organic carbon) content was about 3.0% and 0.2%, respectively. The differences in dry weight and VSS content of the sludges corresponded rather well with the difference in cell numbers determined by direct counting by microscopy. The cell numbers were about 3.10 11 and 5.10 10 cells per milliliter for sludge R and S, respectively. A bicarbonate-buffered mineral medium supplemented with 0.05 g/l yeast extract was prepared as described previously (Stams et al. 1993 ). This medium was used for the activity tests with the sludges and for the enrichment and description of the bacteria. Routine cultivation of the strains was carried out in 117-ml serum bottles with 50 ml medium or in 28-ml tubes with 10 ml medium, and a N 2 /CO 2 (80:20) gas phase at a pressure of 170 kPa. Organic substrates were supplied at a concentration of 10 or 20 mM and where indicated sulfate at a concentration of 20 mM. Incubations were done statically at 30°C. To determine the sulfate reduction activity, 0.5-ml sludge R was inoculated in duplo in 50 ml medium with 20 mM sulfate and different organic substrates. In time, samples were taken to determine the sulfide concentrations. Controls were included without electron donor and without sulfate. Conversion and product formation from citrate was determined using 0.05 ml of sludge R in 50 ml medium with and without sulfate. Samples were taken in time and analyzed for organic acids. To get an impression of the abundance of different groups of bacteria, serial dilutions of suspensions of sludge R and sludge S were made in media with different substrates. The sludges were suspended by taking a sample by syringe and pressing the sample repeatedly back into the bottle with medium using needles with different sizes. The growth tests were done in 28-ml tubes. The incubation temperature was 30°C. Isolation and characterization of strains Strain R210 was isolated from the above enrichment of sludge R with 10 mM citrate without sulfate. Strain S101 was isolated from the highest dilution with growth of sludge S in media with 10 mM citrate without sulfate. Pure cultures were obtained by repeated dilution in citrate-media using, each time, the highest dilution with growth. These incubations were done in 28-ml tubes with 10 ml medium and 1 ml of different dilutions of inoculum. Dilutions were made in tubes containing 9 ml medium without substrate or sulfate. Purity was confirmed by microscopic observation after growth with different substrates. When grown with citrate, strain R210 and strain S101 formed typical crooked chains of cocci. When grown with sugars, strain R210 consisted of cocci and duplo-cocci. Substrate tests were done in 28-ml tubes with 10 ml medium. Growth substrates were tested at the indicated concentrations. Growth was determined by the increase in optical density at 660 nm, substrate conversion, and product formation. Electron acceptor utilization was tested by determination of product formation from citrate, and in the case of iron (III), by color change of the medium. For phylogenetic analysis of the isolated strains, cells of 10-ml cultures were concentrated by centrifugation. Genomic DNA was extracted from the cells using the Ultraclean Soil DNA Extraction kit (Mo Bio Laboratories, West Carlsbad, CA, USA) according to the manufacturer's instructions. The nearly complete 16S ribosomal RNA (rRNA) gene was amplified using primers GM3F and GM4R (Muyzer et al. 1995) . Polymerase chain reaction products were purified and sequenced by a commercial company (BaseClear, Leiden, The Netherlands). The sequences were first compared to sequences stored in the GenBank using the blastn algorithm (http://www.ncbi.nlm.nih.gov/BLAST). Subsequently, they were imported into the ARB database (Ludwig et al. 2004) , aligned, and added to a phylogenetic tree using the QUICK_ADD_TO_EXISTING_TREE tool. The alignment was further corrected by eye, and a tree was calculated using the neighbor-joining algorithm with Felsenstein correction. The rRNA gene sequences of strain R210 and S101 are deposited in GenBank/EMBL/DDBJ under the accession numbers FJ374769 and FJ374768, respectively. Organic acids were measured by high-performance liquid chromatography, and hydrogen and methane were measured by gas chromatography, as described previously (Stams et al. 1993) . Formate was analyzed colorimetrically using the method described by (Lang and Lang 1972) . Sulfide was analyzed by the method of (Trüper and Schlegel 1964) . The VSS content of the sludges was determined from the difference in dry weight (drying overnight at 105°C) and ash content (2 h at 600°C). The physical appearance of sludge samples at the influent point of the reactor and in the central part of the reactor suggested that citrate degradation and sulfate reduction were not directly coupled. When incubated unfed sludge R had a higher sulfate-reducing activity than sludge S (results not shown). The sulfate reduction activity of sludge R from the anaerobic reactor was determined with different substrates over a period of 3 days. The initial sulfide production activity of that sludge without added substrates was 18±3 mmol/g VSS·day. In the absence of sulfate, no sulfide production was observed (<2.5 mmol/g VSS·day). The following sulfide production activities (in mmol/g VSS·day) were measured when substrates were added: citrate (59±9), formate (50±7), acetate (58±8), propionate (76± 21), butyrate (33±17), and lactate (116±22). The activity was highest with lactate, while the activity with butyrate was lowest. The effect of sulfate on citrate conversion by sludge R was determined. Rapid growth and citrate conversion was observed both in the presence (not shown) and in the absence of sulfate (Fig. 1) . In both cases, acetate and formate were formed as main products. The incubations were continued, and after 2 weeks, products were analyzed again. In the incubation without sulfate, still, 19.5 mM acetate was present, while in the incubation with sulfate, the acetate concentration had decreased to 8.5 mM. In this latter incubation, the sulfide concentration was about 18 mM (results not shown). Serial dilutions of sludges R and S were made in media with citrate as substrate. Sludge R showed growth with citrate till the 10 5 dilution, while sludge S showed growth till the 10 7 dilution. The VSS content of sludge R and S was 3% and 0.2% (w/v), respectively. This shows that the relative number of citrate-degrading bacteria in sludge S is about 1,000 times higher than in sludge R. The cell numbers enumerated in the dilutions in media with and without sulfate were the same. The results that were obtained in these initial studies indicated that citrate was not a direct substrate for sulfate reducers, but that citrate was first fermented, and that the fermentation products were the substrates for the sulfate-reducing bacteria. As the sulfate-reducing bacteria of the inoculum were analyzed previously (Dar et al. 2007 ), we focused our further research on bacteria responsible for citrate fermentation. Upon microscopic observation of sludge R and sludge S and the enrichment of sludge R in media with citrate, coccoid cells were observed which formed twisted chains. Two citrate-fermenting bacteria were isolated: strain R201 from sludge R and strain 101 from sludge S. The two strains were coccoid, but strain S101 was somewhat smaller in size than strain R201. Both strain R210 and strain S101 degraded citrate mainly to acetate and formate (Table 1 and Table 2 ). Strain S101 formed less formate than strain R210, but it formed some hydrogen. The substrate spectrum of the two strains was different. Strain R210 was able to ferment sugars to acetate, formate, ethanol, and lactate. Lactate was not degraded by this strain. By contrast, strain S101 did not ferment sugars but was able to ferment lactate and some other organic acids to acetate, formate, propionate, and hydrogen. Taking into account the expected formation of bicarbonate, the carbon and electron balances fitted rather well with the expected balances. Strain R210 and strain S101 did not show growth by respiration. Both strains formed formate as a main product of citrate fermentation. However, strain S101 formed less formate in the presence of nitrate or crotonate. With these electron acceptors, about 4 mM formate was formed during growth with 10 mM citrate, while, in the controls, about 5.6 mM was formed. Strain S101 was able to grow with fumarate. This compound was fermented to mainly formate, acetate, and propionate. When strain S101 was grown with a mixture of citrate and fumarate, the concentration of products was similar to the sum of products formed with citrate and fumarate, separately. Oxygen was not used by the strains, but they could be grown (two transfers) in nitrogen-flushed media in which the reductant and sulfur source sodium sulfide was replaced by sodium sulfate. Growth in sulfide-reduced media under air was possible but not when the cultures were shaken. Comparative analysis of the 16S rRNA gene sequences of the two strains showed that strain R210 was affiliated to members of the genus Trichococcus, while strain S101 was affiliated to members of the genus Veillonella (Fig. 2) . Strain R210 was closest related to Trichococcus pasteurii (99.5% rRNA gene sequence similarity). The closest relative of strain S101 was Veillonella montepellierensis with an rRNA gene sequence similarity of 96.7%. Unfortunately, strain S101 was lost upon storage. Strain R210 is deposited in the German collection of microorganisms and cell cultures (DSMZ) as Trichococcus sp. R210 (accession number DSM 22150). Citrate is clearly not the direct substrate for the sulfatereducing bacteria in the bioreactor that was studied. Recently, (Gámez et al. 2008 ) found a rapid fermentation (Antranikian and Giffhorn 1987; Bott 1997) . The two bacteria that we have isolated formed mainly acetate, formate, and presumably, bicarbonate from citrate. The two strains were able to ferment a set of others substrates as well. Strain R210 fermented sugars. With these substrates, it formed, besides acetate and formate, also ethanol and lactate as products. Strain S101 was not able to grow with sugars, but it was able to ferment some substrates, including lactate and malate, forming propionate as product. The products that are formed by the two strains are direct substrates for the sulfate-reducing bacteria that were previously detected in the sludge that was used to start up the bioreactor (Dar et al. 2007 ). This may have been beneficial for the rapid start-up of the process. Strain R210 was a Trichococcus strain. (Scheff et al. 1984 ) isolated a filamentous bacterium from bulking sludge. This bacterium was described as Trichococcus flocculifomis and is able to grow with citrate, pyruvate, and a variety of sugars and polyols. Other Trichococcus species have been described like T. pasteurii (former Lactosphaera pasteurii) and Trichococcus palustris (former Ruminococcus palustris; Liu et al. 2002; Janssen et al. 1995b; Zhilina et al. 1995) . There are differences in the substrate spectrum of the different Trichococcus species, but the pattern of fermentation products that we obtained with strain R210 for citrate fermentation and sugar fermentation is characteristic for Trichococcus species. Strain S101 was closest related to V. montepellierensis; the rRNA gene sequence similarity was 96.7%. V. montepellierensis was isolated from clinical samples (Jumas-Bilak et al. 2004) . It is able to ferment lactate and succinate to propionate, while it does not ferment sugars. Citrate was not tested as substrate of that strain. In general, members of the genus Veillonella ferment lactate, but they are unable to ferment sugars. The substrate spectrum of strain S101 is similar as described for other Veillonella species, though citrate utilization was rarely tested (Kolenbrander 1992) . However, Veillonella alcalescens is able to ferment citrate (De Vries et al. 1977) . The substrate spectrum of the two citrate-fermenting bacteria is rather complementary. By the combined activity of these two bacteria, a wide variety of substrates is fermented to products that are excellent substrates for the sulfate-reducing bacteria present in the sludge. In this way, complex waste streams represent and excellent source of electron donors for sulfate reduction in industrial processes. Interestingly, lactate can be fermented by strain S101 and can be degraded by a number of sulfate reducers. As shown by (Laanbroek et al. 1983) , the lactate concentration and the prevailing conditions determine which of the bacteria preferentially degrades lactate. Citrate metabolism in anaerobic bacteria Anaerobic citrate metabolism and its regulation in enterobacteria Sulfur and sulfate reduction with acetate and propionate in an aerobic biotechnological process for sulfide removal Coexistence of physiologically similar sulfate reducing bacteria in a full-scale sulfidogenic bioreactor fed with a single organic electron donor ATP formation associated with fumarate and nitrate reduction in growing cultures of Veillonella alcalescens Anaerobic degradation of citrate under sulfate reducing and methanogenic conditions Metabolism of sulfate-reducing prokaryotes New developments in reactor and process technology for sulfate reduction Biological sulphide oxidation in a fed-batch reactor Lactosphaera gen. nov., a new genus of lactic acid bacteria, and transfer of Ruminococcus pasteurii Schink 1984 to Lactosphaera pasteurii comb. nov Industrial applications of new sulphur biotechnology Biological removal of sulfurous compounds from inorganic wastewaters Veillonella montpellierensis sp. nov., a novel, anaerobic, Gram-negative coccus isolated from human clinical samples The genus Veillonella Competition for L-lactate between Desulfovibrio, Veillonella, and Acetobacterium species isolated from anaerobic intertidal sediments Spezifische Farbreaktion zum direkten Nachweis der Ameisensäure Biotechnological treatment of sulfate-rich wastewaters Emended description of the genus Trichococcus, description of Trichococcus collinsii sp. nov., and reclassification of Lactosphaera pasteurii as Trichococcus pasteurii comb. nov. and of Ruminococcus palustris as Trichococcus palustris comb. nov. in the low-G+C gram-positive bacteria Reclassification of the sulfate-and nitrate-reducing bacterium Desulfovibrio vulgaris subsp. oxamicus as Desulfovibrio oxamicus sp. nov., comb. nov ARB: a software environment for sequence data The ecology and biotechnology of sulphate-reducing bacteria Phylogenetic relationships of Thiomicrospira species and their identification in deep-sea hydrothermal vent samples by denaturing gradient gel electrophoresis of 16S rDNA fragments Sulfate reduction in methanogenic bioreactors Desulfobacca acetoxidans gen. nov. sp. nov., a novel acetate-degrading sulfate reducer isolated from sulfidogenic sludge Isolation of a new genus of sulfate-reducing bacteria and description of a new species of this genus, Desulfomicrobium apsheronum gen Trichococcus flocculiformis gen. nov. sp. nov. A new Gram-positive filamentous bacterium isolated from bulking sludge Growth of syntrophic propionate-oxidizing bacteria with fumarate in the absence of methanogenic bacteria Metabolic interactions between methanogenic consortia and anaerobic respiring bacteria Sulphur metabolism in Thiorhodaceae. I. Quantitative measurements on growing cells of Chromatium okenii Occurrence of methanogenesis during startup of a full-scale synthesis gas fed reactor treating sulfate and metal rich wastewater Methanol conversion in high-rate anaerobic reactors Thermophilic sulfate reduction and methanogenesis with methanol in a high rate anaerobic reactor Competition for H 2 between sulphate reducers, methanogens and homoacetogens in a gas-lift reactor Dissimilatory sulfate-and sulfurreducing bacteria Ruminococcus palustris sp Acknowledgments We thank the Technology Foundation STW, Applied Science Division of the Netherlands Science Foundation NWO, Chemical Sciences (CW) of NWO, and the technology program Economy Ecology Technology for financial support of our research.Open Access This article is distributed under the terms of the Creative Commons Attribution Noncommercial License which permits any noncommercial use, distribution, and reproduction in any medium, provided the original author(s) and source are credited.