195 
 
 >y 1 
 
 I i II I \ 
 
 
 ill 
 
 
 A PRACTICAL TREATISE 
 
 ON 
 
 ENSILAGE & SILOS. 
 
 B. "W.'EOSS <35 CO., 
 FULTON, N. Y. 
 
 i ■ * -| 1 1 ; |{ '| ; || ;: fj ij'ii'i^jj! ji'fi ifi'liJ 
 
 ^i^sm 
 
is 
 
A PRACTICAL TREATISE 
 
 Ensilage and Silos. 
 
 CONTAINING MANY VALUABLE LETTERS PROM PROMI- 
 NENT STOCK-RAISERS AND FARMERS, GIVING THEIR 
 ACTUAL EXPERIENCE WITH ENSILAGE. 
 
 A BOOK THAT SHOULD BE READ BY EVERY FARMER IN THE LAND. 
 
 1^>' 
 
 ■ 
 
 rf'OMl'II.El/ANl) PUBLISHED BY 
 
 • E. W. ''ROSS & CO., 
 
 MAM'F U'lTliKHS OF 
 
 THE ROSS ENSILAGE AND FODDER CUTTERS, 
 
 FULTON, OSWEGO CO., N. Y. 
 
^€W^ 
 
 Entered, according to act of Congress, in the year 1884, by 
 
 Elmore W. Ross, 
 
 In the Office of the Librarian of Congress, at Washington, D. C. 
 
 s§^9a 
 
 PRINTED BT 
 
 The Case, Lookwood & Brainard Co. 
 
 printers and binders, 
 
 Hartford, Conn. 
 
 1 
 

 PREFACE. 
 
 It is not an uncommon occurrence for us to receive letters ask- 
 ing about ensilage, manner of building, cost of silo, putting in, etc. 
 Although we have given the subject a great deal of careful study 
 and attention, we are not sufficiently informed to always give the 
 information desired. There has been a great number of books 
 published on this subject, but most of them are from theory only, 
 .and do not furnish the hard facts that most farmers need. 
 Believing that many farmers would adopt this valuable system of 
 supplying green fodder for their stock in winter if they were 
 informed on the merits and expense of it, we decided to gather all 
 the valuable and practical information possible from our customers, 
 whom we know that have given this system a thorough and careful 
 trial, and to publish it in book form for free distribution. With 
 this end in view, we wrote to our ensilage friends giving in full 
 detail our object, and requesting them to give us what information 
 they could regarding the subject, what it cost per ton to raise it, 
 get it in, store it, manner of building silo, whether above or below 
 ground, cost of construction, and general ideas regarding it. 
 They have responded to eur call very liberally, and we are thus 
 enabled to give our friends who are interested in this subject 
 some very important and valuable details on this great question. 
 To our friends who have so kindly helped us in this work, we 
 extend our heartiest thanks, and can assure them that the)'- have 
 thus extended a helping hand to their brother farmers, and we 
 believe their kindness will be greatly appreciated. Without their 
 kind aid we could not have obtained this valuable information, 
 and to them we respectfully dedicate this book. 
 
 Yours truly, E. W. ROSS & CO., 
 
 Fulton, N. Y. 
 
 April 2, 1X84. 
 
ENSILAGE. 
 
 That ensilage is a success there can be no doubt. There is, of 
 course, a large field for improvement, but, in the main, it is a suc- 
 cess. It has been tried by some of the most cautious farmers in 
 the land, who continue to use it, and who speak in glowing terms 
 of it. There are very few farmers who would continue to use 
 ensilage if it was not a profitable and satisfactory experiment. 
 This, in itself, proves that it is all they claim for it.. It is therefore 
 fair to suppose that ensilage is a success. Otherwise it would soon 
 come into disrepute. On the contrary, it has grown in favor very 
 fast in the last two years. We can count a hundred silos now 
 where we could not find one two years ago. Two years ago we 
 endeavored to talk on this subject with a number of farmers, but 
 they would not listen to the subject at all, did not believe that it 
 was practicable, or a healthy food for cattle. These same people 
 are now the most enthusiastic advocates of the system. There 
 are, of course, a great many people who are opposed to this system 
 of feeding, and will not listen to argument, or will not try the 
 experiment. Of course, there are two sides to all questions. It 
 is not to be expected that every farmer will adopt it, but we 
 believe from our observations of it that, in a very few years, every 
 farmer of any note will have his silo. As one of our friends says 
 in his letter, it is simply canned goods, and is as proper food for 
 cattle as canned fruits are for people. It is but a few years since 
 that canned fruits have been generally used, and people could not 
 now do without them. We know, of course, there are some agri- 
 cultural papers who do not advocate this system of feeding, but 
 a great many of the agricultural papers do approve of it, and are 
 
very loud in their praise of it. It certainly has been a very great 
 benefit to a number of the farmers throughout the country, 
 especially to those in the New England States. A great many 
 of the old farms there had run down, and could not feed over 
 five or six head of cattle, that now by using ensilage support 
 from thirty to forty head. We believe that the ensilage system is 
 a boon to mankind generally, and we have taken great interest in 
 it, not because we make a specialty of ensilage cutters, but because 
 we believe it will benefit the farmers, and also the animal creation. 
 There are hundreds of cows that live on straw and poor hay all 
 winter, and come out in the spring hardly able to stand, simply 
 because the farm does not produce enough to feed them. It takes 
 about one-half of the summer for these poor animals to get 
 recruited and in condition to give a reasonable quantity of milk, 
 and some never recover from it. With the ensilage system these 
 cows would give milk all winter, and would come out in the 
 spring in splendid health and condition, and the expense would be 
 no more. This would be, of course, very profitable for the 
 farmer, to say nothing about the comfort and enjoyment of the 
 animals. We know that most farmers let their cows go dry from 
 three to four months in the winter season, because they have not 
 enough to feed them on, or because they have not ambition 
 enough to do the work of milking, etc. To the latter class we 
 have nothing to say, but to the progressive, enterprising farmer 
 we hope our book will be a benefit. Our experience has not been 
 great in the dairy business, but enough to satisfy and warrant us 
 in making the above remarks. A trip through our own county in 
 April, when the cows are first turned out, will verify our state- 
 ment. We have given this our attention, and notice that our 
 county is not alone in this. The main difficulty lies in farmers 
 not having the ambition to try new experiments. Of course, 
 somebody has to go on and make experiments and improvements 
 in all spheres of life and trade. Otherwise, we would be no 
 further advanced than we were a hundred years ago. There is 
 
just as much chance for improvement in agricultural pursuits as 
 there is in any other branch of business. There is not a month 
 but what there is some new machinery or new ideas developed 
 for cheapening and improving' manufactured articles. There is 
 no reason that agriculture should not progress as fast. There 
 has been a great advancement in agricultural instruments to 
 facilitate getting in different products, grains, etc., but heretofore 
 there has been nothing done to increase the supply of milk, and to 
 prepare a feed to produce the same results in winter that grass in 
 the summer season does. It is very difficult through the winter 
 and spring months to obtain nice yellow butter, and it always 
 commands a very high price, and especially if it is made without 
 coloring. We are told that ensilage makes excellent butter, and 
 gives it the color of fall made. 
 
 We have had many letters from customers whom we have sold 
 our feed-cutters to regarding the question of ensilage, and it is a 
 pleasure to read their experience. Many of them have had heavy 
 mortgages on their farms for years, and were utterly discouraged ; 
 as a last resort, built small silos, and increased their stock; and 
 we have letters now in our possession saying that, by the aid of 
 ensilage, they have lifted their mortgage, increased their stock, 
 and are in better circumstances than they have ever been before. 
 Such news is always pleasant to hear, whether it is from the cause 
 of ensilage, or anything else. 
 
 Too many farmers have the impression that it is necessary to be 
 rich, or what they call fancy farmers, to adopt this system. This 
 is erroneous. Any farmer that has from four to ten cows can 
 afford to build a silo, even if he has to run in debt for it. It is 
 very simple and inexpensive to build a silo large enough to exper- 
 iment. It is not any more expensive to cut it green than it is dry, 
 and fodder should certainly be cut, and in this way each farmer 
 knows from his own experience whether it is a profitable thing 
 for him. Of course we understand that what is profitable for 
 some farmers is not for others. We have talked with a great 
 
many farmers about putting in silos, and they have remarked that 
 it was well enough for rich people, etc., but would not do for 
 them. There has been a great many valuable articles written 
 on this subject, and if our farmers read them would perhaps 
 be benefited thereby, but we know of a great many farmers who 
 never read a paper, and consequently do not keep informed. 
 "We hope that this book will reach all such people, and that they 
 will find some valuable and useful information in it. A silo 
 built of wood and above ground, or partly above ground, would 
 be useful for other purposes, in case ensilage proved a failure 
 There is always use for such buildings, such as ice-houses, etc 
 "We are glad to see progress whether it is in agriculture or 
 manufacture. It is a well-known fact that farming is the found a 
 tion of all business and prosperity. When the farmer prospers, 
 we all prosper. Tt is therefore for everybody's interest that the 
 farmer should succeed. Money spent in agricultural implements 
 goes to the manufacturer, thence to his employees, and continues 
 on its endless journey. To say that we are not directly interested 
 would not be true, for we are, and so is every manufacturer in the 
 land. Every business can trace its main resource to agriculture, 
 for it is the one important industry of the land. 
 
 We do not publish this book as a production from our own 
 pen, and will not therefore attempt to champion the cause of ensi- 
 lage. The letters we publish herein are from reliable and progres- 
 sive farmers, giving their experience, which we can vouch for. 
 These letters speak for themselves, and anything we can say will 
 not in any way add to the valuable knowledge these letters give. 
 Farmers who wish to advance with the age, and improvements of 
 the times, must turn out of the old rut, and adopt the new system. 
 There are too many mistakes made by doing as our forefathers did. 
 The one great idea of business is to turn out double or treble the 
 same amount of work at the same expense of former years-. There 
 is no reason why farmers should not do the same. Of course there 
 is a greater quantity of diary products used than there was a few 
 
years ago. The population of the United States is steadily in- 
 creasing, and this demand has got to be supplied. The farmer 
 that adopts the best systems of producing a good article at the 
 least money is the one that will succeed. We know that a great 
 many of our fanner friends think that unless an article is high, it 
 cannot be raised profitably. If they will examine the prices of all 
 kinds of machinery, and compare them to-day with the prices of 
 the same articles five years ago, they will be very much surprised 
 at the difference. Yet our manufacturers make as large a per cent, 
 as formerly, but they are obliged to do a much greater business to 
 make the same profit, but this is as it should be, for it employs a 
 great many more people, and makes greater activity in business 
 life. We can remember when the mowing machine and reaper 
 were first invented, the laboring people were very much alarmed 
 for fear they would be out of work; that these machines would 
 take their place, but the men that used to use the scythe are now 
 at work in factories helping build machines. 
 
 We sincerely hope that this little work of ours will be of benefit 
 to some of our farmer friends, and that we shall have the satisfac- 
 tion of knowing that we have assisted some of them in making 
 their farms more profitable. Whether they use one of our cutters 
 or somebody's else, we would like to see them adopt this system of 
 ensilage, for we believe it is a great thing, and we are strong advo- 
 cates of it. We have, since we commenced this book, received 
 some very encouraging letters from farmers, saying that they think 
 it a very commendable work, and believe it would be more valu- 
 able to farmers than anything ever printed on the subject. It was 
 what the farmers in general required, and they were very glad 
 indeed to hear that we have undertaken the task. These letters 
 have encouraged us to go on with the work. 
 
 E. W. ROSS & CO. 
 
EXPERIENCE WITH SILOS AND ENSILAGE AT LAKE- 
 SIDE STOCK FARM. 
 
 Syracuse, N. Y., February. 
 
 BUILDING A SILO. 
 
 Where nature has so bountifully supplied man with the necessary 
 material with which to build concrete walls, as in Onondaga County, 
 there is little occasion for human ingenuity to be exercised in any 
 other direction. Therefore it was decided, late in the summer of 1882, 
 to build a silo with heavy walls of concrete, using slag from the 
 blast furnace, instead Of stone or gravel, which cannot be found 
 at Lakeside. The location chosen was alongside the main hay and 
 cow barn where we could get a length of forty feet, a width of 
 eighteen feet, and a depth of nine feet; thus utilizing a heavy and 
 substantial wall on which the barn rested, for one side of our silo. 
 Through this wall a door was cut giving suitable and convenient 
 access from the cattle-stable in the basement. The outside walls 
 were laid out two feet in thickness, with a division wall sixteen 
 inches thick, and at right-angles to the barn or basement wall, 
 thereby giving us practically two silos, either of which could be 
 opened without disturbing the other. For uprights or guides to 
 the wall while building, we used hemlock 2 x 4= X 16, about five 
 feet apart, outside and inside the proposed wall, set and fastened 
 firmly in a plumb position, two and one- fourth feet apart as meas- 
 ured across the proposed wall, allowing the ^ foot for the inside 
 or guide-planks, which planks were sixteen inches wide, placed 
 and fastened close to the upright guides, thus leaving between them 
 exactly two feet for the wall. The guide planks being in position 
 for both outside and division walls, and a little mortar firmly pressed 
 
along the inner and underside of them to prevent the thin cement 
 from running away, prepared the work for the first course of six- 
 teen inches. The slag varying in size from a pebble to a good 
 sized cobble stone was shoveled into this huge trough as it were, 
 no special care being exercised to place them except at the corners 
 where building stone were occasionally used crosswise to add to 
 the strength. After filling level with the guide planks, cement 
 was prepared in a barrel with a crank attachment and internal 
 gear to thoroughly stir and mix the ingredients placed therein. 
 
 The best water lime and sand were used in the proportion of 
 three of the former to ten of the latter, placed in the barrel 
 through an opening in its side. Water sufficient to give the mass 
 the consistency of thin cream was used, and therefore the same 
 amount of the ingredients were placed in the barrel to insure an 
 even strength and consistency. A few revolutions of the crank 
 and the perfectly mixed cement was drawn from the barrel, through 
 a faucet at the bottom, and conveyed to the slag in a trough. The 
 operation was, of course, repeated until all the interstices were 
 filled even with the top of the guide-planks. One day was allowed 
 for the mass to set and dry, the time being gradually reduced as 
 we approached the top, when only five hours were required. By 
 spreading the upright guides a little, the planks were easily raised 
 without injury to the wall, when the same operations were repeated 
 until the required height of sixteen feet was reached, the bottom 
 was cemented and a board roof put on which completed the silo; 
 the dimensions being, length, thirty-five feet, breadth, fourteen 
 feet, and depth, fifteen feet. 
 
 This silo was built with the aid of farm laborers only. The 
 sand and lime were drawn fully four miles, and the slag one and a 
 half miles. A careful account made at the time, of each and every 
 expense, including an item of $50.00 for excavating and banking, 
 showed the total expense to be $350.00 for a double silo finished, 
 ready for filling, with a capacity of 165 tons at the lowest calcula- 
 tion of forty-five pounds per cubic foot. 
 
This double silo was filled with corn, cut f of an inch long with a 
 Eoss power cutter, covered tightly, with plank, the cracks bat- 
 tened, and all weighted with eighteen inches of stone over the 
 entire surface. In early winter when opened, the corn came out 
 fresh and bright, with a sweet smell, and slightly acid taste. All 
 visitors examined the silo and ensilage, and many remarked: "Oh! 
 You are feeding sour-krout too, are you ? " The Farmers' Club 
 discussed- ensilage, and the wise opposers ridiculed the sour-krout 
 and alcoholic feed, not even sparing the good Deacon who had 
 built a fine silo and found his corn ensilage a good feed for the 
 production of both milk and butter. 
 
 Perhaps thev feared the coming generation might acquire a taste 
 for strong drink from the milk of cows fed ensilage. We fed our 
 ensilage, however, not yet having developed that moral perfection 
 strong enough to deter us from feeding it, for fear of the volatile 
 alcohol, and the imaginary fear of evil consequences. Is it not 
 a preferable feed to beer grains, refuse from glucose factories, 
 musty hay, old cabbage or turnips ? Is not the aroma of ensilage 
 fully as pleasing? I have yet to hear of the first complaint of 
 poor quality in either milk or butter from cows fed wholly or in 
 part on corn ensilage, and the consumers of Holstein butter manu- 
 factured at Lakeside are among the best families of Syracuse, 
 and unexcelled in epicurean taste. 
 
 For the best quality of ensilage I prefer a strong-growing sugar 
 corn sowed thin enough to allow each stock to develop a fair 
 sized ear. Such corn should be cut when the ears are in" the milk 
 or roasting stage, immediately run through an ensilage cutter and 
 packed in the silo. I am strongly of the opinion that a silo should 
 be filled and weighted heavily the same day, to avoid the heat- 
 ing and souring that so soon takes place if the silo is left open. 
 Sugar corn ensiloed in this manner in a nearly air tight silo can 
 be relied upon to produce a deep rich flow of milk little inferior 
 if any to the finest June pasture. 
 
 The expense per ton of raising and ensiloing a crop of corn is 
 
9 
 
 variously estimated by those experienced in the matter. From 
 past experience I judge that a crop of corn yielding eighteen tons 
 per acre can he raised on our muck land for an outlay of $9.00 
 per acre for labor, seed, and fertilizer. My figures are as follows: 
 
 Plowing per acre, - - - - $1.75 
 
 Harrowing, - - - - - .30 
 
 Rolling, ------ .25 
 
 Seed, li bushels fl) 80c, • 1.20 
 
 Sowing, ------ .50 
 
 Fertilizer, ..... 2.00 
 
 Weeding, - - - - - 1.00 
 
 Cultivating twice, .... 2.00 
 
 $9.00 
 
 Should the crop exceed eighteen tons per acre the cost per ton 
 is reduced as the expense of raising the heavy crop is no more 
 per acre. 
 
 Last season under unfavorable circumstances, using an ensilage 
 cutter too small for our force of men and teams, drawing our corn 
 fully three-quarters of a mile, we ensiloed forty tons per day of 
 eleven hours, at an expense of $35.00 or 87-Jc. per ton. Lessen 
 the drawing distance one-quarter mile and the expense is reduced 
 one team at least. Our cutting expense in the field is light, as 
 boys are employed and placed in charge of -a competent man who 
 directs them, and the corn is cheaply cut, placed in bundles as 
 large as a man can easily handle, ready for the wagon and loaders. 
 
 I think we can safely calculate on eighteen tons per acre, and 
 am sure some acres of our last season's crop exceeded it. I have 
 arrived at the above estimate by actual weight of an accurately 
 measured fraction of an acre. It is very large corn that will weigh 
 twenty-five tons per acre. 
 
 Only a very limited and incomplete experiment has been made 
 at Lakeside to test the milk or flesh-producing qualities of ordinary 
 corn ensilage, grown too thick to admit of forming ears, cut and 
 
 2 
 
10 
 
 ensiloed after a slight damage was done by frost. Three pairs of 
 two years old heifers that had been milked from ten to eleven 
 months were carefully weighed, and fed as follows for a period of 
 thirty days. The amount of milk produced by each pair in ten 
 days preceding the test was compared with the amount produced 
 the first ten days of the test. The result appears as follows: 
 
 Pair No. 1. Fed ensilage alone. 
 
 " " 2. " " and 3 pts. cotton seed meal daily to each. 
 
 " " 3. " " and former feed of 4 qts. bran and 4 
 
 ground oats mixed, to each daily. 
 Pair No. 1. Gained in weight 8 lbs. 
 
 u it 2 " " " 40 " 
 
 it tt 3 tt a a ]12 " 
 
 lbs. oz. 
 
 Pair No. 1. Fell off in milk an aggregate in ten days, 41 15 
 a tt 2 " " " " " " " " " 12 
 
 ft it 3 tt it it . it tt tt tt tt a 5 
 
 It should be borne in mind that these were imported Holstein 
 heifers with their first calves, recently released from quarantine, 
 in poor condition, having calved in mid winter, milked nearly 
 a year and all but one due to calve again in three months, every 
 • circumstance unfavorable to a continuance in milk; therefore I 
 think it remarkable that the shrinkage in milk for the time was 
 no greater, not even so great with pairs No. 2 and 3 as the natural 
 shrinkage. It is a virtue of Holsteins to continue in milk a long 
 time, and a virtue of ensilage to help them do it. 
 
 The comparative value of corn ensilage depends greatly on its 
 quality; that which is all stalk and leaf being inferior to that 
 which contains the natural grown ear in the milk stage of growth. 
 Comparisons are generally based on ensilage made from thickly- 
 grown corn devoid of ears, which by many is estimated; three tons 
 of ensilage equivalent to one ton of hay. I assume this to be 
 correct. An acre of fertile land should produce two tons of hay. 
 An acre of our muck land will produce eighteen tons of corn 
 
11 
 
 ensilage. An ordinary cow will consume three tons of hay in the 
 six months feeding season of our northern winters, or an average 
 of 33-J lbs. per day. By the ratio of one to three we find 33-^ lbs. 
 of hay equivalent to 100 lbs. of ensilage. One acre of hay would 
 therefore feed ten cows twelve days, while the acre of corn would 
 feed the same number thirty-six days. Valuing the land at $1 00. 00 
 per acre and allowing $5.50 for interest and taxes, the expense of 
 producing the eighteen tons of ensilage and ensiloing the same 
 would be increased from $1.37^ to $1.68 per ton. The daily feed 
 of 100 lbs. would therefore cost .084. The acre of hay of two 
 tons can be cut, raked, drawn the same distance we drew our corn 
 and put in the mow for $2.25. Adding interest and taxes for this 
 acre as before, we have an expense of $7.75 per acre or $3.87| 
 per ton in the mow, and .0645c. for the daily allowance of hay, 
 33^ lbs., a difference in favor of hay of nearly .02c. a day per cow. 
 The best is the cheapest. Corresponding to grass of summer is 
 the corn ensilage of winter, rich, succulent, easily digested, and 
 quickly assimilated, producing a deep, rich flow of fine-flavored 
 milk, yielding butter of the finest quality. 
 
 In order to properly winter the immense stock of Holsteins at 
 Lakeside, we must purchase hay and grain, or make and fill more 
 silos. Hay delivered, costs at present $9.00 per ton. Comparing 
 the cost of a daily feed of 33^ lbs. of this hay, when purchased, 
 with the daily feed of 100 lbs. of corn ensilage grown and ensiloed 
 on the farm, we find the daily allowance of hay cost us fifteen 
 cents, or nearly double the cost of the daily allowance of ensilage. 
 Now shall we continue to buy hay, which may advance in value, or 
 build more silos ? To build more and fill them well, seems a prac- 
 tical solution of the problem. 
 
 By the use of a few figures we have learned, that, as a matter of 
 economy, we must produce a large crop of corn of good quality, 
 and while we may not equal the estimates of enthusiasts, we should 
 be satisfied with nothing less than twenty -five tons per acre, which 
 will reduce the cost of the daily allowance of 83^ lbs. to .0727. 
 
12 
 
 The interest, taxes, and growing expenses being divided among 
 the greater number of tons grown, lessening those expenses per 
 ton. 
 
 Our experience with clover ensiloed has not been as favorable as 
 with corn, owing partly to lack of experience, but more to the follow- 
 ing causes. The season of 1 883 caused a quick heavy succulent growth 
 of very coarse clover, consequently it lodged badly and partly 
 decayed at the bottom. The frequent showers at the time of fill- 
 ing the silo, wet the clover, causing it to remain in that condition 
 a long time, and prevented our getting a large proportion of it in 
 other than poor condition. Filling the silo under these unfavor- 
 able circumstances caused the mass to turn black, and gave it a 
 strong disagreeable odor. Cattle eat it greedily however, often 
 leaving corn ensilage to eat it. 
 
 Mr. C. M. Armstrong, manager of the Remington farm, Caze- 
 novia, N. Y., now operated by Smiths & Powell, details the same 
 experience with a little of his clover which received a light shower 
 while that which he ensiloed free from water came out fresh, 
 bright, and green. 
 
 How to produce ensilage of a uniformly good quality, is one 
 great question to solve. Perhaps the theory of Prof. Miles of 
 Amherst Agricultural College, Mass., will throw light on the mys- 
 tery why some ensilage is very sweet, and other ensilage very 
 sour.* "We need light on this important point, and in an age of 
 progress like the present, have every reason to expect it. 
 
 At present we are feeding forty milch cows an average of 55 lbs. 
 of corn and clover ensilage daily, in connection with hay and grain, 
 producing a large flow of milk, while the cattle are easily kept in 
 the finest condition, and as we do not feed one-half the hay we 
 otherwise would, it is evident we are feeding our stock better, and 
 cheaper than on hay and grain both purchased. 
 
 In conclusion, I will state that so far as my experience extends, 
 I find no objection to good ensilage, but strongly approve of it in 
 
 * Co. Gent., Vol. 49, page 104. 
 
13 
 
 our system of feeding. My figures are from notes made at the 
 time, and on the ground, and may appear too small to those less 
 favorably located. I trust they may provoke a friendly spirit of 
 criticism and discussion which will tend to eradicate errors of 
 thought so fatal to true progress. 
 
 JNO. T. CLAPP, Superintendent 
 
 Enfield, N. C, February 15, 1884. 
 Messes. E. W. Ross & Co. 
 
 Gentlemen: — In compliance with your request of 12th inst., ask- 
 ing my experience with silos and ensilage, I cheerfully give you 
 my experience, extending now over nearly four years, having built 
 my first two silos in 1880. 
 
 These were built of cement and stone, eight feet deep, twelve 
 feet wide, and fifteen feet long, which cost me about $300.00. 
 
 These I filled in the latter part of the summer of that year with 
 pea vines two-thirds, and the remaining third with green corn and 
 pearl millet. 
 
 I opened one of the silos about a month after filling, and found 
 the ensilage in good conditon. I at once commenced feeding it to 
 my horses and mules, as well as cattle. All soon became very 
 fond of it, and the horses and mules stood their woi'k as well, and 
 kept in as good condition as when fed on the best of fodder and 
 hay. Since this time three-fourths of all the long forage they have 
 eaten has been ensilage, and another year's experience strengthens 
 my former convictions as to its safe and economic results. 
 
 In 1881, I built two more silos above ground, or rather excava- 
 ted two feet below the surface, thinking at this depch I would be 
 safe from water (in this I was mistaken, as water rose in the bot- 
 tom in very wet seasons, three or four inches deep). 
 
 These last were built of wood, by making double walls of wood 
 
14 
 
 twelve inches apart, and filling in with earth, thus making them 
 air tight, which is all that is required. These were twenty feet 
 long, ten feet deep, and twelve feet wide, costing me not to exceed 
 $100.00, and holding at fifty lbs. to the cubic foot, sixty tons each, 
 or 120 tons; this I estimate cost me not over eighty cents per ton. 
 
 Last summer some of the inside wall of boards had decayed, 
 requiring their removal. 
 
 I tried to avoid the use of earth between the walls, thinking I 
 could make an air-tight wall without it. I first made a wall of 
 twelve inch plank (one inch thick), then after applying a coating 
 of coal tar, I put on another course of the same plank (breaking the 
 joints), after having applied the tar to these also, and nailed the 
 tarred sides together firmly to the studs. About one month after 
 first filling them, I took off the weights to refill them, and found 
 the ensilage next to the wall hot and commencing to decay. 1 
 immediately nailed boards to the outside of the studs and filled the 
 space with earth as at first, which at once arrested the heat and 
 decay. I found when the silo was opened for feeding, that at 
 some parts of it the ensilage next to the wall for some two to six 
 inches was dark colored and decayed, and of course was unfit for 
 use. The balance was in good condition. The wooden silos above 
 ground with the aforesaid exception, has kept the ensilage in as good 
 condition as those built of cement below the ground. This fact I 
 think should do away with the idea of expensive silos. I effectu- 
 ally got rid of the water rising in the bottom of the silos by dig- 
 ging a well just outside of them at one end four feet deeper than 
 the silos, then digging a ditch twelve inches deep and six inches 
 wide in the middle of them, running their entire length, and filling 
 same with small stones, with a hollow tube from the end of the 
 ditch emptying into the well, which requires to be pumped out as 
 often as the water rises to the level of the silo, or in any case about 
 once a week. As I have no cause to change a statement of items 
 of cost of ensilage made to the Ensilage Congress in 1883, I repro- 
 duce it. 
 
15 
 
 Manure for 15 acres of pea vines, 500 lbs. per acre, made of chemi- 
 cals, cotton seed, and stable manure, costing $16.00, $60.00 
 Preparing and planting same, $2.00 per acre, - - 30.00 
 Cultivating and plowing, $2.00 per acre, - - 30.00 
 Hoeing, $1.00 per acre, ----- 15.00 
 Seed for whole, - - - - 10.00 
 Labor for delivery at silo, cutting and weighting 3 silos, 80.00 
 
 $225.00 
 Wear and tear of machinery, interest, etc,, - - 50.00 
 
 $275.00 
 Deduct seed saved from vines before ensilaged, - 100.00 
 
 Net cost of 125 tons ensilage, - - - - . 175.00 
 
 Cost per ton, -..--. $1.40 
 This is for cost of ensilage made from pea vines which I have 
 
 always believed superior to that made from corn. I now have the 
 
 annual report of Prof. Dobney, of the North Carolina Experimental 
 
 Station confirming this opinion. 
 
 Ash, .---.. io.84 
 Fat, - - - - - - 4.38 
 
 Pure Cellulose, - - - - 30.38 
 
 Proteine, - - - - - 13.06 
 
 Carbo-Hydrates, .... 41.34 
 
 100.00 
 Nutritive Ratio, 1: 5: 82. 
 
 For the purpose of comparison we produce an analysis of corn 
 ensilage by the same party, as follows: 
 
 Ash, ---... 7.30 
 
 Fat, - ..... 4.20 
 
 Pure Cellulose, - - - - 30.72 
 
 Proteine, - - - - - 9.37 
 
 Carbo-Hydrates, - - - - 48.41 
 
 100.00 
 Nutritive Ratio, 1: 8: 89. 
 
16 
 
 Thus it will be seen that the relative value of pea-vine ensilage 
 far exceeds that made from corn. I am thus particular in drawing 
 attention to the advantages of the cow pea for ensilage, besides its 
 superiority as a food, it is by far the least costly of any ensilage 
 plant we can cultivate. It matures a full crop in eighty or at 
 farthest ninety days, and is less affected by extremes of the season, 
 either wet or dry, than any other crop. I think, from my experi- 
 ence, it is superior to any plant known for this purpose. 
 
 As many tons can be made to the acre of them as corn under 
 the same conditions. Of course there is great difference in their 
 habits, some making but a comparatively small growth of vine, 
 while others make a very rank growth. The latter only should be 
 grown for ensilage, as a matter of course. 
 
 To sum up I think ensilage made of pea vines superior to any 
 food I have ever fed to horses, mules, and cattle (have never tried 
 it to hogs and sheep). 
 
 That through the silo is the most economical way that food can 
 be transferred, from the field to the stall; that unlike by desiccation 
 there is absolutely no risk from the green plant to its security in 
 the silo, and almost perfect food, and that it is only a matter of 
 time when the system will become universal. 
 
 I do not consider the system has been perfected, as no doubt 
 many improvements will be made from time to time. 
 
 I find the most economical, as well as the easiest method of 
 weighting silos, is with common earth, put on about two feet deep. 
 
 Yours respectfully, 
 
 C. W. GARRETT. 
 
 Charlton, Worcester Co., Mass., March 10, 1884. 
 Two years ago I was aware that my hay crop would be short. 
 I had read a good deal on the method of preserving green fodder. 
 
17 
 
 The idea struck me that I could build a cheap silo in an old barn 
 bay which stood off away from the main buildings and would not 
 be wanted for any other purpose. I commenced planting corn 
 about the first of June for fodder on some fields that were in 
 grass but looked as if there would be a very light crop. I spread 
 barn yard manure on the grass ground and turned it under, and 
 planted on the sod with Russell & Go's, superphosphate of lime, New 
 Jersey, in the hill, 300 lbs. to the acre. Hills about fifteen inches 
 apart, planted with machine. The evergreen sweet corn about 
 three and a half acres. Hoed once by hand. 
 
 It made a large growth the fore part of the season; came on dry 
 and cut it short one-half what it would have been, had it been a 
 common season. However, I had a good lot of fodder and it 
 eared out well. I commenced for a silo in the bay of the' barn. 
 Boarded inside the frame with rough boards twelve feet high, 
 nine feet by eighteen inside on floor. Packed between boarding 
 with sawdust, and papered inside with builders' paper, thinking to 
 make air-tight, filling the bottom with dirt up to top of sill, and 
 laid a floor. This completed my silo work, all done with farm 
 help; cost inside of $20. 
 
 This was arranged for this present crop, thinking if satisfied 
 with the system, I would build something permanent. 
 
 I commenced filling September 10th; some days were dry and 
 some were wet. Hired a Bailey cutter, small size, run it with one 
 horse tread power, cut three-quarters inch long. 
 
 The ears on fodder broke the cutter bad, but I managed to run 
 it through by breaking off the larger ears in time; made rather an 
 expensive job for me. 
 
 It took most of the time for one week to put in and weight it — 
 500 lbs. to square yard — six men, two teams. When settled to its 
 lowest point, there was 1,300 cubic feet. I thought my field of 
 corn, with all my expenses, in rather a small compass. Being told 
 by some ensilage men that I would be satisfied when I come to 
 feed it out, I was contented. 
 
18 
 
 Opened the silo January 1, 1883, fed to twenty-two cows nine 
 weeks, one bushel per day each, or about 30 lbs., part in milk, part 
 dry, all coming in in the spring. Their keeping besides ensilage 
 was hay, first quality, with straw once per day, with meal to those 
 that gave milk as before, only. They gained on milk one-fourth, 
 less than one week's time. The dry cows gained in flesh. I also 
 fed to fourteen yearlings about 15 lbs. per day with poor hay and 
 straw for nine weeks. 
 
 They gained every day from the commencement. It seemed to 
 be something they wanted. When we were about to feed it they 
 were always ready to come into the barn as quick as the door was 
 open. It is a good substitute for roots and is very much cheaper 
 to raise. 
 
 The ensilage did not keep well in this silo. There were rotten 
 corners, and all around the outside, six inches or more, where the 
 air got in. I think it would be a nice job to build a silo of wood, 
 that would keep it perfect; it is necessary to have it tight enough 
 to hold water, then if properly filled in will keep without any loss. 
 
 With my experience I should say that a silo made of wood 
 would be most expensive in the end. The ensilage would rot it 
 in a very few years, so as not to be of any use. 
 
 Being satisfied that ensilage was good feed, and feeling con- 
 fident that I could build a silo that would be for my interest in 
 farming, I commenced one to open into my main barn for feeding, 
 24 feet x 1 2 feet, 1 6 feet walls inside, built of cement and stone, with 
 20" walls. Setting studding inside and out with plank 12" wide 
 with even thickness for the curb. Put one part eement to five 
 coarse sand with all the stone I could bed in, being careful not to 
 have them near the plank to prevent raising. Eaised the plank as 
 fast as it set so as not to break up; completed the walls, put on the 
 roof, all with common laborers at $1.50 per day — board them- 
 selves Plastering inside and out with one part cement and two 
 parts sand, which required a mason at $2.50 per day, which cost 
 me about $400.00. This including digging out and draining for 
 
19 
 
 foundation, 50 loads sand, $60.00. Lumber, $33.00, 80 bbls. 
 cement at $1.50 per bbl., $120.00. 
 
 This was built on a foundation eight feet below barn-floor, about 
 one-half in ground, with door level with floor for taking out ensil- 
 age. The door for filling on the opposite end, on top of walls, 
 five feet from ground. I had four acres of corn planted for fod- 
 der in drills 3^ feet apart, partly Maryland white and part sweet, 
 fertilized same as last year. The season was very dry, and it 
 dried up badly; being so thick it dried worse than if planted in 
 hills, and I got no ears as I did last year. I commenced filling in 
 the silo 15th September, completed the job of fodder corn, and 
 found room for more. Had six acres planted for corn. I had the 
 ears picked, dropped on the ground, cut the fodder also; it being 
 very dry, I wet it down so as to have it tramped down solid. 
 Kept a horse on silo while cutting — cutting with the Ross Cutter, 
 Little Giant, No. 14, three-quarters inch long, run with one horse 
 tread power, with elevator twelve feet long, which carried it into 
 the middle of silo, weighted as before. I found this to be de- 
 cidedly the cheapest way to harvest. The corn was dry enough 
 so as to keep without any trouble. When the ensilage in the silo 
 was settled to its lowest it was twelve feet deep. This will keep 
 thirty cows, one-half their hay keeping 4-| months, — equal to two 
 months and seven days whole keeping and in better shape than it 
 could be done on hay without any grain. I think they will do 
 better on both, than either one alone. There is not one bushel in 
 the whole amount wasted. It is just as good on sides and corner 
 as any part of it. This silo will hold water up to the door; that is 
 what is wanted in order to have a good ensilage. I am going to 
 plant this season some late variety of corn that grows large fodder 
 to plant in hills fifteen inches apart one way, and 3^ feet the 
 other; cultivate and hoe so as to get some ears of corn, and cut 
 when in the milk. I shall be ready this coming season ; my silo is 
 built and will not rot out in my lifetime. I have not met a man 
 
20 
 
 that has tried ensilage but who speaks favorably of it and intends 
 to increase his amount. 
 
 The cost of raising corn for ensilage depends very much upon 
 the land, whether in high state of cultivation or poor; light land 
 works much easier, and can be done principally with horse power. 
 Heavy land, clay, would have to be worked by hand principally. 
 I think one acre of corn for ensilage could be raised and put in 
 silo from eighteen to twenty tons, "which would be a good aver- 
 age," after the fertilizer was on the ground, for $25.00; my advant- 
 age is my land is mostly clay soil. I believe that every farmer 
 will eventually adopt this way of providing for his cattle in win- 
 ter, my silo being one of the first in town. I have had a great 
 many callers from those who intend this coming summer to build 
 silos. 
 
 LEVL L. HAMMOND. 
 
 Scotland, Conn. 
 
 I have a farm of fifty acres. I have worked it fifteen years. I 
 could keep but three cows and two horses, and could not improve 
 it to keep only that number. It is now February 7, 1884. Two 
 years ago I built a silo of 1,000 cubic feet. It cost me to cut the 
 ensilage and pack it into the silo, "ten dollars." I kept through 
 the winter on ensilage and hay, from my farm, five head of cattle 
 and two horses. I found my cattle in the spring in better condi- 
 tion than usual, and my farm improving. 
 
 I enlarged my silo by building on the top 700 cubic feet this 
 present season, and am keeping eight head of cattle and two horses, 
 and shall have more hay than I shall need to keep my stock. It 
 cost me to cut and fill my silo this season, $16.00. I shall sow 
 more corn next season, and if I cannot get it into my silo, I shall 
 cut it and feed dry. 
 
21 
 
 I cut my ensilage with a Daniels cutter. This season I shall 
 have a Ross cutter of greater capacity, which makes it cost less to 
 cut. 
 
 JONATHAN ANTHONY". 
 
 Raleigh, N. C, March 5, 1884. 
 Messrs. E. W. Ross & Co., 
 
 Sirs : — Mr. Mohler handed me your letter and requested me to 
 answer it. Mr. M. and I are the owners of Thomasburg Vine- 
 yard. I tried ensilage as an experiment, and in answering your 
 letter I will state facts which may not occur in other letters. I 
 built three silos under one roof, each ten by twenty feet. The first 
 had a cement floor with dressed wooden sides of two inch plank. 
 This silo was filled with corn alone,' August I, 1882, and when 
 compressed was about six feet deep. It leaked very freely from 
 juices, and I thought it had spoiled. About February 1, 1883, I 
 opened the end as directed in the books and found it sound. I 
 exhibited it to different parties, tried it with horses and cows, and 
 they seemed to like it. It stayed open until about June. I then 
 commenced to use it regularly, hauled it three miles to town, twice 
 a week, in bags, and are still hauling it at this time, as my stable 
 is small. It is as bright color and sound to-day as it ever was. 
 My cows give more milk, from it, my butter is yellow, and turns 
 partially when the cattle do not have the ensilage. The horses 
 only get one bale a day, because it sweats them, but, they prefer it 
 to any other forage. A half broken mustang will not eat it until it 
 gets warm. The other two silos were lined with brick and cement 
 on account of the first leaking, but I would not line them again. 
 They have about eight feet of compressed corn, field peas, and 
 vines, from the bloom to the mature pod, which I regard as the 
 
22 
 
 best material out of which to make ensilage in the Southern coun- 
 try. I expect to find them entirely sound when I open them. 
 
 I hope this fall, in Eastern North Carolina, to try some silos 
 composed of corn, field peas, crab grass, and partially dried peanut 
 vines. In this 1 expect to get a richer ensilage than any yet 
 made. 
 
 I used your cutter, No. 11, I think, first with steam, and then 
 with horses. It required four horses with sweeps to give it suffi- 
 cient speed. If I had sufficient power I would much prefer 
 No. 18. 
 
 I think there were only two things requisite to succeed with 
 ensilage: cut the material one inch in length or less, and let the 
 weight on top be heavy and fall as long as ensilage will give. 
 
 I am respectfully, THOMAS D. HOGG. 
 
 N. B. — The wood of the silo decays rapidly when it comes in 
 contact with the ensilage, and yellow pitch pine gives a slight taste 
 to the ensilage for about an inch. 
 
 Barrington, R. I. 
 P. 0. Address, S. Seakonk, Mass. 
 E. W. Ross & Co. 
 
 Dear Sirs: — As you wish to know what results have come from 
 my efforts to test silos and ensilage, I will give you a description 
 of the past year's experience. 
 
 Farmers cannot afford to experiment too often, for a failure means 
 a loss of time (and time is money), besides the actual outlay of 
 cash. 
 
 While expensive silos were advocated I hesitated, for the amount 
 of stock on my farm was not large enough to demand such costly 
 storage, but the increase of my wife's pet Jerseys called for more 
 
23 
 
 food than I could raise in the form of hay without too much ex- 
 pense, as my soil is high and sandy. Now I work a farm for 
 profit, (and therefore for pleasure,) and as this farm of twenty-five 
 acres was run down and had never fed more than two cows and 
 one horse, yet my success in building up others that were in the 
 same condition gave me faith to try this one, and I now keep one 
 horse, a yoke of oxen, four cows, and two yearlings, by the help of 
 a cheaply built silo. My ensilage is now (March 1st.) nearly all 
 fed out, and have hay enough to last until my seven acres of rye 
 will be ready to cut for fodder, when some corn will follow in time 
 for the silo in the fall. We need not fear the frost as in the past 
 when silos were not used. 
 
 Prove all things and hold fast to good. The silo has come to 
 stay. There is no need of useless expense. My wealthy friend 
 has four silos built of heavy masonry, and says he shall build four 
 more, and yet his ensilage is preserved no better than that which 
 I fed from a cheaply built board silo. 
 
 My barn is arranged so that the floor for cattle is four feet below 
 the level of the ground. The walls are stoned up to the level 
 with brick work above the ground three feet high; this gives a 
 good temperature both winter and summer, and good ventilation ; 
 above is a common board barn for storing hay, etc. 
 
 I partitioned off a space 8X16 feet at one end of my barn, 
 using 2 X 4 joists, with 1^ inch matched spruce sheathing, this 
 extended up to the plates a distance of about twenty feet. The 
 floor, stone, and brick walls were cemented, and after furrowing 
 the sides above the brick wall to make an even surface, the sheath- 
 ing of spruce was carried to the top of the silo. I put doors of 
 matched boards on the first and second floors of the barn, and 
 rough steps from the second floor to the top of silo, all of which 
 cost $25.00, and felt that the lumber woiild be worth $15 for 
 other purposes, in case the silo was a failure. I shall next build a 
 silo of hemlock boards and cover the cracks with lath, as it costs 
 less and lasts longer than spruce. 
 
24 
 
 My next business was to get the right kind of a cutter, and very- 
 likely I taxed the patience of some dealers by my questions, but I 
 wanted a cutter that would cut rye, hay, and dry corn stalks, as 
 well as the green corn fodder, and after careful investigation I 
 decided that the Little Giant was the right article, and am happy 
 to say that a thorough test has proven that my choice was a wise 
 one, for the Ross Little Giant is correctly named and fully meets 
 the published guarantee of its manufacturer. 
 
 The early frost (which was a severe one) of last fall laid its icy 
 hand upon four acres of my corn fodder and left it as pale as 
 death. I was in a fix. Silo and cutter ready, but the sweep 
 power had not arrived, and every farmer knows how quickly corn 
 fodder becomes worthless after a heavy frosting. I set my men 
 at work cutting it with bramble scythes and hauled it at once to 
 the silo and begun to cut it up by hand, but fearing the effect of 
 the frost, 1 deemed the work too slow and filled it into the silo 
 both whole and cut. After all was in and carefully spread and 
 trodden down, With the doors closed, and covered with tarred 
 paper to keep them tight (here I made a mistake, for tarred paper 
 injures the ensilage where it comes in contact with it), I covered 
 it with two-inch planks, and then weighted it with eight inches of 
 wall stones, and all was well. After a few days it began to settle 
 and smell like an herb factory, owing to the weeds which were 
 gathered with the corn, and when it had settled five or six feet it 
 stopped and remained quiet until the 20th of October, when I 
 opened it. Bear in mind that two sides were single thickness 
 of boards and no filling on the other sides. Under the planks, it 
 was wet and sour about four inches deep, while between the 
 planks it was not so wet and of a brighter color. I shall not use 
 plank again, but shall cover the depth of a foot with poor hay and 
 put my sacks of sand and stone on top of hay. 
 
 The ensilage was splendid, the pale frosted stalks had become a 
 bright straw color and were juicy. I was happily surprised. I 
 found that my cutter would cut it as well as if it were fresh and 
 
25 
 
 green. It has the sweet smell of ground apples with an alcoholic 
 odor. My cattle soon learned to eat it, and indeed prefer it to 
 good hay. I was anxious to make a thorough test and so stopped 
 using grain for two weeks, then for a full month. I fed ensilage 
 three times a day without hay or grain, carefully watching the 
 effects, and failed to discover any signs of injury, but on the con- 
 trary found that my stock improved steadily. Since that time I 
 have fed ensilage every day, and my cattle are all healthy and 
 looking finely, and were never wintered better nor so cheaply. 
 
 I do not think that any fair-minded man can stand in front of 
 my stock, and see them leave good hay in their mangers in their 
 anxiety to get the ensilage as soon as the silo door is opened, with 
 their eager, wistful looks toward the point of interest, and see the 
 condition of my cattle, and then condemn silos and ensilage. 
 
 I feed direct from the silo, taking the top, which is exposed to 
 the air, and find the fodder which was cut finely kept in the best 
 condition, as it packs closer, and I found by opening the doors so 
 that I could examine the fodder from the top to bottom, that the 
 closely packed was free from mold, while any openings left by 
 loose packing contained a little mold. 
 
 Every farmer has some place on his farm where he can test this 
 matter cheaply, and it will pay to do so. There can be no fixed 
 rule in regard to the cost of raising the corn fodder, as that will 
 vary with the soil, and every one must use his own resources to 
 increase his crops. Remember that the double back furrow tells us 
 that one piece of soil helps another piece to produce a , better crop, 
 and it is needless to tell farmers that the land must have manure 
 to get the wished-for results. 
 
 As to seed, the Maryland white southern corn is the best, and 
 can be bought of any grain dealer. I have tried it by the side of 
 the best wonderful prolific varieties. In order to get the best, 
 crops it should be sown early, not in drills, but broadcast, and the 
 manure being spread and cut finely. I plowed them in together- 
 about three inches deep, then go over it with a bush. As soon as, 
 
 3 
 
26 
 
 .the corn is fairly up, I go over the whole piece with a light one- 
 horse harrow, having the teeth slanting a little backwards, and 
 thus kill the tirst crop of weeds without injury to the corn. 
 
 On sod I hedge it in rows three feet apart, using the Planet, Jr., 
 and with this machine, I can furrow, cover, roll down, cultivate, 
 and hoe my crops with the horse. 
 
 Experience is better than theory, and I find that I can double 
 
 my stock on this farm by the aid of silos and ensilage, for I can 
 
 raise and store five tons of fodder corn at the cost of one ton of 
 
 hav put into the barn. Yours truly, 
 
 J. A. PERRY. 
 
 Beidgeton, N. J., March 13, 1884. 
 E.W. Ross & 'Co., 
 
 Gentlemen: — Your request in regard to my experience with 
 ensilage and manner of constructing silos, etc., at hand. Will 
 endeavor to give it briefly: 
 
 The corn is sown in drills three feet apart, three bushels per acre. 
 
 The ground that will produce fifty bushels corn per acre in an 
 average season, will produce about thirty-five tons of green fod- 
 der. The ground that is to be used for ensilage should be made 
 very rich; then it will produce twice that amount if the season is 
 not too dry. 
 
 Both theory and practice teach that ensilage is not a complete 
 food for cattle. It is deficient in albuminoids, and some concentra- 
 ted, nitrogenous food should be fed with it, as corn meal, oil cake, 
 or cotton-seed meal, containing albuminoids to excess. 
 
 As to constructing silos, almost any way will answer, so they 
 are built to exclude the air from the fodder. Mine is rectangular, 
 about half above and half below ground; would prefer it above 
 ground, but it is much more difficult to fill and weight. I do not 
 
27 
 
 think that ensilage will take the place of clover hay entirely, but 
 it is a valuable adjunct and is a great saving of it. 
 
 I write these few lines as my short experience with ensilage, 
 hoping that they may benefit some one. 
 
 Yours respectfully, 
 
 CHAS. J. FITHIAN". 
 
 Waddington, N. Y., March 17, 18S4. 
 
 Messrs. E. W. Ross & Co., 
 
 Dear Sirs: — In reply to yours of the 16th inst., I will state to 
 you as near as I can all the particulars concerning my silos. I 
 cannot tell what it cost per ton to raise it, to get it in or store it, 
 because a good deal of what corn I sowed was drowned out, so 
 that I could not accurately estimate the number of acres of corn. 
 I will now state the number of loads of clover, corn and oats, etc., 
 that I put in silos. First silo I put in twenty-four loads of green 
 clover. 
 
 It takes four men to fill a silo and do it justice: one to put on 
 table, one to feed the cutter, one to spread in silo, and one to 
 tramp in silo; and if there are two men in the silo tramping it is 
 all the better, because the more it is tramped the less weight it 
 takes. I am now feeding the clover, feeding two feeds a day of 
 ensilage, and one feed a day of hay and straw cut half and half. 
 I feed the dry feed about noon, the ensilage I feed early a. m. and 
 late p. m. My other silos I put in fourteen loads of corn, three 
 loads clover, four loads of oats, all these perfectly green, tramped 
 it well, put on the weights, which was stone about ten inches deep, 
 on and all over the silo. The silo settled down to about one-half. 
 My other silo was filled, weights put on same as other; it settled 
 three feet. When they were both opened, were found to be slightly 
 
28 
 
 moldy on top, in some places two inches, and in some places near 
 edge six inches. But it did not smell bad, and when well mixed 
 with the good ensilage, they ate it all, so there was no waste. My 
 covering was hemlock lumber, two layers, breaking joints, and 
 they were cut about one inch or inch and one-half, shorter than 
 silo to allow for settling. I opened them in sections, cutting right 
 down from top to bottom, then when down to the bottom I took 
 off another section of two or three feet and cut down the same 
 way. Now for a description of the silos which I built in my barn 
 mow; two silos, thirteen feet above ground. They do not go below 
 ground. Width of each silo 11X15 feet long inside. Amount of 
 lumber used 7,840 feet; this includes 2x6 scantling, and hemlock, 
 and tongued and grooved spruce. I purchased my lumber for 
 $10 per thousand. I put the studs sixteen inches apart. I used 
 tarred paper 32" wide. I first tacked on the tar paper which 
 would just cover three studs, — put on the tar paper perpendicular. 
 That leaves a hollow wall of six inches between outside wall and 
 paper, — outside of silo single boarded with tongued and grooved 
 spruce lumber. I then put on strips on each stud inside one inch 
 thick by two inches wide, right on the top of the tar paper. Then 
 I boarded it again horizontal leaving another hollow wall of one 
 inch. 1 then papered again with tarred paper and then boarded 
 again perpendicular with tongued and grooved lumber. My reason 
 for boarding perpendicular is this: so there will be no obstruction 
 to the cover when settling. 
 
 • I would not approve of screws instead of stone for weight, 
 simply because it is not a steady, continual pressure like stone, and 
 as I have just stated, three thickness of boards and two of tar 
 paper. The partition between the silo contains two thicknesses of 
 boards and one of tar paper. The partition is boarded horizontal 
 on one side of the studs and perpendicular on the other. The 
 silos are well underpinned inside and out, and a good lot of mortar 
 used, especially on inside, to keep out the air and frost. The bot- 
 tom of my silo is one layer- of stone six inches deep, all covered 
 
29 
 
 with sand, but intend to cement them both this year, because 
 cement will hold the moisture and be much cleaner. I make a 
 dormer-window in the roof over the partition between the silos 
 and have a spout to slide it either way from the carrier. The 
 doors for taking out the ensilage are made large enough to take 
 out a two-bushel basketful of feed. I have two such doors one 
 above the other in each silo, and in each "door-frame three doors 
 and two hollow walls. It took five days to fill the first silo, work- 
 ing about six hours a day; four men and one team for that length 
 of time. 
 
 The second silo took three days to fill. Filled a little more 
 than half full, one team and four men. We immediately put on 
 the cover and then the stone. We don't know how much weight 
 to the square foot. But I think it was about ten inches deep. I 
 sowed corn of the southern sweet variety. I sowed in the drill; 
 but, as I said before, the most of the crop was a failure. The corn 
 made splendid ensilage; very jucy, but slightly tarnished; cows 
 milked splendidly. 
 
 I will now tell you how well my cows milked on the corn. Last 
 fall, in October. 1 883, I got more pounds of milk from eight cows 
 fed on two feeds of corn ensilage per day and one feed of dry 
 fodder, than my neighbor got from seventeen head fed on un- 
 thrashed oats cut green, which is considered good fodder, especially 
 for milk. These are positive facts. I now will give you an idea 
 of how my cows are milking now — in March. 
 
 In one day, from two cows and one two year-old, and one three- 
 year-old, four in all. They average all the time, every day, be- 
 tween seventy and eighty pounds per day. This is certainly a good 
 average; if they were. all old cows they would average much more. 
 I tried my cows with ensilage and first-class hay, to see which 
 they would prefer. I place ensilage in their manger, and put on 
 the top of it first-class hay; of course they would smell the ensi- 
 lage through the hay, and the result was they would not eat a 
 mouthful of hay until they devoured all their ensilage. I 
 
30 
 
 know it to be the best feed for cows, and especially milch cows, on 
 record. It is far ahead of first-class hay, three feeds a day, and 
 two big messes of shorts, one feed or mash a. m., and the other p. m. 
 
 The carpenter- work cost about thirty dollars; tar-paper, ten dol- 
 lars; nails, five dollars. You can see my expenses on building 
 these are comparatively small. You know what my ensilage cut- 
 ter cost, and my horse-power is worth $75.00. 1 believe any one 
 having silos must have very warm cow-stables, ensilage being so 
 much like summer feed, etc. 
 
 My cows are all fat and in good order, and the all-clover ensi- 
 lage they are feeding on now is, in my opinion, far superior to 
 corn ensilage for milk. The milk is very rich and our butter 
 brings the highest price in town. 
 
 You can take my word for it, that the No. 1 4a ensilage-cutter 
 I purchased of you is a first-class cutter in every respect. It cuts 
 dry feed equally as well as green, and also the chain carrier, which 
 is eighteen feet in length, works like a charm, and takes compara- 
 tively little power to run it. I use a two-horse power. I can exit 
 ensilage as fast as two teams can draw, and cut, elevate it. spread, 
 tramp, etc., all at the same time. 1 feed one bushel of ensilage 
 twice a day to each cow; that is, on an average. Some cows eat 
 more than others ; they get only what they eat up clean. A bushel 
 of clover ensilage weighs about twenty-seven or twenty-eight 
 pounds, and corn of the same bulk weighs near or between thirty- 
 five and forty pounds. I cut in one-half inch lengths. I can 
 most cheerfully recommend your ensilage cutter and carrier, etc , to 
 the public, as a first-class machine in every respect. I intend to 
 build another silo the coming season. It will be about thirteen 
 feet high, and sixteen feet long, by sixteen feet wide. I never 
 feed the horses ensilage, but am convinced they would do as well 
 on it as the cows. Some of the cows, only one or two of them out 
 of the herd, I had to teach to eat the corn ensilage; they were a 
 day or two before they seemed to know what it was. I just shook 
 
SI 
 
 a little meal on it, and they soon would eat it without the meal, 
 and now they are, if anything, fonder of it than the rest. 
 
 Some gentleman whom I have read about, who has been experi- 
 menting with ensilage, complains of its scouring the stock, but it 
 has done nothing of the kind with mine. If it did, I would feed 
 more moderately of ensilage and a little more of dry feed; common 
 ashes, one handful in a mash of any kind, is a sure cure for scours. 
 If the first handful don't cure, the second or third mash certainly 
 will. My sheep like ensilage well. Also, the hogs and pigs. I 
 pour boiling water on what I feed the swine, and also mix a very 
 little shorts or meal in it, and they eat it with a relish, and are in 
 good condition. I am sorry I cannot give you what it cost per 
 ton, but you can figure for yourself, from the time I told you it 
 took to fill them. I gave you the number of men, horses, etc., 
 employed filling; man and team are worth about $3.00 per day, ten 
 hours, and .men $1.25 and board. 
 
 This testimonial of mine you can print the most important part, 
 or the whole of it if you wish, and any time you wish to know 
 how I succeed, in the future, in this new mode of farming, I will 
 be pleased to explain to you. You must not forget to send me a 
 copy of your ensilage books when you get them from the press. If 
 you wish me to be agent in this part send me the particulars 
 regarding agents' territory, etc., and agents' commission, etc. I 
 hope this will be of benefit to my fellow man and to you. If there 
 are any more particulars concerning the silos I have just been 
 writing about, let me know, and I will explain. I am 
 Respectfully yours, 
 
 HENRY COLBURN. 
 
32 
 
 Piereepont Manor, N. Y., February 4, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen : — Yours at hand in regard to ensilage. I submit what 
 my experience has been so far the present winter. My silo is built 
 in my barn, which was constructed last summer. The barn is 112 
 x 56 feet, having a manure cellar 26 x 112 feet, under where my 
 eows stand, and two rows of cows, which occupy with the allow- 
 ance for feeding, etc., thirty-five feet, in front of which is my 'silo, 
 19 x 48 inside, bottom on level with cows, and feeding door is 
 front of one row, and silo extending up into barn twenty feet 
 high; an entrance floor on each end of silo on floor above cows. 
 My silo frame is made of 8 x 8 posts framed into a sill set into 
 the ground, and upper end into beams of the barn fourteen feet apart, 
 and girts between these posts 4x8, and 3 feet apart. I then 
 placed two-inch plank up and down on inside, and covered the 
 planks well with coal-tar paper of good thickness, and covered the 
 paper with hemlock boards, making joints as well as possible with- 
 out planing. The bottom was made of gravel and two barrels of 
 cement packed into it two inches deep, and then covered with a 
 thin grout of water, lime, sand, and gravel, about two inches thick, 
 and allowed to harden before using, several weeks. The lumber 
 used was less than 10,000 feet of hemlock, at $8.00 per thousand, 
 and counting labor, cement, paper, lumber and all, the silo did not 
 exceed $125.00, and its capacity is about 450 tons, or about 100 
 cattle for seven months. I sowed first season about eleven acres, 
 seven of which was Egyptian sweet corn, and four of Blout's Pro- 
 lific white corn. Owing to circumstances, none of it was hoed, only 
 cultivated once, and was hurt to some extent by frost; measured 
 at fifty-five pounds per foot, 220 tons when pressed in silo. The 
 Blout's Prolific corn was much superior to sweet corn in size, and 
 appeared when put in silo to contain nearly as much sugar. I 
 planted in drills twenty-seven inches apart, use Bradley's ammoni- 
 ated bone at about two barrels per acre, in drill, cut the fodder 
 with reaper, and used three teams and five men to get it to one of 
 
33 
 
 E. W. Ross & Co.'s No. 16 ensilage cutters, with a twenty feet 
 elevator which carried it over beam into silo. It took two men 
 to feed and one on table, and cut a ton in six minutes; used a six- 
 horse engine, and about forty pounds of steam; put in corn in 
 about 31 days, and counting all expense, cost seventy cents per ton 
 to put in use, and labor- on land seventy cents more, making $1.40 
 per ton in silos. Covered with p'iahk and then threw on stone, 
 estimated at 100 lbs. to the square foot, which took two men and 
 team two days. 
 
 I opened and commenced feeding, November 5th. I fed as 
 soon as the cattle would eat it freely, 40 lbs. each per day in two 
 feeds, morning and noon, and a light foddering of hay at night; 
 used one pint of pea-meal per day, and my cows increased their 
 milk J. 00 lbs. per day in four weeks; increased the grain to one 
 quart per day of pea and bean meal after first month. Shall have 
 enough ensilage to feed sixty-six head of cattle from November 
 5th to" April 1st, with one foddering of hay and one quart of grain 
 per day from eleven acres of land and at a cost of not $300.00 
 for the corn, $150.00 for grain, $200.00 for hay, total $650.00 for 
 sixty-six head, which can be lessened by feeding more ensilage 
 and less hay, and cost of ensilage by filling silo with less help and 
 using more time. My cattle are perfectly healthy, and crazy for 
 their feed, and if they had what ensilage they would eat at two 
 feeds they would not eat the hay. 
 
 I consider a wooden silo safe and will last several years, when 
 the inside boards can be removed, the paper keeping the outside 
 plank sound ; do not think wooden silos are as liable to freeze on 
 sides, as the wood is a non-conductor, and a sudden cold storm will 
 not penetrate. 
 
 Have fed a four-year old short-horn bull on ensilage alone, 
 without grain or water, and he has done well and is in fine con- 
 dition. Shall increase my average number of cattle, and think I 
 can keep double as many on same farm as was ever wintered on 
 it, without extra expense. Yours truly, 
 
 W. H. GRENELE. 
 
34 
 
 New Milford, February 15, 1884. 
 
 E. TV. Ross & Co., Fulton, N. Y., 
 
 Gentlemen : — Your favor was duly received. In reply I would 
 say that I have had one year's experience with ensilage. 
 
 Last spring I built a silc with cement walls and floor, twenty- 
 two feet long, and fifteen feet wide, and ten feet high. Over this 
 I erected a frame building with posts six feet high, and planked 
 up the inside even with the inner walls of the cement so as to 
 make a total depth of fourteen or fifteen feet. The silo opens 
 into the basement of the barn, and the walls are .chiefly under 
 ground. It was built after the manner described in Bailey's Book 
 on Ensilage, by fixing vertical timbers' about sixteen inches from 
 the banks of the excavation, putting a tier of plank against these 
 all around, and filling the space with cement, bedding in while 
 wet as many cobble stones as possible; as each layer became suf- 
 ficiently dry, the planks were raised and another added until the 
 wall was of the requisite height. When it reached the surface, 
 supports were of course placed on the outside also. . 
 
 The cement was mixed with sand or fine gravel, in the pro- 
 portion of one to six, and about 35 bbls. were used. The walls 
 are as hard as a rock and look likely to stand for ages. The total 
 cost, including superstructure, and allowing for labor and team 
 work, was not far from $150.00. The latter part of August, the 
 silo was filled to the top of the cement, with the corn grown on 
 some four acres, cut into f inches in length. This settled under 
 pressure to a depth of seven feet. The corn was sowed in drills, 
 and cultivator run through it twice without hoeing. Of the exact 
 amount of labor expended in raising I kept no account. Estima- 
 ting the quantity at sixty tons, the cost of transferring from the 
 fields as it stood to the silo cut and weighted, with reasonable al- 
 lowance for wear of cutter and engine, was about $1.00 per ton. 
 
 The silo was opened the first of November and its contents 
 found to be in an excellent state of preservation, of an olive color 
 and fragrant smell. Since then, I have fed it once a day to my 
 
35 
 
 thirty head of imported Holstein and other cattle, and part of the 
 time to about the same number of pure blood Southdown sheep. 
 They ate it greedily from the first, and have thriven finely upon 
 it without extra allowance of grain, as a partial substitute for dry 
 feed. I am satisfied that it is not merely economical for the 
 owner, but better for the stock. Beyond that I have never exper- 
 imented, but if I had enough to last,' I should substitute it further. 
 It is perfectly palatable, sweet, and wholesome, and I know of no 
 reason why it could not serve for two meals a day as well as one. 
 In that case, one would simply need to feed more cotton-seed and 
 corn-meal and less bran, in order to keep as nearly as before to 
 the so-called perfect ration. 
 
 But I do not wish to enter the field of argument. I have sim- 
 ply to add that I built the best silo I knew how. From the begin- 
 ning to the end, I sought to fulfill all the conditions of success, 
 and not only did I provide a good receptacle for the corn, but I 
 put good corn into it. when it was at the right stage of maturity, 
 and before it was half spoiled by frost. I determined to give the 
 system a fair trial, and then if it failed, it would not be my fault, 
 but the fault of the system. The result is that nearly every per- 
 son who has examined my ensilage, says that it is the best he has 
 ever seen. 
 
 It may be that wooden silos built above ground, as you suggest, 
 will answer every purpose. That must be left to the experience of 
 those who have tried them to show. 
 
 My silo excluded the air so perfectly, that the amount of spoiled 
 ensilage practicaly amounts to nothing. It would not exceed a 
 bushel or two in all, and that owing to the impossibility of making 
 a hermetically tight covering. In my judgment the slight addi- 
 tional expense of concrete, at the outset, is more than counter- 
 balanced by its greater durability and the greater certainty of the 
 perfect preservation of its contents. I have no desire nor interest, 
 gentlemen, to influence any man's opinion, either on the main 
 question or the methods of its application, but in response to your 
 
36 
 
 request, have briefly stated my own experience. That experience 
 enables me to say, that the capital I expended in a silo was the best 
 investment I have ever made. 
 
 Very truly yours, 
 
 E. B. MARSH. 
 
 Center Rutland, Vt., February 8, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen: — Your much esteemed favor of the 26th ult., is at 
 hand. In reply, practically I can say little from experience on 
 ensilage. Two years since I built a silo on my farm in New 
 Hampshire, but that is seventy miles away from me and I go there 
 only two or three times a year, consequently have not watched 
 results. My man on the farm thought so Well of the first one 
 that I built the second one last year. I can only say that 1 built 
 of wood and quite cheaply. The ensilage has come out each year 
 in splendid condition. Some adjoining my farm built of stone 
 and cement at a much greater cost. More satisfactory results have 
 been had from my silo, built mostly above ground, and entirely 
 of wood. I took one end of my barn and lined up about eighteen 
 feet with plank. The cost of my silos didnot exceed $50.00 each. 
 Sizes were twenty feet long, fourteen feet wide, eighteen feet deep. 
 I will only add that I think silos have come to stay; and I fully 
 believe in them. I wish I could write you results obtained from 
 experience and practical knowledge. I should much like one of 
 your books when out. I think another fall I may want a cutter. 
 Hastily yours, . 
 
 W. A. JOHNSON. 
 
37 
 
 Monmouth Junction, N. J., February, 1884. 
 E. W. Ross & Co., 
 
 As to the subject of ensilage, I am of the opinion that farmers are 
 mainly hampered by two great considerations, those of prejudice 
 and ignorance. Prejudice, in that they are firmly persuaded it is a 
 good thing, but persistently refuse to try its great and lasting bene- 
 fits — and ignorance, because they allow their old time customs to 
 dominate their every day lives to the exclusion of great and prac- 
 tical results. After an experience both in the county " Middlesex" 
 and outside the State, I am of the opinion that the silo, in a great 
 many instances, is made too costly. Of course, with large cap'ital 
 such a course is of no moment, but to the small farmer — to whom I 
 verily believe the Ross cutter is an estimable blessing — cost of 
 course must be a consideration. My plan is to dig a pit (accord- 
 ing, of course, to the ensilage grown) of from twelve to twenty 
 feet in depth, with a breadth of about half the same number of 
 feet. The material can then be introduced, and after the pit is 
 filled a screw-jack can be used, taking care of course that the pit- 
 sides are lined with plank, and then a temporary flooring being in 
 place, the whole mass can be firmly packed, the tighter the better. 
 Cost per ton, too, is so excessively low that it need not alarm the 
 most penurious. 
 
 As to its results, ensilage food is of itself doubly nutritive in 
 the winter, and is far ahead of ground food, and careful chemical 
 analysis shows that the waste of the various nitrogenous and car- 
 bon-giving elements are little or nothing. 
 
 These crude and informal remarks are given and are based 
 upon the honest conception of the writer who cannot close with- 
 out a' reference to the kind of cutters that should be employed. 
 I have watched the various cutters that have been floated, but 
 unhesitatingly award the palm to the Ross cutters and carriers. 
 Simplicity of construction, durability, added to a never-failing 
 satisfaction in working, are a few of their distinctive merits. 
 
 DOUGLAS DeMEYRICH, 
 Country Editor " Home News." 
 
38 
 
 Washington, February 2. 
 Messrs. E. W. Ross & Co., 
 
 Gentlemen: — Your favor of the 25th, after sundry forwardings, 
 reaches me to day. 
 
 I can give you no valuable figures on the cost of a ton of ensilage 
 in silo, because my assistants did not keep their accounts with proper 
 detail, the first year, and this year the corn yield was too short for 
 a just estimate. As far as I can judge, wet curing by ensilaging is 
 a safer method than dry curing. 
 
 The quality of the ensilage depends on the condition of the crop 
 harvested. I have preserved excellently full-grown corn which was 
 badly frost-bitten in a wooden silo; corn grown only to about three 
 feet in height, when frost-bitten, is not nearly so good, though pre'- 
 served in a stone silo under great weight. 
 
 The silo does not improve, it preserves the younger plants with 
 more danger than the older ones. Experience alone will teach 
 the farmer the difference between good and poor ensilage. 
 
 The quality is as easy to distinguish as the quality of hay. In 
 laying out cattle-barns, the body of the distributing wagon should 
 be six inches to a foot above top of manger, the bottom of silo 
 should be six inches to a foot above the top of the wagon-box. It 
 costs practically nothing to raise the crop over the top of silo, as 
 the engine that runs your No. 18, Giant, making an average of one 
 hundred loads a day, did cut thirty-five loads in two hours. Your 
 No. 18, Giant, will cut a load of stalks in 2 minutes 12^ seconds, 
 and I do not think any more men could have been used to 
 advantage. Six minutes a load is the average time taken to drive 
 a load up to the platform, unload and go away. 
 
 A stone silo I am convinced is cheaper than a wooden one.. My 
 stone silo cost about $2.50 per ton capacity; the wooden one about 
 $] .50 per ton capacity; the stone one ought not to rot, the wooden 
 one cannot he expected to last five years. Silos should be as deep 
 as possible. Fourteen feet two inches is as good a width as any; a 
 sixteen-foot plank is a trifle heavy. Planks can be got ten feet, 
 
SO 
 
 twelve feet, fourteen feet, sixteen feet. About two inches play is 
 needed to prevent jamming. 
 
 The beginner should see several silos before building his own. 
 By careful study a good designer can save the practicing farmer 
 immense labor bills. 
 
 Sixty dollars is the interest of $1,000. Yet $60 is two months' 
 wages for a man. How many farmers will hesitate to build for 
 $500, where they would not hesitate to employ another man ? The 
 advantage of the silo is security in harvesting and labor saved in 
 feeding. 
 
 If the silo and barn are not well designed they will cause severe 
 loss instead of a handsome profit. I do not consider ensilage only 
 proper feed. 
 
 Yours truly, 
 
 HERBERT WADSWORTII. 
 
 Oooperstown, N. Y , February 6, 1884. 
 E. W. Ross & Co., 
 
 Dear Sirs : — Yours of the 2d at hand. In reply will say that I 
 don't feel competent to write an article for your book. I filled 
 one of my silos last season for the first time. The early frost cut 
 my corn very bad ; some people thought that the crop was not worth 
 cutting and putting into the silo. I cut it with my reaper; one 
 team to cut it, two teams and three wagons to draw it to the silo. 
 One two-horse-power to run the No. 14 A Ross cutter. We put in 
 three loads per hour. It took three men one-half day to fill or 
 cut all the fodder corn off of ten acres, by estimate 80 to 100 
 tons. I opened the silo January 1, 1884. The ensilage has kept 
 well, and is more than satisfactory to my stock and to myself. 
 I want to fill all my silos this next season. I think it best to put 
 on plenty of stone for weight. That you want to recommend 
 
40 
 
 strong in your book. I built with stone. I paid 46 cents a perch 
 for laying the stone, I furnishing stone, lime, and tending mason. 
 I have two silos 3H feet x 12; one 20 x 12; one 12 x 12, all thir- 
 teen feet deep; the partition-wall eighteen inches thick, and side- 
 walls two feet thick, all plastered with cement, side and bottom. 
 The bottom of my silo was rock. I put in small stone first, then 
 pounded up stone fine to make it smooth, then plastered over the 
 bottom. If there is any water to run out of the rock-bottom, the 
 drain in the small stone will take it off. My plan is, if a barn or 
 silo is worth building, it is best to do it well. 1 would not advise 
 any slip-shod of a farmer to build a silo. 
 
 Wood, if air tight, will keep the fodder as well, below as above 
 ground. I will give you the basement or ground plan of my barn 
 and silo. The bottom of the silo is fourteen inches below the 
 stable floor, so that it is easy to feed the stock. My cows give me 
 more milk since I fed them with ensilage morning and night. I 
 make butter winter and summer. 1 think that the milk and but- 
 ter is better color and flavored better since I have fed the ensilage. 
 The cows milk better, give down the milk the same as they do to 
 grass, don't drink as much water. I feed hay at noon, for my 
 ensilage will not hold out to the end of the season if I feed it too 
 fast. Yours truly, 
 
 MARCUS FIELD. 
 
 Chicago, January 31, 1884. 
 E. W. Ross & Co., Fulton, N. Y., 
 
 Gentlemen : — Your letter of 29th inst. is at hand. I am very 
 sorry I am unable to comply with your wishes in regard to ensi- 
 lage, silos, etc., as I have had.no experience with it. I have 
 used your cutter only in cutting dry feed, stalks, hay, etc., 
 and will give my opinion in the u?e of it for this purpose, if you 
 
41 
 
 wish. But I suppose you have all 3^011 care for in this way. I 
 hope you will favor me with one of your books when ready for 
 distribution, as I am sure it will be of much value. I-wili be glad 
 to assist you in any way in my power, for I want information, as I 
 have about twelve square miles, which has been put under the 
 plow within the last ten years, an<J now am putting it into a 
 thoroughbred stock farm. 
 
 Last spring I went to England, and chartered one of the largest 
 iron steamships that cross with cattle, and loaded both decks with 
 306 head of thoroughbred pedigree Hereford cattle; all females 
 but ten, and are now on my farm doing well. 
 
 Now you will see that I am in need of help in obtaining knowl- 
 edge, to care for what I have and what I expect to come. Al- 
 though I commenced farming when thirteen years of age and am 
 now fifty-one, yet I find I have much to learn. 
 
 Ver3' truly yours, 
 
 CHAS. W. COOK. 
 505 Monroe street, Chicago, 111. 
 
 Union Springs, N. Y., February, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen: — I have used ensilage for some years by way of 
 experiment and for a small family. The silo occupies one end of a 
 barn basement, and will hold about thirty tons, it was made at a 
 cost of less than thirty dollars, by merely plastering two sides, and 
 making solid plank partitions lined outside with building paper 
 on the other two sides, the cow stalls are on the same level, and 
 the animals are easily supplied through the plank door. The fresh 
 stalks are drawn to the floor above, cut half an inch long with a 
 two-horse Ross power cutter and a few tons filled in each day. It 
 is better to fill moderately so as to promote some fermentation, 
 4 
 
42 
 
 which cooks the ensilage and makes it better, than if converted 
 to vinegar at a lower temperature. The silo is weighted as usual 
 with stone on plank, half a ton or more to a square yard. For 
 removing the ensilage, the stones are easily placed on a broad, solid 
 shelf surrounding the silo ;. this I find much simpler, easier, and 
 better than any other kind of pressure. I do all the work with a 
 two-horse team and the labor of two men. They cut the stalks in 
 the field with sickles, placing them at one operation on the low 
 wagon and drawing about a ton at a time. One of the Ross small 
 power cutter (No. 11), driven by the two horses, which are taken 
 from the wagon, will cut a ton in twenty minutes, but when 
 briskly driven it has been done in less than ten minutes. 
 
 I find this mode of preparing fodder to possess several advan- 
 tages, and on the whole I prefer it to any other. The stalks may 
 be cut, drawn in and chopped in any weather except a pouring 
 rain. The labor of chopping the fresh, succulent stalks is only 
 one-half as much as cutting dry fodder; the space they occupy in 
 the silo is several times less than by the common way of storing 
 in barns, and my neighbors are often astonished at the large amount 
 packed solid in so small a space. 
 
 The cows prefer the ensilage to dry food. Keep in better con- 
 dition and give rather more milk. An important saving of labor 
 is effected by entirely avoiding placing the stalks in shocks, and 
 then there is no danger of the fodder spoiling in heavy rains. 
 
 I have not made a rigid estimate of the cost of ensilage by the 
 ton. On rich soil twenty tons of green fodder may be raised on 
 an acre in the average of seasons. 
 
 The past wet summer gave me twenty-eight tons. In very dry 
 summers I have had only fourteen or fifteen tons. . ■ 
 
 But much depends on the richness of soil, and it is much cheap- 
 er to raise heavy crops with plenty of manure. The large south- 
 ern sweet corn, the seed of which I obtain yearly from Burrell & 
 Whitman, Little Falls, N. Y., yields nearly one-half more than our 
 small northern varieties. The cost of the fodder ready to cut 
 
43 
 
 ought, therefore, not to be more than one dollar a ton ; drawing 
 and filling in would not be greater, probably a little less. 
 
 I have found by experiment that cutting dry fodder half an 
 inch or l£ss in length doubles its value for feeding, as compared 
 with the common mode of feeding it uncut, and had adopted this 
 mode before employing the silo. The latter is a still further im- 
 provement. 
 
 An important additional advantage is gained by either mode, 
 besides economy in feeding by the increased value of the manure, 
 which is short, ready to spread at any time, and is free from the 
 long fibre so troublesome in common cornstalk manure. 
 
 J. J. THOMAS. 
 
 Baltic, Conn., February 5, 1884. 
 Messrs. E. W. Ross & Co., 
 
 Gentlemen: — In answer to your letter of 30th ultimo, asking a 
 statement of my experience in ensilage, etc., I will say that for 
 over two years back I made it a duty to enquire into ensilage, and 
 have taken great pains to ascertain from books written on the sub- 
 ject, and from parties that had built silos, whether it was profitable 
 to build silos and raise corn for ensilage. Not wishing to farm it 
 for the mere fancy of doing it, I was desirous to make farming a 
 success financially. 
 
 After gathering all possible information for and against it, I 
 finally resolved, last spring, to build a silo and raise corn to fill it. 
 
 I built a silo partly under ground and partly above ground, so 
 that the top of my silo was one foot above the floor of my barn, 
 45x24 feet, divided in three parts, each measuring 13x20 feet at 
 bottom, and 13-^x20 j^ feet at top, and 16 feet deep. As you 
 will see by the measurement that my walls were made with 4-inch 
 battening on the 16 feet so as to insure a perfect exclusion of air 
 
44 
 
 •in pressing the mass with stones, putting about 400 lbs. to the 
 square foot. 
 
 My silo is built of common field stones which cost me the cart- 
 age (about 150 rods), laid in lime mortar, the wall being 24 inches 
 thick at bottom, and 16 inches at top, and are fastened inside 
 with mortar, made of one part lime, 5 parts cement, and 12 parts 
 sand for the sides, and bottom of one part cement, 3 parts sand, 
 and 2 parts gravel, and cost $392.87, not counting cartage of 
 stones and sand, and holds when filled 240 tons. 
 
 Although it had hardly time to dry before I put in my ensilage, 
 I find now (as I have emptied) it is in very good condition, and 
 feel confident that it will last a century or more. 
 
 For corn I sowed Southern Dent in drills 40 inches apart, with 
 the Albany coi-n planter, from June 6 th to 12th, putting super- 
 phosphate in the drills, with the attachment in the planter, 300 lbs. to 
 the acre, but owing to different causes and particularly to drouth, it 
 did not grow as well as I expected. I raised 160 tons on 10 
 acres, and it was slightly damaged by frost. I begun to put in 
 my ensilage on September 6th, and finished the 12th, taking three 
 days in one week and three in another to fill two parts or 1 60 
 tons, but as it was the first time any of my men had done this 
 kind of work, it could be done quicker. I use the Ross Little 
 Giant Cutter No. 14A, with a two-horse tread power with 5^ feet 
 diameter drive wheel. It did the work very nicely and cut the 
 whole 160 tons without grinding the knives, a remarkable thing 
 to compare to what 1 hear of other kinds of cutters. 
 
 ] begun to feed my ensilage November 8th, found it in a nice 
 condition, and fully up to my expectations, and found that my 
 cows ate it very well, some the first time it was given to them, and 
 all after two or three feeds. My cows have gained in milk, quan- 
 tity and quality, and I have made and am now making as good 
 butter (color and flavor) as I have ever made in summer. Milk- 
 ing is done before feeding so as to be sure that no taste of any 
 kind of feed is imparted to the milk, and although working under 
 
45 
 
 many disadvantages, my ensilage did not cost me over $3.00 per 
 ton, and I am confident I can raise it much less another year. All 
 I regret is that I did not have enough to fill all three of my silos, 
 and that it did not feed my twenty-five milch cows and seven 
 head of young stock for more than five months, giving them a 
 little meal and shorts with it morning and night, and feeding a 
 little hay at noon each day; but I hope that next year I will raise 
 enough corn to fill all up, if manure and fertilizer will help. 
 
 Very truly yours, 
 
 J. H. WOISARD. 
 
 Branfobd, Conn., February 4, 1384. 
 E. W. Ross & Co., 
 
 Gentlemen: — We are in receipt of yours of January 29th, ask- 
 ing us to send you a statement of our experience with ensilage, 
 the way we built our silo, and our opinion in general on the sys- 
 tem. We built our silo in one of the bays of our barn, it is 10 x 
 16— 16 feet deep. "We dug down six feet and stoned it up and 
 cemented it smooth as the side of a room. 
 
 We then laid sills on the stone-work, built a frame ten feet high, 
 and covered it on the inside with one inch matched boards, two 
 thicknesses, breaking joints as we do with shingles. We then gave 
 the boards a coat of coal tar to fill the cracks, making it perfectly 
 air tight. The silo when completed cost $65.00. 
 
 We planted three acres of southern white corn in rows three 
 feet wide, with the hills fifteen inches apart in the row. We began 
 to fill our silo August 1st; it required the aid of ten men and four 
 horses two and one-half days to fill it. We cut the ensilage one- 
 half inch long with the No. 13 Little Giant Cutter, which we 
 purchased of you, driven by a Cobleskill horse-power; it made 
 lively work for three men to feed the cutter. We are well pleased 
 
46 
 
 with both, power and cutter, and would advise any one going into 
 the ensilage system to try a Cobleskill Power and Ross Cutter. 
 After we had filled the silo, we covered it with tarred felt and 
 two-inch plank, upon which we put about ten ton of stones. 
 
 "We opened the silo December 5, 1883, and found the fodder as 
 green and sweet as when first put in. We have been feeding our 
 milch cows since December 5th, all they will eat, with about six 
 quarts of wheat shorts a day, and they never looked or did so 
 well as at the present time. 
 
 Our milk is sold every day in New Haven to some of the first 
 families, and we have not heard one word of fault yet. Parties in 
 this vicinity who have silos and cut their fodder one and one-half 
 inch long, admit that our ensilage is better than theirs, and they 
 will cut it one-half inch next season. 
 
 On the whole we are more than pleased with our ensilage fod- 
 der, and think that a visit to our barn will convince those who are 
 prejudiced against ensilage that it is a valuable winter feed for 
 milch cows. We are so well pleased with it that we shall build an 
 addition to our silo 10x16 in the spring. 
 
 We are satisfied that there are three things necessary to be suc- 
 cessful with ensilage : first, a good silo; second, the fodder must be 
 cut at the right time, that is, when it is in the milk ; third, it must 
 be properly weighted. 
 
 Yours very respectfully, 
 
 J. H. & F. E. BEACH. 
 
 Dublin, N. H., February 9, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen : — At your request, I will make a few statements 
 in regard to my silo and my experience with ensilage. I have 
 been a great believer in this system of storing fodder, for two or 
 
47 
 
 three years, and was determined to try it thoroughly, but on 
 rather a small scale at first. My silo is built in one corner of the 
 barn cellar, and is 9 feet deep below the barn floor, and 9x 14 feet 
 on the inside. It was built last June, and I estimated 4hat $100.00 
 would cover the whole expense. 
 
 I have no doubt but that a wooden silo might have been built 
 for much less money, but I prefer todiave the bottom part built of 
 cement. I commenced by laying a drain covered with flat stones 
 from the bottom of the cellar wall, starting in the corner and run- 
 ning under the silo and out from under the barn ; this is to carry 
 off any water that may collect round the wall, and make it dry 
 under the silo. Then I dug out the dirt and put in about 8 inches 
 deep of little stones all over a place the size T wished to build the 
 silo. I used 16 cakes of Norton's cement, which T bought of D. 
 Roby & Co., 280 Causeway street, Boston, Mass., a good reliable 
 company. The cement was mixed three parts gravel to one of 
 cement, the w T alls,' which are one foot thick, have as many small 
 stones packed in the cement as possible, and have a good job; to 
 finish the bottom I covered the stones with cement mortar about 
 three inches deep, and made it water-tight. I planted white south- 
 ern corn, about one acre in all, about half of it w T as planted in 
 drills, but we got it too thick ; the rest was in hills and grew larger 
 stalks. I think there is more danger of planting it too thick than 
 not thick enough. The dry weather hurt my corn considerably, 
 and then at last the frost nipped it, but I had some very good en- 
 silage after all, much better than I expected. I used the Little 
 Giant Ross Cutter No. 11, with a one-horse power, and cut the 
 corn \ inch long. I think the Ross Cutter is far ahead of any 
 other kind that I have seen. I put the corn into the silo about 
 the first of September, and pressed it'by raising a scaffold of hay, 
 with two jack screws and bringing the weight on the corn. I had 
 enough corn to fill the silo, and after it had settled a foot I filled 
 it up again, then it settled two feet more, leaving the ensilage 
 seven feet deep, when I opened it October 20th. It had kept 
 
48 
 
 splendidly. I have fed five bushels every day, and some days 
 six; at this rate I think it will last until the first of April. The 
 cattle appear to like it as well as meal or the best of hay, and I 
 have seen no bad results from it. I am satisfied that I cannot 
 afford to do without ensilage, and intend to enlarge my silo the 
 coming season by building it higher. I have read of folks that 
 pressed their ensilage until the juice ran out in large quantities, 
 but I think that is wrong. The main point is to have the corn trod 
 tighter round the edge of the silo, and then it does not need to be 
 pressed very hard to have it keep well, according to my idea. 
 
 Yours truly, 
 
 CHAS. F. APPLETONV 
 
 New Bkunswick, N. J., February 5, 1884. 
 E. W. Ross & Co., 
 
 In reply to your inquiries about silos and ensilage, I reply 
 briefly. I built two silos in the summer of 1881. Each 13x19, 
 and 16 feet deep inside measurement; the walls are fifteen inches 
 at bottom, six feet below surface of ground, and battened in at 
 outside to twelve inches at top. I used concrete for the walls and 
 bottom, made by mixing one barrel Rosendale cement and four 
 and one-half barrels coarse, sharp gravelly sand. 
 
 In using this we bedded into the concrete, as the walls were 
 going up, all the field stones we could get and have the concrete 
 completely cover and fill so as to make solid work; the cost of 
 these silos exclusive of covering was about $1.25 per ton capacity, 
 estimating fifty pounds to cubic foot. I made no charge to the 
 silo for the field stone used, nor for the time in picking them 
 up and hauling to silo. These charges belong to farm improve- 
 ments, and the silo walls were as convenient as any place to dis- 
 pose of them. 
 
49 
 
 If one has stone at hand I do not see how a silo could be built 
 cheaper, certainly not if durability is considered. I have only 
 used corn for ensilage, but cannot give cost for raising, but to put 
 it into the silo including cutting up in the field and carting, the 
 cost has been 75c. to 80c. per ton. I have had three years ex- 
 perience in feeding ensilage for milk and beef, and much prefer it 
 to the same fodder cured by drying. Unquestionably the greatest 
 objection to ensilage as usually preserved is an excess of acidity. . 
 To prevent or correct this, is now the greatest problem to solve, 
 which the scientific and practical man must work out together. That 
 we are on the road to success in this direction, I fully believe. 
 
 Very truly yours, 
 
 EDWIN ALLEN. 
 
 Adams, N. Y., February 5, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen: — Your favor of the 2d, requesting me to give you 
 my experience with ensilage, is received, and I cheerfully comply 
 with your request. 
 
 In the summer of 1882, I built a silo on the north side of my 
 barn. Dimensions, fifty -four feet long, sixteen feet wide, and six- 
 teen feet deep. We excavated about ten feet deep of earth, the 
 bottom being two feet below a basement stable, this gave us ten 
 feet in, and six feet out of the ground. The silo is built with lum- 
 ber, using 2x6 hemlock, placed flat one upon another from the 
 bottom to the top, with a partition in the center, made of 2 X 12 
 plank laid flat as before; the object of laying the plank flat was to 
 have the walls strong enough to resist pressure, and also to guard 
 against frost. The side next to the barn is laid with 2x4 stuff. 
 I found this plan much cheaper than stone and mortar, as I had 
 no stone, without hauling some distance. 
 
50 
 
 I cannot give yon the exact figures as to the cost of my silo, as 
 the job was done in connection with other work, and during my 
 absence from home. I paid for excavating, ten cents per cubic 
 yard, and $9.00 per M. for hemlock timber delivered. I estimate 
 the cost to be about $300.00. 
 
 The capacity is supposed to be about 260 tons. In September I 
 came home to superintend the work of putting into silo seven acres 
 of corn that had been drilled in especially for ensilage 1 found 
 on my arrival home that the walls of the silos were not finished. 
 They were not made smooth as I expected, but were left in a 
 rough and uneven state. 
 
 As the help were all engaged, also machine for cutting, we 
 used your Little Giant Cutter, No. 16,) and my time limited, we 
 cut the corn into the silo in its unfinished condition. 
 
 The cutter did good work, and we put the corn in without 
 much hindrance, except rain hindering us about a day. When 
 ready to cover I could not obtain the right length lumber of any 
 kind to cover with, and I used such as I could find, any and all 
 lengths. I could not get a perfect cover. We weighted with 
 bai'rels of sand, about 100 pounds per cubic foot. Owing to the 
 uneven condition of the walls which resisted the pressure, and the 
 bad covering the ensilage did not keep well, but the only spoiled 
 ensilage was around the sides of the silo ; at one end where the 
 silo had been finished with smooth boards, the ensilage was in good 
 condition. The quantity spoiled was about six inches in from sides; 
 all through the center from top to bottom, the ensilage was in good 
 condition, and the stock ate it with a relish as long as it lasted ; the 
 result of my first year's experience showed me that I must have 
 smooth walls in order to have perfect pressure, and that the ensi- 
 lage must be kept air tight. The result of my second year's trial 
 of ensilage has proven more satisfactory. During the season the 
 wall had been made smooth by being lined with matched and 
 planed lumber, the ensilage was well trodden and packed as it came 
 into the silo from the cutter. 
 
51 
 
 When all in we covered with plank cut to fit, and weighted same 
 as before, and with loose sand about eight inches deep all around 
 the sides of the silo to keep out air. sealed up the door of silo 
 with water lime. Ensilage put in about the 25th September, and 
 silo opened about the 15th November, and ensilage found to be 
 in good condition, and keeping all right. At the time of opening 
 •silo the weight was all removed; this should not have been done, 
 as ensilage must be kept weighted until required for feeding. The 
 ensilage this winter has kept well, until quite recently, when some 
 of it which had been a long time exposed with weights off was 
 affected by the air. Only as much as is required for present use 
 should be uncovered and the rest should be kept covered and 
 weighted until wanted. 
 
 Stock like it and do well on it as a general thing. My corn was 
 badly bitten by frost the past season, spoiling all the leaves, which 
 has to a great extent affected the quality of the ensilage. 
 
 The cost of raising a crop of corn for. ensilage is the same as for 
 grain ; the cost of putting corn into silo, is governed by circum- 
 stances, the quantity grown per acre, and the distance of silo from 
 crop. I estimated I had about ninety tons from six and one half 
 acres of ground, and cost about $1.40 per ton to raise and put in silo. 
 I think now I can raise corn and put in silo at a cost not to exceed 
 $1.00 per ton. One acre nearest the silo put in the first season, on 
 which was twenty tons corn fodder, green, cost on a careful esti- 
 mate ninety cents per ton to grow and put in silo. 
 
 Good soil, good seed, good tillage, and a favorable season, will 
 make cheap ensilage. I am wintering eighteen head of stock, two 
 horses, six hogs. I have only thirty-two acres plowed land on a farm 
 of sixty acres. Before I built my silo the farm would barely keep 
 a half-dozen cows and team; now I know I can keep twenty-five 
 cows and a team the year round. Silos can be built much cheaper, 
 and for much less money than mine ; fifty to seventy-five cents per 
 ton capacity ought to build of lumber that will keep ensilage. 
 
 My statement is quite lengthy, more so than I intended, and still 
 
» 52 
 
 much more might be said. I believe ensilage is a good healthy 
 food for cattle, and the silo system for keeping stock should be 
 generally adopted in this country; and I believe as good butter can 
 be made from it as any other feed used in connection with grain. 
 Very respectfully yours, 
 
 G. S. NOTT. 
 
 Ferry Cliff Farm, Bristol, R. I., March, 1884, 
 E. W. Ross & Co.: 
 
 The conflicting reports regarding the preparation of. and the 
 benefits to be dei'ived from feeding ensilage, has made it difficult 
 for an owner of live stock to determine whether he would do well 
 to adopt the system or not. Some of its advocates have written 
 as if green fodder might be saved by putting it into any kind of 
 an enclosure, air tight or not, and applying pressure, little or 
 much, as the operator might select, and there are those who would 
 have us believe that stock might be fed upon the resulting fodder 
 ad libitum, and that beef, mutton, and milk, would be produced 
 for almost nothing, as the reward of this slip-shod husbandry. 
 
 It is not remarkable, as many have been influenced by this teach- 
 ing, that failures have not been uncommon, nor can it be wondered 
 at that those who are willing to decry the silo as a means of pre- 
 serving green fodder, may be found in many quarters. The pro- 
 cess might with reason ask "to be saved from its friends." The 
 process of preserving fodder by putting it into a silo and promptly 
 applying heavy weight, is, in fact, accomplishing on a large scale 
 what is done in canning vegetables. 
 
 It is too late now for any one to pronounce canning a failure, 
 because a certain lot of tomatoes sealed up twenty -four hours after 
 filling, are found spoiled upon subsequent opening. 
 
 The construction of the silo may be ever so simple, and its sides 
 
53 
 
 may be made of any convenient materia], but its walls must be 
 plumb, smooth, and it must be air and water-tight, and strong- 
 enough to withstand the side-thrust which result from the weight 
 of the fodder, and that which is put upon it to produce pressure. 
 In most cases it will be, in the end, cheaper to build the silo walls 
 of stone, or brick, or concrete, cementing smoothly the sides and 
 the bottom, not forgetting to drain the ground when that is neces- 
 sary. It is a very common mistake to make the silo too large. It 
 is better to build several small ones rather than one as large as all 
 combined. The largest silo should have no greater capacity than 
 can be filled and weighted within two days. Beside the absolute 
 certainty of saving fodder put away with this promptness when 
 sufficiently weighted, there is the added advantage of taking off 
 the daily allowance from the entire upper surface rather than cut- 
 ting down at one end of a large silo. In the former case, there is 
 no part of the fodder exposed long before it is used. 
 
 A silo filled with corn cut immediately upon being brought from 
 the field, and trodden as the filling progresses, which is topped off 
 and weighted with 300 lbs. to the square foot, within thirty-six 
 hours after the filling has begun, will turn out good, juicy, bright, 
 healthful fodder with absolute certainty. I will not say that good 
 ensilage has not been made, that has not had different treatment, 
 but to proceed in this manner is sound theoretically, and the results 
 may be confidently relied upon. 
 
 Lt is not remarkable that a food so easily prepared in large 
 quantities which nine cows out of ten will in winter time eat, in 
 preference to the best June cut hay that can be put before them, 
 should be given with a free hand. I believe that to this abuse of 
 ensilage more than anything else is clue the opposition that some 
 give to this method of feeding. As an exclusive diet it is proba- 
 bly no better for a cow than sour-krout and beer would be for a 
 man, but fed in small quantites it supplies a useful variety of diet, 
 and provides a succulent food at a season when such food is 
 scarce, and very useful. In this respect it fills very much the 
 
54 
 
 same place that roots occupy. Theoretically the chemist may tell 
 lis that well-cured hay differs from grass in that its moisture 
 (water) has been evaporated. Were this strictly true from the 
 herdsman's standpoint, i. e., would only be necessary to add moist- 
 ure to hay at the time of feeding to make it equivalent to June 
 grass, and yet any practical man knows this is not the case, and 
 that butter and milk made from hay, differs most essentially, both 
 in color and quality, from that made when the cow is fed on grass. 
 The difference between the feeding value of dried corn fodder, 
 and corn preserved in a silo, is probably greater than that known to 
 exist between hay and grass. Practically it is very difficult to 
 cure corn fodder, cut before the grain has ripened, when much of 
 the succulence and nutrition ultimately to go with the ripened 
 grain is still in the stalk and must be put to the credit of the silo, 
 that it takes the plant at this stage and preserves it with certainty 
 for future use. This process of preparing ensilage, however, has 
 an improving effect upon the plant. The fodder thus treated, 
 owing to the fermentation which has taken place, has been 
 rendered more digestible, and the feeding value of any nutrient 
 is in proportion to the ease and the rapidity with which it can be 
 appropriated to the needs of the body. A degree of acidity is 
 not incompatible with the good quality and digestibility of the 
 ensilage, indeed, the gastric juice is complete and in operation as a 
 digestion fluid if deprived of its proportion of muriatic acid. 
 
 That ensilage should be more easily digested, and therefore 
 more nutritious, than either fresh or dry corn fodder, is no more 
 remarkable than that koumiss should he so much better as an 
 article of diet, in many cases, than the best fresh milk. Koumiss 
 is nothing more than fermented milk, and many physicians of 
 large experience are constantly using it, and have seen numerous 
 cases where it would be impossible to give milk under any other 
 article of diet, when koumiss is readily taken and retained. It 
 would seem as if through the process of fermentation it had 
 been carried on one stage in the process of digestion, and that 
 
55 
 
 thus far it could be more readily appropriated or assimilated in 
 the stomach. When farmers come to regard the preparing of 
 ensilage as a chemical process, which with proper manipulation 
 and care may always be relied upon to give uniform results, and 
 will consider the food thus preserved as a valuable adjunct to 
 their winter supply of feeding stuff rather than material fit to 
 supplant all others, the true value of a silo will be appreciated 
 and acknowledged, and a silo will be regarded essential on very 
 well ordered farms. 
 
 H. M. HOWE. 
 
 Chakl^ston, S. C, February 8, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen : — In reply to your circular, I will state generally 
 that my silo was formed by excavating into the side of a well- 
 drained clay hill, a pit of the capacity of full 150 tons, sides sup- 
 ported by rock, walls of the thickness of 15 inches. 
 
 The ensilage from corn, Indian, cut in roasting ear \ inch in 
 length, well trodden by two heavy men, always in motion during 
 the cutting. The excavation was greatly facilitated by the use of a 
 scoop and yoke of oxen in the removal of the earth from the pit, 
 and may have been used in packing, in the place of two men, had 
 it not been objected to for its want of cleanliness. After filling, 
 1 8 inches of clean straw was placed all over the ensilage and then 
 well fitted boards, heavily weighted with stones, and over all a 
 good roof, extending 18 inches from the wall, so as to protect the 
 silo from rain and moisture. Cost including Ross Cutter, about 
 $600.00. 
 
 , Along with my corn I placed one layer of green clover cut and 
 used in with oat straw. My manager, Mr. Wood, writes me that 
 his beeves from the first feed greatly relished the corn ensilage, 
 
56 
 
 feeding each 50 lbs. per day, but was comparatively indifferent 
 when fed on the mixture of clover and oat straw. Mr. Wood, a 
 practical and well-educated Scotch farmer, is greatly pleased with 
 this, his first experience with ensilage, but does not recommend it 
 as a feed alone; his system is to give a full ration of hay and corn 
 with this addition; his beeves thrive^ satisfactorily; so much so that 
 in future he will reduce materially his turnip crop, upon which he 
 formerly depended in a great measure, preferring the ensilage, not 
 only as food, but far less expensive in the cultivation of corn over 
 turnips. 
 
 More accurate information may be obtained by addressing Mr. 
 Wood, Calhoun, Transylvania (Jo., N. C. 
 
 Should this crude statement prove worthy of publication, 1 
 prefer that my name should not be used, but you may substitute 
 that of my farm. 
 
 VALLEY HOME, North Carolina. 
 
 Salisbury Center, Herk. Co., N. Y. 
 E. W. Ross & Co., 
 
 Dear Sirs: — Agreeable to your request, I herewith send you 
 some items of my experience with the silo and ensilage system. 
 I will not give detailed account of construction, only say we used 
 a small bay in one end of barn. Excavated twelve feet below 
 sill and planked up ten feet above. Have used it two seasons, first 
 with corn exclusively. 
 
 This season, 1883, put in thirty-five tons, "so estimated," of 
 green clover, when nicely in blossom, put on pressure at the rate 
 of 1,000 to 1,100 lbs. to the square yard. When time to put in 
 corn, removed weights, and filled up with about same quantity of 
 corn and weighted as before. 
 
 When opened, found it bright and nice, and well preserved. 
 Stock are very fond of it. When ready to fill silo, having no 
 
57 
 
 ensilage cutter, and as it would be less expense, and we could per- 
 form the labor more within ourselves, were disposed to put it in 
 whole. But I don't claim this method to be the better way. If 
 cut fine when siloed, no doubt it will pack closer, and I think it 
 may contain less acidity when opened for feeding. Enables stock 
 to masticate and dispose of it with more ease, and better relish ; 
 therefore would much prefer the cutting process. Our plan of 
 feeding is one ration of ensilage per day in the morning, average 
 from 20 to 25 lbs. to each cow. At evening, about what dry fod- 
 der they will dispose of. Find that stock does better than to con- 
 fine them to either exclusively. 
 
 In feeding corn or clover ensilage, stock seem to have but little 
 preference, and very little variation in quantity of milk changing 
 from one to the other. We have no accurate account of the ex- 
 pense of building silo; my estimate, which I think is nearly correct, 
 is $150.00. In filling silo we find it less expensive to put corn 
 into ensilage, than the old method of binding, and stouting up. I 
 think the time will soon come when the silo and ensilage system 
 will be more practically and better understood, and will be pur- 
 sued with as little complexity and difficulty as most any other farm 
 labor, and be of immense value to the farming community. No 
 doubt the benefit of feeding ensilage to stock is not so fully ap- 
 preciated as its merits deserve. Years before this discovery, or 
 practice of feeding, we were troubled every year more or less 
 with cows not doing well, when coming in, but, with our present 
 practice of feeding, I think there has not been an instance that 
 they have not disposed of after-birth within two or three hours' 
 time. It seems to be congenial to the nature of stock, keeps 
 them strong and thrifty, and so far as my experience goes, am 
 fully satisfied with its results. 
 
 My estimate favoring the feed of ensilage may be in part owing 
 to the farm we cultivate, which makes the advantages more practi- 
 cable. Some parts of it are light and sandy, not adapted to grass. 
 If seed is sown, it is nearly thrown away, growing not more than. 
 
 5 
 
58 
 
 half a ton per acre. But by plowing shallow with good tillage, 
 and sowing corn with grain drill, nearly two bushels per acre, and 
 about 250 lbs. of fertilizer with corn in drill, this method gave 
 satisfactory results. 
 
 We use southern white corn for seed. Those having poor farms 
 and keep dairy of cows, I think would find it greatly to their 
 interests to adopt the ensilage system. 
 
 Respectfully yours, 
 
 DAVID TUTTLE. 
 
 SILOS AND ENSILAGE. 
 By V. D. Taylor, South Richford, Vt. 
 
 PRELIMINARY REMARKS. 
 
 In attempting to say a few words upon the above subject, I am 
 well aware that the ground that I am about to tread upon is con- 
 sidered by a large majority of people at the present timeas debat- 
 able, and also that there are people who are so bitterly opposed to 
 the ensilage system, that they persistently shut their eyes to all 
 facts in the case, totally ignoring everything that has been proven 
 by experiment during the last two years, claiming that the theory 
 is a humbug, and that money invested in building silos is worse 
 than thrown away. 
 
 Now all I have got to say to the latter class of people is, come 
 over and examine my silo and ensilage, and see for yourselves 
 whether or not I have exaggerated anything in any of my state- 
 ments ; and to the former, that I stand ready to debate with them 
 at any time and place they may see fit to appoint. 
 
 The practical solution of the saying: " Be not the first nor the 
 last to try an experiment," has proven of inestimable value, times 
 without number, to these who have had the nerve and pluck to go 
 
59 
 
 ahead without waiting for somebody else to demonstrate beyond a 
 doubt that the theoretical solution of an untried proposition is 
 correct. 
 
 Solomon tells us somewhere in his writings that there is nothing- 
 new under the sun, and as far as preserving ensilage by storing it 
 in pits in the ground is concerned, we are told that the art is as 
 old as the hills; and who knows but what Noah may have had a 
 silo in his ark. If I remember aright, science has not given us 
 any light upon the antiquity of this point, although we are told 
 from this source tha,t there is nothing in ensilage but water. I 
 have great respect for science, and 1 am also glad that there is 
 such a thing as theoretical knowledge, for were it not for the lat- 
 ter we should not be led to try experiments; but as to the former, 
 I do not believe that it will prove profitable to any man in the long 
 run to be led blindfolded by scientific sophisms contrary to reason. 
 An all-wise Providence has implanted within the head of every 
 thinking individual a desire to investigate, but the spirit of old 
 fogyism is yet rampant in the land, and views with equal distrust 
 the attempts of science to establish a truth and the vindicators of 
 theoretical knowledge to prove by practical experiment a hypo- 
 thetical supposition. Smith says, there is a propensity to push theory 
 too far; but what is the just inference ? Not that theoretical propo- 
 sitions of any considerable comprehension or extent should, from 
 such their extent, be considered to be false in toto, but only that 
 in the particular case inquiry should be made whether, supposing 
 the proposition to be in the character of a rule generally true, 
 an exception ought to be taken out of it. It might almost be im- 
 agined, to hear some people talk, even in this, the 19th century, 
 that there was something unwise in the exercise of thought. I am 
 not given to speculation. I am no friend to theories. Can a man 
 disclaim theory, can he disclaim speculation, without disclaiming 
 thought? Again, to quote the above-mentioned author, '• when reason 
 is in opposition to a man's interest," he ought to have said his future 
 inclination, " his study will naturally be to render the faculty itself, 
 
60 
 
 and whatever issues from it, an object of hatred and contempt." 
 The sarcasm and other figures of speech employed on the occa- 
 sion are not directed merely against reason, but against thought, 
 as if there was something in the faculty of thought that rendered 
 the exercise of it incompatible with useful and successful practice. 
 Now, would not it be well for men who feel an uncontrollable 
 desire to brand every new idea as speculative, to take a look into 
 the merits of the particular case which they are branding as theo- 
 retical, visionary, chimerical, and all humbug, before they give us 
 the benefit of their sarcasm, as they have upon the ensilage ques- 
 tion? — and when they have demonstrated by practical experiment 
 that the theory is a humbug, then we will take their say, so far, for 
 what it is worth ; but in the meantime we who know the theory is 
 correct will do what we can to bring the system to perfection by 
 building more silos, thus proving our faith by our works. Now, 
 brother farmers, I am not going into a long dissertation upon the 
 ensilage question, but I shall just give you my practical experi- 
 ence in as brief a manner as possible, and you who have a desire to 
 increase your stock and enrich your farms at the same time, just 
 read the following experience carefully, or give me a call*, and I 
 will show you how you can double your stock the first year, and in 
 less than three years how to keep twenty-five cows on six acres. 
 
 THE WOODEN SILO. 
 
 My silo is built entirely of wood, directly under my upper barn 
 floor. When I built my barn, I built with the intention of having 
 two silos under the floor, if I liked the first experiment. My first 
 experiment is a success, and accordingly I shall finish off another 
 silo the coming season. A wooden silo can be built of one hun- 
 dred tons capacity, that will not cost over fifty dollars, if a person 
 has timber so that he can get out his own lumber. The cheapest 
 way to build is to build with matched lumber, single board, and 
 stuff with sawdust. I built mine by putting 2x4 ribs on to an 
 eight-inch wall, boarded the outside up and down upon the girts, 
 
61 
 
 and the inside upon the ribs horizontally, thus making a strong 
 wall, and giving me ten-inch space to stuff with sawdust; the size 
 of silo is 13 x 18 on the ground, and fifteen feet high up to the 
 upper floor. I can put in ensilage thirty feet deep by taking out 
 a section of the barn floor, when I am filling the silo, thus making 
 it hold twice what its natural capacity would be were it not finished 
 above the floor ; the bottom of sild^is nearly on a level with my 
 stable floor, a door opens directly into the feeding floor of the sta- 
 ble from one corner. I make this door tight by putting in matched 
 boards on the inside and stuffing from above with sawdust. 
 
 One of the most important features in building a silo is to have 
 it so constructed that you can feed out the ensilage without being 
 put to too much trouble, and you can just as. well have it handy 
 as otherwise, if you will just use a little common sense in planning 
 the silo from the start. You must bear in mind, when building, 
 that you have got to feed out the ensilage, as well as to put it in, 
 and that the filling-time occupies but a short period, while the feed- 
 ing-time lasts all winter. 
 
 FILLING THE SILO. 
 
 I was six days in filling my silo. Commenced to fill it September 
 16th. The corn was badly frosted, consequently I did not expect 
 any very good results from my ensilage this year, but I have been 
 very agreeably disappointed. I put in about twenty tons of white 
 western corn sowed especially for the purpose, and three acres of 
 oats, and on top of that my field-corn fodder, after picking off the 
 ears, and top of that about a foot of rowen. I cut the whole of it, 
 with the exception of the rowen and about a foot of corn fodder, 
 into half -inch lengths, with a one-horse power and a Ross Fodder 
 Cutter. That which I did not cut I put in for the purpose of try- 
 ing an experiment, and it has convinced me that the right way to 
 put in ensilage is to cut it up, as the cattle cannot eat the large 
 stalks unless they are cut up fine After getting all my fodder into 
 the silo, I covered it with matched boards, and weighted with 
 
62 
 
 stone, putting on about one hundred pounds to the square foot. 
 (It is very important to have the boards cut just the right length, 
 for if they crowd on the wall and do not settle clear, the ensilage 
 will not pack hard enough to keep out the air.) I believe that it 
 does not make any difference how long you are in filling a silo, if 
 you only keep at it until you get it filled. At least, the length of 
 time that I occupied in filling mine would seem to indicate that 
 the above inference is correct, as mine came out in good condition, 
 and continued so, with the exception of the oats, until the last of 
 it was fed out. 
 
 MY EXPERIENCE IN FEEDING ENSILAGE. 
 
 I commenced to feed ensilage the 11th day of November, and 
 fed it clear for seven days to twenty-four head of cattle. Before I 
 had completed the fourth day my cows had gained up double in 
 their milk. At the end of the eighth day, I commenced to mix 
 my ensilage with cut hay, mixing it about half and half, and feed- 
 ing three bushels a day up to the first day of February; then I 
 commenced to mix a bushel of shorts a day with the feed, mixing 
 up the three feeds together, and letting it stand over night. My 
 cows never looked better than they do at the present time. They 
 commenced to gain in flesh as well as milk almost immediately 
 after commencing the new " departure," and have continued to 
 gain up to the present writing. 
 
 If any one is skeptical or doubts what I am stating, I can refer 
 them to scores of visitors that have visited me during the past 
 winter for the purpose of seeing the "rotten stuff," and among 
 all that have interviewed me, I have yet to learn of a single indi- 
 vidual who has gone away without coming to the conclusion that 
 there is something in the "Ensilage System" besides "Humbug." 
 I have not fed fifty pounds of good hay since 1 commenced to feed 
 ensilage. The hay I have been cutting is poor, late-cut stuff, con- 
 sisting chiefly of wild grass, brakes, and weeds. I have enough 
 ensilage left to feed a month longer, which will make, in the whole, 
 
 
63 
 
 fully five months of feed in connection with, the hay mentioned 
 above. Now, in view of these facts, taking into consideration the 
 amount of ensilage that I had in the start, " estimated to be forty 
 tons," the length of time that I have been feeding, the number of 
 head of cattle fed, and their condition as they appear ac the pres- 
 ent time, I am led to believe that the corn fodder undergoes a 
 process of fermentation while in the silo that adds greatly to its 
 nutritive value. I am not a chemist, consequently I cannot give 
 the relative constituents of the ensilage that I have been feeding; 
 that it is rich in nitrogenous, free extract substances, such as 
 starch, sugar, etc., I cannot doubt; at least, T am willing to take 
 the testimony of the old red cow upon this point without putting 
 it to a chemical solution. At any rate, I am not going to denounce 
 it as "'nasty, stinking, unhealthy stuff," as long as old Red continues 
 to prefer it to the best of hay or even meal. 
 
 ''CUTTING AND SHREDDING." 
 
 There has been a machine invented for shredding ensilage, 
 which consists of small circular saws set close together on a 
 horizontal shaft. The shredding operation consists in running 
 the corn fodder over the saws lengthwise. Now, as far as getting 
 the ensilage out of the silo is concerned, it would be just as 
 hard work to get it out if it were shredded as it would the whole 
 corn fodder, and then it would be just as bad stuff to mix 
 with any other feed, as uncut hay, and I would not take a silo full 
 of uncut corn fodder if 1 could have it given to me free of cost, 
 unless I was in the same position of the stuttering old farmer, who, 
 when asked if it paid to manure corn in the hill, replied, "yes, 
 if you have got a lot of boys that you don't have to hire." Still, 
 notwithstanding the fact that it is hard work to get it out of the 
 silo, some are putting in the fodder whole, and seem to like the 
 process well. This is no argument against cutting, but an argu- 
 ment in favor of the silo, for if it pays to put it in whole, it is 
 much more profitable to cut it, for this reason: when ordinary corn 
 
64 
 
 fodder is fed without cutting, the animals reject the hard lower 
 parts, and of this a large percentage finds its way to the manure 
 pile, making the manure very difficult to manage or handle, while 
 if it is cut up fine it is very easy to handle or to mix with any- 
 thing, and cattle will eat it all up clean. 
 
 Eochester, March 10, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen: — Your kind letter came duly to hand, in which you 
 requested me to give my experience on silos and ensilage. I will 
 gladly do so, as I do not think anything has been discovered with- 
 in the last ten years that will benefit the farmer so much as the 
 process of keeping green fodder for his stock through the winter. 
 
 Two years ago I built a silo of stone, the walls being twenty 
 inches thick, laid up in water lime. As my farm is on the Gen- 
 esee flats, and is liable at certain seasons of the year to be over- 
 flowed, I was obliged to build above ground, with the exception of 
 four feet. 
 
 The dimensions are: 30 feet long, 16 feet wide, 20 feet deep. I 
 used in its construction 50 bbls. water lime. It is plastered on 
 the outside five feet high, on the inside to the top, with a grout 
 bottom five inches thick. It will hold from 180 to 200 tons; were 
 four days filling it. As soon as full we put on the cover and 
 weights, amounting to 300 lbs. pressure to the square foot. Did not 
 open it until six weeks later, when I found it perfectly cool and in 
 splendid condition. L sowed Burrell & Whitman's southern 
 sweet corn, believing it to be the best that grows for ensilage. I 
 have raised twenty tons to the acre for the past two years, and 
 expect this year to get thirty. 
 
 I am milking thirty-five cows, and find that ensilage will pro- 
 
65 
 
 dues more milk than anything I can feed, as my contract will not 
 allow me to feed brewers' grains. 
 
 Last winter I fed thirty nine head of stock five months and 
 twenty days, with the ensilage I put up in September, giving each 
 cow two bushels per day with a feed of dry corn stalks at noon. 
 The cost, including seed corn, plowing, planting, cultivating, cut- 
 ting, drawing, and filling silo, was 1 $1.18 per ton. This does not 
 include the cost of silo, which was $350.00. It is a pleasure to 
 see the cows eating green corn in the month of December, when 
 the ground is covered with snow, and not a green thing to be seen 
 around the farm excepting what the silo contains. 
 
 I am satisfied that the time is not far distant when you Mall see 
 every farmer with a silo. I would not take three times the cost 
 of mine, if I could not have another. "While I am speaking of 
 ensilage, I want to say a word about the Ross Ensilage Cutter. I 
 tried two cutters before buying the Little Giant, manufactured by 
 E. W. Ross & Co. I believe it is the best machine made for 
 cutting ensilage. The only fault I find with it is that we cannot 
 get the corn to it fast enough. 
 
 Hoping soon to have the pleasure of reading the experience of 
 your many customers and friends, I remain, 
 Respectfully yours, 
 
 E. A. LODER. 
 
 Gayloedsville, Conn., March IV, 1884. 
 E. W. Ross & Co., 
 
 Sirs : — In answer to your inquiry on ensilage, I would say I 
 find it a pretty good feed. I do not consider it as valuable as 
 some, neither do I consider it as worthless as some others. I find 
 it does well when fed once or twice a day, with some hay and 
 grain between times. I do not think I get the flow of milk that 
 
66 
 
 smae pretend to get. My silo is built mostly under ground; can-- 
 not give the exact expense, as barn and silo were built at the same 
 time. I have no faith in cheap silos built above ground, as they 
 will soon wear out, and be very inconvenient to fill and weight. 
 
 Ensilage should be put into the silo dry, as it will not mould 
 when exposed to the air at feeding-time, which it will if put in 
 when wet. 
 
 Yours truly, 
 
 JOHN FLYNN. 
 Litchfield County. 
 
 Haeneestown, Monmouth Co., N. J., February 28, 1884. 
 Messes. E. W. Ross & Co., 
 
 Dear Sirs : — Tn reply to your inquiry, asking my experience of 
 ensilage, etc., I would state, that my silo cost about $350.00, is of 
 brick, five feet below and ten feet above ground, with a wooden 
 building on top five feet high with a shingle roof, with two tie 
 beams across directly over and forming a part of the partition in 
 ths silo; inside measurement, 30 feet long, 12 feet wide, 20 feet 
 deep. 
 
 The walls are 9" thick, with four places on each side 14" thick 
 by 18'', to give more strength. The bricks are laid in cement 
 mortar. Bottom and sides cemented. Doors in end next to 
 stable one foot above top of ground. 
 
 For two years I filled it all in one silo, taking five days to fill it. 
 I then divided it into six compartments so that I could fill and 
 close a section each day, and I like it much better than having one 
 large silo. The silo is divided by a partition lengthwise and two 
 cross-ones made of two-inch plank, tongued and grooved, except 
 six feet of cross partitions, above level of bottom of outside 
 doors, where the planks are put in so that they may be removed in 
 
67 
 
 taking out the ensilage; that space is covered with building felt 
 before filling. In feeding it out I remove the entire cover from 
 the section. 
 
 I covered the doors with building felt to make them air-tight. 
 I covered the ensilage with two layers of inch boards, broke 
 jointed, and weighted with stones, about 1,500 lbs. to square yard. 
 The silo stands 14 feet from the stable. I use a two horse railway 
 power standing in second story of stable. 
 
 The corn is- brought to the cutter on wagons, and is cut about §■ 
 inch long, and taken in at top of silo by means of large barrows, 
 holding some eight bushels, and dumped. I keep it well trodden 
 while filling. My way of raising the corn is to prepare the ground 
 as for wheat, and about the 10th of June I sow it, using a grain 
 drill, shutting off all but two tubes, planting the rows about four 
 feet apart and about eight grains to the foot. 
 
 The cultivation consists of running the cultivator or horse-hoe 
 through it twice. 
 
 The cost of growing, putting in silo, and weighting it, has been 
 for three years about $1.22 per ton, not including rent of land. 
 I found the ensilage good in contact with the wood partitions, and 
 some three inches of waste next to the brick; that leads me to 
 believe that wood will keep it better than bricks — any cheap 
 wooden structure will keep it better than the very costly ones, 
 but they must be air-tight, which can be easily done by lining the 
 inside with roofing felt. 
 
 I had great doubts about the practicability of the system, for it 
 seemed to me to be so unreasonable to keep corn in a green state, 
 and to add to my doubts, such great things were claimed for it; so 
 I thought I would go slow in the matter. In the fall of 1879, I 
 dug a pit, five feet deep, eight feet wide, and fifteen feet long, and 
 filled it with Stowel's Evergreen corn, cut in f inch lengths. The 
 pit was lined with, and ensilage covered with, 3 inches of straw 
 covered with 2 feet of earth. When I opened it the following 
 
68 
 
 March, the sides and bottom were somewhat spoiled, but the greater 
 part was a splendid feed. 
 
 The cows ate it readily, and increased at least ten per cent, in 
 their milk, and the quality was so much better that, on delivery 
 to the creamery, the foreman remarked that it looked like grass 
 milk, and asked what I was feeding. I have since shipped milk 
 to one of Philadelphia's largest milk-dealers, and he requested some 
 of his other customers to find out what I fed my cows on, and for 
 them to feed the same. 
 
 I have nearly doubled the cows T kept before using ensilage. I 
 feed it to all my cattle, from six months old. I feed full-grown 
 cows forty pounds per day, and from two to eight pounds of grain, 
 and once a day a bundle of corn fodder; on wet days a little hay. 
 After my experience, I fully believe in the system, and that cheap 
 wooden silos will keep it, that more than double the number 
 of cows can be kept, and that it is the cheapest and best food we 
 can get. The best ensilage I have had, has been of sweet corn, 
 cut when you could pull some for boiling, and the poorest when 
 less than half of the stalks showed silks for ears. It is most im- 
 portant when filling to keep it of equal compactness. 
 
 NICHOLAS WALK 
 
 Gorham. Maine, February 4, 1884. 
 E. W. Ross & Co., 
 
 Gentlemen : — I was considering the ensilage question some time 
 before I moved in that direction, thinking that I was obliged to 
 put two or three hundred dollars into building a silo, but I found 
 out that it is not necessary. 
 
 Last summer, I prepared me a silo for an experiment. I took 
 a part of my ice-house, put a partition up with seven-incb plank 
 edgewise, boarded each side with hemlock boards, and filled space 
 
 
69 
 
 with sawdust. My silo is 15x20 and fourteen feet high, all out of 
 the ground. Then I ordered a No. 14 Ross Cutter, which is not 
 second to any, and I can cheerfully recommend it to all my brother 
 farmers as being all that is claimed for it. I planted twenty acres 
 of sweet corn for canning, sold the corn, and siloed the fodder. 
 
 I commenced filling my silo the 5th of September, under very 
 unfavorable circumstances. The severe drouth damaged the fod- 
 der very much, and the early frost made it about worthless; so I 
 concluded that my experiment would be a failure, but as I could 
 silo it cheaper than I could dry it in the field, I concluded to per- 
 severe, and I did so. 
 
 1 filled my silo, covered it with two-inch plank, and weighted it 
 with five tons of stone. It settled about three feet. The '25th of 
 November, I opened it, and to my surprise, it was in better con- 
 dition than I expected to find it. I took about three inches from 
 the top, that was somewhat moldy, and the remainder was all 
 right ; so I concluded that a cheap silo would keep ensilage. 
 
 I have fed forty head of cattle since November 25th, and thirty 
 of them are cows, and they all eat it with a relish, and have in- 
 creased in the flow of milk, and have laid on more flesh than ever 
 before in winter. As poor as the fodder was, my cows will leave 
 the best hay and take the ensilage, and I have not a hundred 
 pounds of waste from my twenty acres of corn fodder. 
 
 I feel so well pleased with my results, that I am preparing 
 another silo that will hold a hundred tons more; but I shall use 
 the old one as long as it will last. So, brother farmers, you can 
 have a silo as well as your neighbor, with a_ small expense. I can- 
 not tell you the expense of raising it per ton. It will depend on 
 the condition of the land ; but the expense of putting it into the 
 silo, for me, was about fifty cents per ton. 
 
 Yours truly, 
 
 H. B. JOHNSON. 
 
70 
 
 SILOS AND ENSILAGE. 
 
 Walpole, N. H , January 21, 1884. 
 
 The giving my ideas of silos and ensilage, and the result of the 
 benefit derived from same, will be of little benefit, as there are 
 many who have given the subject more thought, and have been so 
 situated that the result can be given much better. 
 
 I have two silos, one built in 1 882, of wood above ground. It is 
 in the north end of what used to be a cider-mill. I cemented the 
 bottom with a coat of cement about two inches thick ; the sides are 
 double-boarded, with paper between. Dimensions, 21X10X12 
 feet. The cost of this was twenty-five dollars for the lumber and 
 cement. I did the work at odd jobs; perhaps my work was worth 
 five dollars — making the cost thirty dollars. This silo was partially 
 filled with corn fodder raised for the purpose, but the season was 
 very dry, and my crop was light; but the ensilage was all one 
 could wish, for it kept perfectly, and my stock never did better 
 than when fed on the contents of this cheap silo. I was so well 
 pleased that I concluded that I must build another, so, in the follow- 
 ing spring of 1883, 1 took a bay in one of my barns (the barn has 
 a cellar under it) for the purpose of a larger silo. 
 
 I dug down seven feet into the ground and iised stone and 
 cement for the wall. After getting up a little above the ground, I 
 used studding and double -boarded, using paper between, as on the 
 silo No. 1. This silo is now 21x10x28 feet, and a chance to 
 extend the boarding up as high as the high beams of the barn. 
 
 I planted white Southern corn for ensilage on the 25th day of 
 June, and the 3d day of September commenced filling my silo, 
 cutting it with a Ross Cutter. . The cost of putting the ensilage in 
 silo was one dollar per ton. The cost of planting and cultivating 
 was not very expensive, as I used a harrow soon after the corn 
 came up and then cultivated twice. What the exact cost was, I 
 cannot tell, as I kept no particular account of my time. I raised 
 100 tons on the 3£ acres of ground, using nothing but stable 
 manure. 
 
71 
 
 After filling my silo, I put in a layer of straw and planked it 
 over, then took some boards and laid round the edges of the planks 
 and put on stone enough to just make the plank level and no 
 more. Then put on six or eight inches of sawdust and called it 
 completed. On the 15th day of October, I opened it, and found 
 it all right, even the straw on top looked as bright as when put on. 
 Since that time I have been feeding ensilage to cows, oxen, sheep, 
 hogs, and poultry, and consider it the very best way of keep- 
 ing stock, as the cows give more milk, and of a better quality, 
 than when fed on hay. Oxen gain flesh and enjoy their feed; 
 sheep are greedy for it, and it seems to be just what they want or 
 need. Just how much this silo cost I cannot tell, as my hired 
 man and myself did all the work. 
 
 I used 30 bbls. cement, and about 2 A- M ft. of lumber, worth $14 
 
 per M. It took a good many days to do the work, but I feel 
 
 as if it was time and money well spent. The ensilage kept as 
 
 well in the first'or cheap silo, as in the other, which most persons 
 
 would call the best one. I am so well pleased with the result of 
 
 feeding ensilage the present winter, that I shall try and raise 
 
 enough to fill both another year; and the most I have to say to my 
 
 brother farmers is, if you want to keep double the stock you now 
 
 keep and keep it better, then build a silo, and you will, I trust, 
 
 never to be sorry for the money and expense you have been to in 
 
 doing it. 
 
 0. J. HUBBARD. 
 
 Baltic, Conn., March 18, 1884. 
 Dear Sirs : — I understand that you are about to issue a book treat- 
 ing on the value and the effect of ensilage. Having had some 
 experience in feeding the same for the last two years, I would beg 
 leave to ask you to look over this document and give it a place in 
 your book, if not received too late.. 
 
72 
 
 In 1881 I bought a farm in the town of Franklin, that some 
 years ago did rank among the best farms of New London county. 
 But, like other good old farms, the buildings, and^particularly the 
 land, was entirely run out, so much so that the parties could not 
 winter any more than seven head with all they could secure on 
 the place. 
 
 I had read the book of H. R. Stevens on ensilage, and the dif- 
 ferent methods of building silos. With what notions I had learned 
 from the book and people talking, I built a silo big enough to hold 
 two hundred tons, at a great deal more expense than there was any 
 need of, and I went to using corn for ensilage. 1 used what ma- 
 nure I could scrape from the farm, and spread on to 2^ acres of 
 land the most handy to the barn, and succeeded very well. 
 
 I ensilaged about sixty tons, and had no more hay than my pre- 
 decessors, but I wintered sixteen head horn cattle and four horses, 
 and in the spring, when the cattle went to pasture, I had five tons 
 of hay and about as much ensilage left. 
 
 From that time I came to the conclusion that in order to bring 
 old farms to* the good state of cultivation we must have manure, 
 and the -best way to have it is to make it by increasing your num- 
 ber of head of stock, and raise corn fodder for ensilage to feed. 
 
 Last year I sowed double the land that I had the year before, 
 but did not succeed, for the first reason that of the corn I sowed 
 more than half the seed did not come up, and then frost in the 
 fall cut it very badly, so that I could not increase my stock any; 
 but I have enough to winter the same number of head. Next fall 
 I expect to be able to winter thirty head. I believe that silos 
 will redeem the New England farms, provided that every farmer 
 builds one and fills it properly. It is not much of a job to build a 
 silo; you can build of wood or stone, cheap. As to the filling of 
 silos, there are various opinions about the time one should take in 
 filling, and in regard to that, I think the quicker they are filled 
 and weighted the better. 
 
 The first year I cut my ensilage with a two -horse tread -power 
 
73 
 
 and No. 42 Cycle Cutter, and it gave me very good satisfaction. 
 We did the work well, and in a hurry; but last year I bought a No. 
 14 Ross cutting machine, and with the same power I did the work 
 to a better satisfation, and kept all my men on the run to keep it 
 a running. It is the most reliable, easily fed, and no grinding to 
 the knives, as we had to do with the Cycle machine. I worked 
 the machine three days, and did not grind the knives, and did the 
 work nicely. As to the experiment of feeding ensilage to see its 
 •effect in milk, etc., etc., I am not able to say anything about it, as 
 I have not made any as yet. Yours, 
 
 P. S. COTE. 
 
 Preston P. 0., Conn., March 2, 1884. 
 Messes. E. W. Ross & Co., 
 
 Gentlemen: — In building my silo I excavated ten feet deep, 
 and built the stone-work three feet above, and banked up with 
 dirt, making thirteen feet of stoning, on top of which I put a wood 
 frame 12 x 20 feet, with eight-foot posts. 
 
 Part of the stone-work was laid dry and grouted with cement 
 mortar, and part was laid dry and pointed, and plastered with the 
 same. On the inside, above the stone, I put on one covering of 
 matched chestnut boards, and over that one covering of matched 
 pine and spruce; estimated cost of excavation, $50.00; estimated 
 cost of whole concern, $300.00. . Last of May, and first of June, 
 planted Southern white corn three feet apart, in rows eighteen to 
 twenty-four inches between the hills, with one handful of Coe's 
 phosphate to three hills, with manure spread on a small part; corn, 
 manure, and phosphate the year previous on the same land. 
 
 September 3, 1883, began to fill silo, and in five days put in four 
 acres, filling silo eighteen feet and six inches after the covering 
 was on. I covered it with two-inch oak plank, with a six-inch 
 6 
 
74 
 
 "board under under each seam. Settled just one-fourth of the 
 depth. Cut with a two-horse-power and a Ross Cutter No. " 14A," 
 which runs beautifully, and I don't think it can be beat by any- 
 thing of its size. I cut my ensilage one-quarter inch, but am now 
 inclined to think that one-half is better. The fine cutting on the 
 large fifteen-inch pulley that came with the cutter made slower cut- 
 ting than it otherwise would have been. In filling I had one man 
 in silo to spread it even, and one to tread, and some of the time, 
 more. I don't think heavy treading is so essential as it is to see 
 that all parts are kept equally full and hard, as I think if there is 
 any soft spots they will be liable to be moldy. I commenced 
 feeding one bushel a day to twenty-four head of cows and heifers 
 the 7th of November, and I think it will last them until about. 
 May. They seem to like it, and will eat it in preference to the 
 best of hay, although it is quite sour, and has a decidedly vine- 
 gary taste. The first cutting that I took out had several inches of 
 juice in the bottom, and a disagreeable smell. I think I- cut my 
 corn too young. I now believe it should be planted thin enough 
 to form some ears, and they should be ripe enough to eat. I have 
 planted fodder-corn twenty-five years or more, more or less, and 
 have found, by experience that if fed before it is spindled, it would 
 diminish the quantity of milk and injure the quality of butter. If 
 we can put poor feed into the silo and have it come out good, it 
 must be very remarkable. I think the silo should be adjoining 
 the stables, and nearly on a level with them. I don't like hoisting 
 up when it is so much easier to throw down; for a wood silo, I 
 would board up inside with two coverings of rough boards, or one 
 thickness of two inch-plank, and then lath it and plaster with 
 cement mortar. When I first began to read about this ensilage, 
 business, I thought it was all studied out and perfected, but 1 now 
 think there is much to be learned yet. I went through my corn 
 once with cultivator and hoe. What I did not feed green, or put 
 in silo, I cut and set up in large shocks, and let stand until I fed it! 
 
 ANDREW AVERY. 
 
75 
 
 New Yobk, April 2, 1884. 
 Messrs. E. W. Ross & Co., 
 
 Gentlemen: — Tn reply to yours of February 4th, in reference to 
 ensilage, I can say very little, except as it comes to me from my 
 farmer. 
 
 My business proper is in this city, and I only make occasional 
 trips to the farm. I had experience on the farm in boyhood, and 
 therefore take to this business more naturally than if without any 
 experience. I never made any calculation as to the cost of rais- 
 ing or cutting. As to the former, most depends upon the richness 
 of the soil, and to get it in and store it the cost will greatly de- 
 pend upon the way it is managed. Give me land rich enough to 
 raise a good crop of corn, and I am not afraid to get in and store 
 it at a very low cost. 
 
 We have used your cutter, and a two-horse tread power, and 
 had no difficulty to cut a ton in twenty minutes, and store it in 
 silo at the same time, by means of your elevator, which carried it 
 nineteen feet at an elevation of eleven feet. Our custom has been 
 to have two men in the field cutting, two teams and one man at 
 the cutting machine, while the two men and teamster are loading, 
 while the other teamster is unloading his load, on the platform of 
 the cutter, as fast as the man at the cutting machine can feed it. 
 
 My silo was built in the end of the barn, 10x12, and 25 feet 
 deep, boarded up. It is made of matched boards, and when filled 
 we weighted it with stones from 75 to 100 lbs. to the square 
 foot. This I find sufficient for us, as we can cut our corn \ to -£ 
 inch in length. 
 
 The weighting with stone I find takes but a short time, as well 
 as the removing of them. Much has been said against the practice 
 of using stone, and the vast amount of labor attending it, etc. 
 This I presume comes from those that have no experience of farm 
 work, or from that "lazy" class who are afraid of work, and 
 never will make ensilage, or anything requiring labor, a success. 
 I have not tested ensilage sufficiently long to give that opinion you 
 call for. 
 
76 
 
 Two years ago my silos were not built in time to store a great 
 deal; and last year, in consequence of late planting, and a very 
 cold season, I was obliged to cut it before it came into tassel, lest 
 the frost would catch, it. In this condition it had not fully 
 matured, and I do not think it contains the strength it would have 
 had if stalks were in tassels. 
 
 Ensilage made from corn cut in this condition keeps well, looks 
 nice, and is free of dust. My farmer writes me, " I like to feed it to 
 the cattle. They are fond of it, and eat it ravenously. After 
 feeding it over a month with hay, and same amount of feed, fail 
 to see that they have become more thrifty or are doing any better 
 than before we fed it. The labor of feeding it is no objection to 
 silo; neither do I discover the much-talked-of taste in milk and 
 butter; nor do I think it affects either in that respect. Some of 
 the cattle can be fed on it in unlimited quantities, with impunity, 
 while with others an overdose goes through them like a dose of 
 salts. The pigs eat it sprinkled with feed voraciously, but I think 
 the feed does more for them than the ensilage." 
 
 My present farmer has only been on my place this winter, and 
 has had no knowledge as to the growth of the corn, and that it 
 was not fully matured when cut, for he adds, " corn does not 
 mature in this latitude nor do corn-stalk grow to perfection." A 
 silo filled with twelve-foot corn stalks having large ears of corn on, 
 grown in Monmouth county, New Jersey, on marl bottom land, 
 might be fed with very different results. 
 
 Sweet potatoes, grown in Virginia and Delaware, are very supe- 
 rior to those grown in the vicinity of New York ; both the flavor 
 and keeping qualities are better. Corn grows more to perfection 
 in Virginia than in my own county, Monmouth. Climate and 
 soil have a great effect on amount of nutriment contained in 
 
 plants of different kinds. 
 
 Yours truly, 
 
 J. L. OBEELY. 
 
THE EOSS 
 ENSILAGE AND FODDER CUTTERS. 
 
 To those who decide that they will adopt this system, and who 
 wish to cut their ensilage, we would respectfully call their atten- 
 tion to our line of cutters. We make a specialty of this class of 
 work and have a very superior line of machines. We would like 
 to have them examine our circular, and if they believe that our 
 machines are the best, and at reasonable prices, hope they will give 
 us a trial. We ask no one to buy our machines unless they are 
 fully up to our representations. We are perfectly willing that 
 they shall be tried beside any other make in the market, for the reason 
 that we know there are a great many cutting machines, as well as 
 other classes of goods, that are inferior and not what they are 
 ■ claimed to be, and farmers are often imposed upon by manufacturers 
 of inferior articles. We believe and guarantee our machines to be 
 the best in the world, and guarantee every cutter we sell to give 
 satisfaction or no sale. We do this as a protection to farmers in 
 general, and to our customers. We are selling cutters constantly 
 throughout the United States, and frequently receive orders from 
 foreign countries, and extreme Western States, enclosing money 
 with their order, which shows the confidence they have in our ma- 
 chines. We take particular pains to always see that these people 
 are supplied with machines that are in every way first class, and 
 that they receive full value for their money. We have done busi- 
 ness here a great many years, and expect to continue. We can- 
 not therefore afford to deceive any of our customers. We do not 
 ask anybody to keep a machine that we sell them, if they find any 
 other cutter in the market for the same price that will do the same 
 
78 
 
 work without breakage, etc. Our prices may be higher than a 
 great many inferior machines in the market, but it is not an uncom- 
 mon thing for us to sell one of our cutters to a customer when he 
 has been offered cutters from other manufacturers at from $10 to 
 $25 less money. We have never yet had a machine sent back to 
 us that we have sent out on our guarantee. Of course we do not 
 expect to sell all the machines that are sold, but it is our endeavor 
 to get our legitimate share of the trade. Our prices are no higher 
 than we are obliged to make them, and give first-class, guaranteed 
 work. "We can build cutters as cheaply as any manufacturer in 
 the world, and we do not expect any larger profits. Consequently 
 we believe that our cutters are the cheapest to buy, for they will 
 stand heavy work without breakage, and are always ready. We 
 hope that our friends who contemplate buying a cutter will send for 
 our circular and write for prices before buying. 
 Yours truly, 
 
 E. W. ROSS & CO. 
 Fulton, N. Y., April 2, 1884. 
 
IMPORTANT. 
 
 Please remember that our Machines will do double and treble 
 the amount of work, size for size, that can be done by any other 
 make in the country, and that they are heavier, stronger, and more 
 durable. Also, that our smaller sizes do equal the amount of 
 work that is done by the largest size and more expensive Cutters of 
 other makes; consequently you can buy of us a Cutter which 
 requires less power to drive it, will do better work, will not get 
 out of order, and is guaranteed to give satisfaction, for con- 
 siderably LESS MONEY than you can secure a Machine for of 
 other makes with an EQUAL capacity, while for large sizes our 
 Machines cannot be approached by several TONS per hour. 
 
NOTICE. 
 
 It frequently happens that our customers find some of the parts 
 of the machine broken or missing when they come to use the 
 machine, and at once write us for the duplicate parts, claiming 
 that the parts were broken or lost by the railroad company. We 
 in many instances have sent the extras, and charged them to the 
 railroad company receiving the goods from us. After a long 
 investigation, railroad companies have reported the goods delivered 
 and receipted for in good order. Under these circumstances we 
 could not force our claims, and must therefore stand the loss, when 
 in reality the railroad companies are at fault. We always send a 
 duplicate shipping receipt with each shipment, enumerating all 
 of the pieces and bundles, and it is our express desire that our 
 customers check the goods in by these receipts, and if there are any 
 parts broken or missing, to make claim before accepting or receipt- 
 ing for the goods. We can then- assist them in recovering from 
 the railroad company, but otherwise we cannot. Our responsibility 
 ceases when goods are delivered on cars here and properly receipted 
 for, unless otherwise agreed upon. 
 
 In ordering, state size of pulley wanted, and which side the cut- 
 ter will be driven from, left or right, standing at the feeding end, 
 and give full shipping directions. 
 
 For carriers, give height of wall from feet of cutter, and thick- 
 ness of wall. Full directions will be sent with each cutter. 
 
GENERAL PRICE LIST. 
 
 The Ross Hand Cutters. 
 
 No. 5 —2 knives, $22.00 
 
 " 9A— 3 knives, . . . ' . . . . 30.00 
 
 " 12A — 3 knives, two men to turn, ... 38.00 
 
 The Ross Little Giant Power Cutters. 
 
 No. 11 A— 4 knives, $45.00 
 
 « 13A— 4 knives, 65.00 
 
 « 14A— 4 knives, 90.00 
 
 " 17A— 4 knives. . .' •'. . . 140.00 
 
 The Ross Giant Power Cutters. 
 
 No. 18 A— 4 knives, chain feed, . . . .$250.00 
 
 « 26A— 4 knives, " " . . 300.00 
 
 All power Cutters have the Ross Patent Safety Fly- Wheel. 
 
\ 
 
 ROSS LITTLE GIANT No. MA. 
 
83 
 
 The Ross Little Giant Cutter No, HA. 
 
 The No. 11A is our smallest power-cutter, and is especially 
 adapted for cutting all kinds of dry fodder. It has four 11 -inch 
 knives with long shearing and upward cut. It can be driven upon 
 either side, as ordered, by 8, 10 or 12-inch pulley. It has the Ross 
 patent safety fly-wheel, extensible joints, convex gears, self adjust- 
 ing feed-rollers, swing hood, and all of the new improvements. It 
 is one of the finest power-cutters in the market, and we guarantee 
 it to give perfect satisfaction. It can also be run by hand power. 
 
 Cuts one-fourth, one-half, and one inch. 
 
 Capacity, 2,500 pounds per hour. 
 
 Power required, one horse. 
 
 Speed, 500 to 600 revolutions per minute. 
 
 Weight, 350 pounds. 
 
 Price, $45.00 
 
 Chain Carrier, 12 feet long, or under, . 24.00 
 
 Each Additional Foot, extra. . . . 2.00 
 
 The No. 11 A was not designed for an Ensilage Cutter, and we 
 do not recommend it for that purpose, although some of our custo- 
 mers have used this size with good success. Our Nos. 14 A, IV A, 
 18 A, and 26 A are especially adapted for cutting ensilage, and we 
 can guarantee them in every way. 
 
ROSS LITTLE GIANT No. I3A. 
 
85 
 
 The Ross Little Giant Cutter No. 13A. 
 
 The No. 13 A is the next size larger than the No. 11 A, and of the 
 same pattern. It has four 13 -inch knives with upward shearing 
 cut. It is fifty pounds heavier than the No. 11A, and stronger in 
 proportion. This is the most convenient size we have for the 
 general farmer. It is an easy-running cutter; can be run by hand 
 or one-horse-power, and has a large capacity. It is intended for 
 cutting all kinds of dry fodder, and has no equal for the price. 
 We guarantee this cutter in every way. 
 
 Cuts one-fourth, one-half, and one inch. 
 
 Capacity, 3,000 to 3,500 pounds per hour on dry fodder. 
 
 Power required, one horse. 
 
 Speed, 500 to 600 revolutions per minute. 
 
 Weight, 400 pounds. 
 
 Pulleys, either 8, 10, 12, 14, or 16-inch diameter, as ordered. 
 
 Price, $65.00 
 
 Chain Carrier, 12 feet long, or under, . 24.00 
 
 Each Additional Foot, extra, . . . 2.00 
 
 The No. 13A is not one of our Ensilage Cutters, and we do not 
 recommend it for that purpose. It is, however, a very superior 
 machine, and will do excellent work. Our 14A, 17 A, 18 A, and 
 26 A are made especially heavy and strong, and are perfectly 
 adapted for^, cutting ensilage. 
 
ROSS LITTLE GIANT No. I4A. 
 
87 
 
 The Special Little Giant Cutter, No. 14A. 
 
 This is one of our "Specials," and designed to be the very best 
 machine it is possible to build. Is extra heavy, strong, and dura- 
 ble, and is intended for heavy work. It cuts equally well, and in a 
 perfect'manner, every kind of green and dry fodder, including the 
 largest of corn-stalks. It requires but very little power to drive it. 
 Provision is made for attaching an extension to the end of feeding 
 box for facilitating rapid and easy feeding of machine. 
 
 The driving pulley and fly-wheels can be changed to either side. 
 Cutter has an extra provision for long springs to increase the uni- 
 versal motion of the feeding rollers, and is provided with every 
 improvement and device for making it superior in every particular. 
 "We cannot recommend it too highly. 
 
 Machine has — Four 14-inch knives, and Weighs 575 pounds. 
 
 " '• — Two pulleys for belting on either side. 
 
 " " — Pulleys either 8, 10, 12, 14, or 16-in. diam. as ordered. 
 
 « <• — Extra heavy and long shafts, with three bearings. 
 
 11 " — Safety fly-wheel and pulleys, changeable. 
 
 " " — Heavy flaring frame of selected timber. 
 Cuts \, l T 6y, and 1 inch long. 
 
 " " — Provision for receiving Carrier at any time. 
 
 " " — Capacity on green fodder of five tons per hour. 
 Cutter should run from 500 to 600 revolutions per minute. 
 Power required, including Carrier, 2-horse tread or sweep. 
 
 Price, $90.00 
 
 Chain Carrier, 12 feet long, or under, . 24.00 
 
 " " extra per foot, . . 2.00 
 
 The 14A is one of our Regular Ensilage Cutters, and is the best 
 cutter of its size in the world. 
 
ROSS LITTLE GIANT N2 I7A. 
 
 
89 
 
 The Special Little Giant Cutter, No. 17A. 
 
 Is one of our "Specials," and designed to be the very best cut- 
 ter it is possible to build. It is precisely similar in construction to 
 the. No. 14 A, only heavier and larger and of greater capacity. It 
 will cut more fodder, green or dry, than any cutter of any other 
 make (excepting our Giants) in the United States. The capacity 
 ■is not controlled by the length of knives, and it does its work 
 with ease and freedom, and in a most perfect manner. The ma- 
 chine requires but very little power to drive it, and is furnished 
 with two pulleys for belting up on either side at will, and arranged 
 for attaching Carrier at any time. 
 
 Machine has — Four 17-inch knives, and weighs 775 pounds. 
 
 — Two pulleys for belting on either side. 
 
 — Pulleys either 8, 10, 12, 14, or 16 in. diam. asordered. 
 
 — Shafts with three bearings, extra heavy and long. 
 
 — Safety fly-wheels and pulleys, changeable. 
 
 — Heavy flaring frame of selected timber. 
 
 — Cuts ^-, T 7 s-, f , and 1 inch long. 
 
 — Capacity on green fodder, eight tons per hour. 
 Cutter should run from 500 to 600 revolutions per minute. 
 Power required, 2-horse tread or sweep. 
 
 Price, . . . . ■ . . . $140.00 
 
 Price of Carrier, 12 feet long, or under, 25.00 
 
 " " per foot extra, . 2.00 
 
 The 17Ais one of our Ensilage Cutters, and is a very superior 
 machine in every respect. 
 
ROSS GIANT CUTTER No. 18A. 
 
91 
 
 The Ross Giant Cutter No. 18 A. 
 
 The No. 1 8 A Giant is next in size to our largest Ensilage Cutter, 
 and is a very large and powerful machine. It has an^ almost un- 
 limited capacity, and cannot be excelled, except by our 2 6 A. 
 Except in size, it is the same as the 2 6 A. Our Giants have all the 
 new improvements, and are guaranteed to be as represented. 
 
 It is very heavy and strong. 
 
 Has four 18-inch knives and upward cut. 
 
 Pulleys, either 20, 24, 26, or 30-inch diam., 6-in. face, as. ordered. 
 
 Shafts extra heavy and long, three bearings. 
 
 Safety fly-wheels. 
 
 Driven upon either side, as ordered, — generally left side. 
 
 Frames very heavy and flaring, and from selected timber. 
 
 Cuts J, §■, %, § , f, and 1 inch long and upwards. 
 
 Weight, 2,000 pounds. 
 
 Capacity, ten tons per hour, one-half inch long. 
 
 Speed, 600 revolutions per minute. 
 
 Power, five to six horse-power engine. 
 
 Detachable chain feed. 
 
 Price, ........ $250.00 
 
 Chain Carrier, per foot, . . . . 2.50 
 
 Feeding Tables, . . . . . . 15.00 • 
 
 We can furnish this cutter with downward cut, if desired, upon 
 sufficient notice. 
 
ROSS GIANT CUTTER No. 26A. 
 
93 
 
 The Ross Giant Cutter No. 26A. 
 
 The No. 26 A is the largest and most powerful Ensilage Critter 
 in the world. It has an unlimited capacity, and we guarantee it 
 to he superior in every respect to any other cutter in the world. 
 
 It is very heavy and strong. 
 
 Has four 2 6 -inch knives, and upward cut. 
 
 Pulleys, either 20, 24, 26, or 30-in. diam., 6-in. face, as ordered. 
 
 Shafts very heavy and long, three wide bearings. 
 
 Safety fly-wheels. 
 
 Driven .upon either side, as ordered, — generally left side. 
 
 Frames very heavy and flaring, and from selected timber. 
 
 Cuts ^ f, i, f , f, 1 inch and upwards. 
 
 Weight, 2,500 pounds. 
 
 Capacity, fifteen tons per hour, one-half inch long. 
 
 Speed, 600 revolutions per minute. 
 
 Power, seven to eight-horse-power engine. 
 
 Detachable chain-feed. 
 
 Price, $300.00 
 
 Chain Carrier, per foot, . . . . 2.50 
 
 Feeding Tables, 20.00 
 
 We can furnish this cutter with downward cut, if desired, upon 
 sufficient notice. 
 
ROSS ANCLE CARRIER. 
 
95 
 
 CARRIERS. 
 
 Ross Patent Angle Carriers. 
 
 This Carrier is our very latest design (1883), and destined to 
 supersede all others. It is reversible. On page 94 the carrier is 
 shown delivering to the left, and can also be changed to deliver to 
 the right, and with the devices provided, this change is very easily 
 and quickly made. Also please notice that the driving belt of the 
 cutter runs directly away from the machine, and not backwards on 
 either side. This arrangement, unlike the straight delivery carrier, 
 enables the user to place the cutter close up to the silo or bin, into 
 which the fodder is to be carried or elevated; or in narrow drives 
 or passageways. It also leaves the feeding end of the machine 
 clear all around it for wagons, material, and workmen, and permits 
 its being fed on either or both sides, as best suited for receiving 
 the material to be cut, which advantages are too apparent to need 
 explanation. 
 
 Heretofore it has been necessary to belt back beside the cutter, 
 when straight-away carriers were used, thereby shutting off com- 
 pletely with the driving belt all of one side of the machine, and 
 preventing its approach with wagons, men, or material, doubling 
 the cost of preparing the fodder, and proving a great annoyance 
 and expense. 
 
96 
 
 This carrier requires but the very least power to drive it — the 
 friction of the working parts being reduced to a minimum, and it 
 works so easily that in turning a large cutter by hand, the differ- 
 ence is hardly perceptible, whether the carrier is attached to the 
 machine or detached. 
 
 All the working parts are fully exposed to view, and can be 
 readily oiled. This is the only carrier where the whole of itself 
 and load is supported by an especial device which relieves entirely 
 the shafts and boxes from that weight, and at the same time holding 
 firmly and securely in position the bottom shafts and chain-wheels r 
 thus preventing their slipping or moving while being attached, 
 elevated, or detached. The chain we put upon these carriers is; 
 made of malleable iron, and can be quickly detached, or put 
 together at any point. 
 
 Cut on page 94 shows at upper end of carrier our patent device 
 for taking up the slack of the chain and buckets after they are 
 hooked together when setting up the carrier, and afterwards for 
 regulating at all times the proper tension of the chain. The action on 
 both sides is simultaneous, and accomplished in a moment. This- 
 device entirely prevents the difficulties heretofore experienced with 
 all carriers. The chain will not slip, jump the teeth, stretch un- 
 evenly, or break, but will run smooth and free under the hardest 
 work. The toood work is thoroughly framed, and put together 
 with joint bolts, and the sides are very high, suited to our cutters, 
 which require carriers of good capacity to remove the cut stock. 
 
 Carriers are fast coming into favor, and are furnished with 
 nearly every large cutter, and will be found not only to save the 
 labor of from one to five men, but will do the same amount of work 
 quicker, cleaner, and at no expense after first outlay. They 
 deliver off upon the same level or will elevate to an angle of forty- 
 five degrees, every kind of material, green or dry,' and being 
 entirely of iron and wood, do not soak up or fray out. Are used 
 also either by hand or power for carrying ensilage or dry fodder 
 from the storing-places to such points as it may be necessary to< 
 
97 
 
 feed. " They are indestructible, require the least possible power 
 to drive them, will deliver either to the right or left, are positive 
 drivers, and do not clog, slip, or stop; are easily and quickly 
 attached or detached ; require no belt to drive them ; are heavy, 
 strong, and durable ; can be made in sections to any length ; have 
 our patent adjusting and tightening device ; have no equal for 
 perfection of operation, durability, or capacity, etc., etc." 
 
 Covered by patents, and can be had only Of ourselves or our 
 agents. 
 
ROSS STRAIGHT DELIVERY CARRIER. 
 
99 
 
 Straight Delivery Carriers. 
 
 These are our latest design (1883), and in general construction 
 and operation are similar to our angle carriers, and covered by the 
 same patents, excepting that they do not deliver sideways. When 
 arrangements are provided or circumstances of the case admit of 
 driving the cutter either from below, above, or straight-away, with- 
 out belting backward past the feeding end of cutter (thereby shut- 
 ting off one side of machine completely, like every and all others, 
 excepting our patent angle), then they will be found to be very 
 satisfactory, and will do just as good work as the angle style. The 
 carriers are provided on all short lengths with means for driving as 
 shown on pages 94 and 98. 
 
 Material and workmanship is the same as in the angle style, and 
 in every particular of construction and operation the same, except- 
 ing this delivers straight-away and the angle style at right angles, 
 either right or left side as desired. 
 

r^