hi gl it i IER f ; | i pl 1 - i - \ | 3 SERVICE, | J[oxicological +; 7 A g | tH [ 5 4 i 3 ct i di = 1 fi I | : 2 i Fo oh f 7 : vl for is 2% b SULFUR TRIOXIDE and SULFURIC ACID @ Draft for Public Comment Comment Period Ends: February [WARS aE J U.S, Led od OF HEALTH & HUMAN SERVICES i Public Health Service “Agency for Toxic Substances and Disease Registry PUBLIC HEALTH LIBRARY BERKELEY LIBRARY UNI ERSITY OF ALIFORNIA DRAFT TOXICOLOGICAL PROFILE FOR SULFUR TRIOXIDE AND SULFURIC ACID Prepared by: Sciences International, Inc. Under Subcontract to: Research Triangle Institute Under Contract No. 205-93-0606 Prepared for: U.S. DEPARTMENT OF HEALTH AND HUMAN SERVICES Public Health Service Agency for Toxic Substances and Disease Registry September 1997 SULFUR TRIOXIDE AND SULFURIC ACID DISCLAIMER The use of company or product name(s) is for identification only and does not imply endorsement by the Agency for Toxic Substances and Disease Registry. OR “At YS 3 uBiic ¥ ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID iii PA 1247 SF 169 UPDATE STATEMENT Toxicological profiles are revised and republished as necessary, but no less than once every three years. For information regarding the update status of previously released profiles, contact ATSDR at: Agency for Toxic Substances and Disease Registry Division of Toxicology/Toxicology Information Branch 1600 Clifton Road NE, E-29 Atlanta, Georgia 30333 “**DRAFT FOR PUBLIC COMMENT*** FOREWORD This toxicological profile is prepared in accordance with guidelines developed by the Agency for Toxic Substances and Disease Registry (ATSDR) and the Environmental Protection Agency (EPA). The original guidelines were published in the Federal Register on April 17, 1987. Each profile will be revised and republished as necessary. The ATSDR toxicological profile succinctly characterizes the toxicologic and adverse health effects information for the hazardous substance described therein. Each peer-reviewed profile identifies and reviews the key literature that describes a hazardous substance 's toxicologic properties. Other pertinent literature is also presented, but is described in less detail than the key studies. The profile is not intended to be an exhaustive document; however, more comprehensive sources of specialty information are referenced. The focus of the profiles is on health and toxicologic information; therefore, each toxicological profile begins with a public health statement that describes, in nontechnical language, a substance's relevant toxicological properties. Following the public health statement is information concerning levels of significant human exposure and, where known, significant health effects. The adequacy of information to determine a substance's health effects is described in a health effects summary. Data needs that are of significance to protection of public health are identified by ATSDR and EPA. Each profile includes the following: (A) The examination, summary, and interpretation of available toxicologic information and epidemiologic evaluations on a hazardous substance to ascertain the levels of significant human exposure for the substance and the associated acute, subacute, and chronic health effects; (B) A determination of whether adequate information on the health effects of each substance is available or in the process of development to determine levels of exposure that present a significant risk to human health of acute, subacute, and chronic health effects; and (C) Where appropriate, identification of toxicologic testing needed to identify the types or levels of exposure that may present significant risk of adverse health effects in humans. The principal audiences for the toxicological profiles are health professionals at the Federal, State, and local levels; interested private sector organizations and groups; and members of the public. We plan to revise these documents in response to public comments and as additional data become available. Therefore, we encourage comments that will make the toxicological profile series of the greatest use. Comments should be sent to: Agency for Toxic Substances and Disease Registry Division of Toxicology Mail Stop E-29 Atlanta, Georgia 30333 vi The toxicological profiles are developed in response to the Superfund Amendments and Reauthorization Act (SARA) of 1986 (Public Law 99-499) which amended the Comprehensive Environmental Response, Compensation, and Liability Act of 1980 (CERCLA or Superfund). This public law directed ATSDR to prepare toxicological profiles for hazardous substances most commonly found at facilities on the CERCLA National Priorities List and that pose the most significant potential threat to human health, as determined by ATSDR and the EPA. The availability of the revised priority list of 275 hazardous substances was announced in the Federal Register on April 29, 1996 (61 FR 18744). For prior versions of the list of substances, see Federal Register notices dated April 17, 1987 (52 FR 12866); October 20, 1988 (53 FR 41280); October 26, 1989 (54 FR 43619); October 17,1990 (55 FR 42067); October 17, 1991 (56 FR 52166); October 28, 1992 (57 FR 48801); and February 28, 1994 (59 FR 9486). Section 104(i)(3) of CERCLA, as amended, directs the Administrator of ATSDR to prepare a toxicological profile for each substance on the list. This profile reflects ATSDR’s assessment of all relevant toxicologic testing and information that has been peer-reviewed. Staff of the Centers for Disease Control and Prevention and other Federal scientists have also reviewed the profile. In addition, this profile has been peer-reviewed by a nongovernmental panel and is being made available for public review. Final responsibility for the contents and views expressed in this toxicological profile resides with ATSDR. David Satcher, M.D., Ph.D Administrator Agency for Toxic Substances and Disease Registry SULFUR TRIOXIDE AND SULFURIC ACID vii CONTRIBUTORS CHEMICAL MANAGER(S)/AUTHOR(S): Joseph D. Little, MSPH ATSDR, Division of Toxicology, Atlanta, GA Carol Eisenmann, Ph.D. Sciences International, Inc., Alexandria, VA THE PROFILE HAS UNDERGONE THE FOLLOWING ATSDR INTERNAL REVIEWS: 1. 2, Green Border Review. Green Border review assures consistency with ATSDR policy. Health Effects Review. The Health Effects Review Committee examines the health effects chapter of each profile for consistency and accuracy in interpreting health effects and classifying end points. Minimal Risk Level Review. The Minimal Risk Level Workgroup considers issues relevant to substance-specific minimal risk levels (MRLs), reviews the health effects database of each profile, and makes recommendations for derivation of MRLs. Quality Assurance Review. The Quality Assurance Branch assures that consistency across profiles is maintained, identifies any significant problems in format or content, and establishes that Guidance has been followed. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID ix PEER REVIEW A peer review panel was assembled for sulfur trioxide and sulfuric acid. The panel consisted of the following members: 1. Dr. Arthur Gregory, Private Consultant, Luray, VA 2. Dr. Ingeborg Harding-Barlow, Private Consultant, Palo Alto, CA 3. Dr. Lyman Skory, Private Consultant, Midland, MI These experts collectively have knowledge of sulfur trioxide’s and sulfuric acid’s physical and chemical properties, toxicokinetics, key health end points, mechanisms of action, human and animal exposure, and quantification of risk to humans. All reviewers were selected in conformity with the conditions for peer review specified in Section 104(i)(13) of the Comprehensive Environmental Response, Compensation, and Liability Act, as amended. Scientists from the Agency for Toxic Substances and Disease Registry (ATSDR) have reviewed the peer reviewers’ comments and determined which comments will be included in the profile. A listing of the peer reviewers’ comments not incorporated in the profile, with a brief explanation of the rationale for their exclusion, exists as part of the administrative record for this compound. A list of databases reviewed and a list of unpublished documents cited are also included in the administrative record. The citation of the peer review panel should not be understood to imply its approval of the profile’s final content. The responsibility for the content of this profile lies with the ATSDR. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID xi CONTENTS FOREWORD v CONTRIBUTORS . . ddd vii PEER REVIEW |. 1X LIST OF FIGURES . . . ©. sds, XV LIST OF TABLES . . ds XVil 1. PUBLIC HEALTH STATEMENT . .. 1 1.1 WHAT ARE SULFUR TRIOXIDE AND SULFURIC ACID? .................... 1 1.2 WHAT HAPPENS TO SULFUR TRIOXIDE AND SULFURIC ACID WHEN THEY ENTER THE ENVIRONMENT? . ... 3 1.3 HOW MIGHT I BE EXPOSED TO SULFUR TRIOXIDE OR SULFURIC ACID? ..... 3 1.4 HOW CAN SULFUR TRIOXIDE AND SULFURIC ACID ENTER AND LEAVE MY BODY? © 4 1.5 HOW CAN SULFUR TRIOXIDE AND SULFURIC ACID AFFECT MY HEALTH? ... 4 1.6 IS THERE A MEDICAL TEST TO DETERMINE WHETHER I HAVE BEEN EXPOSED TO SULFUR TRIOXIDE OR SULFURICACID? .................... 6 1.7 WHAT RECOMMENDATIONS HAS THE FEDERAL GOVERNMENT MADE TO PROTECT HUMAN HEALTH? ........ 6 1.8 WHERE CAN I GET MORE INFORMATION? ............................. 7 2. HEALTH BRFECTS . i tt i tt ests sts tttae ress nnnns 9 2:1 INTRODUCTION :.uuitiuuisnnnmrnmsmurmmsmmrmmenmenmesssmesswsnss nn 9 2.2 DISCUSSION OF HEALTH EFFECTS BY ROUTE OF EXPOSURE .............. 9 2.2.1 Inhalation Exposure .............. 11 22.1.1 Death ....... 12 221.2 SyStemiCEHEctS .. cu viinsonrivibnimmemmrnmrmnamennss 15 2.2.1.3 Immunological and Lymphoreticular Effects . ................. 58 2.2.1.4 Neurological Effects .................................. 60 2.2.1.5 Reproductive Effects .................................. 61 2216 Developmental Effects . ... vu vivniinnrmmnnsnssnmenmnnns 61 22.1.7 Genotoxic Effects ................. 61 2218 Cancer .........i ii arate ream ana 62 222 Oral BXPOSUIE +s coon vv sms 85508 9s muse mom a mm smn smnomomes vss sms 63 222.1 Death ...... 63 22.22 Systemic Effects .................. 64 2.2.2.3 Immunological and Lymphoreticular Effects . ................. 68 22.24 Neurological Effects ................... ............... 68 2.2.2.5 Reproductive Effects .................... . . ............ 68 22.2.6 Developmental Effects ................................. 68 2227 GenotoxicEffects ..............cciitrrriiinnernnen. 69 2228 CACBY , sui vuen mt aus nos satvismenmmensonsnas onsen: sn 69 ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 3 2.2.3 Dermal EXPOSUIE . . . . o.oo iit 2231 Death oo vmivn ome iii mR IARI REA BE REE RE BADR ENN SHAY 2232 SystemiCEIlectS sus nus vncvncnminmraromesms noe nus wns 2.2.3.3 Immunological and Lymphoreticular Effects . ................. 2234 Neurological Effects ...........c.c vin ivvinnrvnnnnvnnss 2235 Reproductive Effects .:x:sniuninvsnssmsmnnenmsagrnnrmene 22386 Developmental BHCCIS vu. vu smo smmtmt ame nu ecmme nme num ns 2.237 Genotoxic Effects ............. 2238 CANCEL ©. venir ems mm nme anv iG AI ABA IRE I HEIR EWE oH 8 WD 23 TOXICOKINBTICS .. co nnsov ints nisi ssaiats sams xassssnssmsons ws 23.1 AUSOIPUHON cms mi 6 mins 515s Bt s mos £8 626 44 2 3 swims Sims vss mss me sims 2.3.1.1 Inhalation Exposure .................... 0... 2312 OralEBxposure ........ ci amiss ams Ber nein RE HELE HE LR 2313 Dermal BXposure . . ccs nm inn ssw snsmepa seme mns vues 2.3.2 DIStrIbUtiOn . . o.oo 2321 Inhalation Exposure ....... coc iivsnnimasnssmesmennsnms ss 2322 OralExXposure ...::cc:vus:amssmsnssnsemevmomnrnnswssns 2.3.23 Dermal Exposure . ........... 2.3.3 MetaboliSm . . . o.oo 234 Elimination and EXCretion : «cco: vsina ira sna bor ams ums mms sms ws ww» 2.3.4.1 Inhalation Exposure . ............. 2.3.42 Oral EXpoSUIe . . . o.oo 2343 Dermal EXposure .. ........c:i6 sass ismimesainsntens vas 2.3.5 Physiologically Based Pharmacokinetic (PBPK)/Pharmacodynamic (PD) Models . ..... 24 MECHANISMS OF ACTION . . eee 24.1 Pharmacokinetic Mechanisms ......c. cin vn snmimesnersnsnnsmns 2.4.2 Mechanisms of TOXICItY . .... oti 2.4.3 Animal-to-Human Extrapolations . ..................... ........... 23 RELEVANCE TOPUBLICHBALTH ........ cu nmina miimrominsinas sss 2.6 BIOMARKERS OF EXPOSURE AND EFFECT ..-.:vuiniivismonninmenmanss 2.6.1 Biomarkers Used to Identify or Quantify Exposure to Sulfur Trioxide/Sulfuric Acid... ... 2.6.2 Biomarkers Used to Characterize Effects Caused by Sulfur Trioxide/Sulfuric ACId .... cv vusvminmss is nis moms snmansssasmsy 2.7 INTERACTIONS WITH OTHER CHEMICALS ............................ 2.8 POPULATIONS THAT ARE UNUSUALLY SUSCEPTIBLE ................... 29 METHODS FOR REDUCING TOXIC EFFECTS ....c:vcinsivsasnisnsnnssanss 2.9.1 Reducing Peak Absorption Following Exposure . ...................... 29.2 Reducing Body Burden . .............. 29.3 Interfering with the Mechanism of Action for Toxic Effects .............. 2.10 ADEQUACY OFTHE DATABASE .....:ic s0troivaitaasassnsssossansiy 2.10.1 Existing Information on Health Effects of Sulfur Trioxide and Sulfuric Acid . . 2.10.2 Identification of Data Needs ................ inn... 2.10.3 Ongoing Studies . ....... CHEMICAL AND PHYSICAL INFORMATION . .......... i. 3.1 CHEMICAL IDENTITY . ... eee 32 PHYSICAL AND CHEMICAL PROPERTIES ......... o:vuinnimiiamsaniss ***DRAFT FOR PUBLIC COMMENT*** Xii SULFUR TRIOXIDE AND SULFURIC ACID xiii 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL ................0...... 121 4.1 PRODUCTION . dd, 121 42 IMPORT/EXPORT i ons vi 00.6 6.50 #8 4 6.5 5 50 2 5s 8.08 Bd x Ha ABE 5k § 0m ds nse v0 124 4.3 USE 124 4.4 DISPOSAL . 125 5. POTENTIAL FOR HUMAN EXPOSURE . . .... i, 127 5.1 OVERVIEW 127 5.2 RELEASES TO THE ENVIRONMENT . . ... ii. 127 5.2.1 DIE 6 5 55.5% 0 BE BG BEE Ee Bek BAe mee in ek ems mn Rh ne Ae tse hs 127 5.22 Water . o.oo 133 5.23 Soil 134 5.3 ENVIRONMENTAL FATE . . .. eee, 134 5.3.1 Transport and Partitioning . ................. 0. uti... 134 3532 Transformation and Degradation . cs: vs isai univers ni amsnss sm snss sun 135 5.3.2.1 AI. 135 5.322 Water . o.oo 136 5.323 Sedimentand Soil ............. 137 5.4 LEVELS MONITORED OR ESTIMATED IN THE ENVIRONMENT ............ 137 5.4.1 AIT Le 137 54.2 WLBT + oc ov i tvs tt sens wm rem ama mda nns sms mm smn sae ews urns wes 140 5.4.3 Sediment and Soil ........... 140 5.4.4 Other Environmental Media .................... iii... 140 5.5 GENERAL POPULATION AND OCCUPATIONAL EXPOSURE ............... 141 5.6 POPULATIONS WITH POTENTIALLY HIGH EXPOSURES .................. 144 5.7 ADEQUACY OF THE DATABASE . ..... iii 144 5.7.1 Identification of Data Needs . ............... 0. uiiiiinannnn... 145 5772 Ongoing Studies . ......... 148 6. ANALYTICAL METHODS . . . . ee se, 149 6.1 BIOLOGICAL SAMPLES . . . . ees 149 6.2 ENVIRONMENTAL SAMPLES . .... iis 150 6.3 ADEQUACY OF THE DATABASE . . .. 154 6.3.1 Identification of Data Needs ................. 0.0... 155 6.3.2 Ongoing Studies . ......... 155 7. REGULATIONS AND ADVISORIES . .. 157 B. REFERENCES i ov v 500 50 440 vie» sme vim a srs smn aim = iow 2 550 3 45x #0 6 wi & Wie x Ei & 00% 8 a 161 9. GLOSSARY 179 APPENDICES A. ATSDR MINIMAL RISK LEVEL . . .... i A-1 B., USER'SGUIDE ..cu:oms ame sms mas sme sms ums nme mn ssn wns sms ons as mms B-1 C. ACRONYMS, ABBREVIATIONS, AND SYMBOLS .............. 0... C-1 ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID XV 2-1 2-2 2-3 2-4 5-1 LIST OF FIGURES Levels of Significant Exposure to Sulfuric Acid - Inhalation . ...................... 38 Levels of Significant Exposure to Sulfuric Acid - Oral . .......................... 66 Conceptual Representation of a Physiologically Based Pharmacokinetic (PBPK) Model for a Hypothetical Chemical Substance ..................................... 83 Existing Information on the Health Effects of Sulfuric Acid ....................... 108 Frequency of NPL Sites With Sulfuric Acid Contamination ....................... 128 ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 2-1 2-2 2-3 2-4 2-5 3-1 3-2 4-1 5-1 5-2 6-1 7-1 LIST OF TABLES Levels of Significant Exposure to Sulfuric Acid - Inhalation . ..................... Levels of Significant Exposure to Sulfuric Acid -Oral . ......................... Levels of Significant Exposure to Sulfuric Acid - Dermal ....................... Age-Dependent Respiratory Parameters as a Function of Subject Physical Activity Levels Used in the Martonen and Zhang (1993) Model ......................... Genotoxicity of Sulfuric Acid In Vitro . ......... iii Chemical Identity of Sulfur Trioxide, Sulfuric Acid, and Oleum . .................. Physical and Chemical Properties of Sulfur Trioxide, Sulfuric Acid, and Oleum . ....... Facilities That Manufacture or Process Sulfuric Acid . .......................... Releases to the Environment from Facilities That Manufacture or Process Sulfuric Acid . . . Outdoor, Indoor, and Personal Concentrations of Sulfate, Hydrogen Ion, and Ammonia . . . . Analytical Methods for Determining Sulfur Trioxide and Sulfuric Acid in Environmental Samples . os EE ER RA NRE SEN ERA ER EEE IAL rE saa va nw wn Regulations and Guidelines Applicable to Sulfur Trioxide and Sulfuric Acid .......... “**DRAFT FOR PUBLIC COMMENT*** Xvi 16 65 71 79 99 118 119 122 129 139 SULFUR TRIOXIDE AND SULFURIC ACID 1 1. PUBLIC HEALTH STATEMENT This public health statement tells you about sulfur trioxide and sulfuric acid and the effects of exposure. The Environmental Protection Agency (EPA) identifies the most serious hazardous waste sites in the nation. These sites make up the National Priorities List (NPL) and are the sites targeted for long-term federal cleanup. Sulfur trioxide and sulfuric acid have been found in at least 47 of the 1,430 current or former NPL sites. However, it’s unknown how many NPL sites have been evaluated for this substance. As more sites are evaluated, the sites with sulfur trioxide or sulfuric acid may increase. This is important because exposure to these substances may harm you and because these sites may be sources of exposure. When a substance is released from a large area, such as an industrial plant, or from a container, such as a drum or bottle, it enters the environment. This release does not always lead to exposure. You are exposed to a substance only when you come in contact with it. You may be exposed by breathing, eating, or drinking the substance or by skin contact. If you are exposed to sulfur trioxide or sulfuric acid, many factors determine whether you'll be harmed. These factors include the dose (how much), the duration (how long), and how you come in contact with it. You must also consider the other chemicals you're exposed to and your age, sex, diet, family traits, lifestyle, and state of health. 1.1 WHAT ARE SULFUR TRIOXIDE AND SULFURIC ACID? Sulfur trioxide is generally a colorless liquid but can also exist as ice- or fiber-like crystals or as a gas. When sulfur trioxide is exposed to air, it rapidly takes up water and gives off white fumes. It combines with water releasing considerable heat while forming sulfuric acid. It also reacts violently with metal oxides. Sulfur trioxide is also called sulfuric oxide and ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 2 1. PUBLIC HEALTH STATEMENT sulfuric anhydride. It is used as an intermediate in the production of sulfuric acid, other chemicals, and explosives. Sulfur trioxide is unlikely to exist in the environment except for very short periods when it may be present in the air as a gas. In the air, sulfur trioxide can be formed slowly from sulfur dioxide. Once formed, sulfur trioxide will react with water in the air to form sulfuric acid. Both sulfur dioxide and sulfuric acid are more likely to be found in air than sulfur trioxide. If you are interested in learning more about sulfur dioxide, the Agency for Toxic Substances and Disease Registry has developed a separate profile about it. Sulfuric acid is a clear, colorless, oily liquid that is very corrosive. Although sulfuric acid is odorless, if you are exposed to concentrated sulfuric acid in the air your nose will be irritated and it may seem like sulfuric acid has an odor. When concentrated sulfuric acid is mixed with water, the solution gets very hot. Concentrated sulfuric acid can catch fire or explode when it comes into contact with many chemicals including acetone, alcohols, and metals. When heated it emits highly toxic fumes that include sulfur trioxide. It is also called sulphine acid, battery acid, and hydrogen sulfate. More sulfuric acid is produced in the United States than any other chemical. It is used in the manufacture of fertilizers, explosives, other acids, and glue; in the purification of petroleum; in the pickling of metal; and in lead-acid batteries, the type commonly used in motor vehicles. Sulfuric acid can be found in the air as small droplets or it can be attached to other small particles in the air. The odor threshold for sulfuric acid in air has been reported to be 1 milligram per cubic meter of air (mg/m?). Fuming sulfuric acid, also called oleum, is a solution of 10-70% sulfur trioxide in sulfuric acid. It is in the form of oleum that sulfuric acid is often shipped in railroad cars. For more information, see Chapters 3 and 4. "**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 3 1. PUBLIC HEALTH STATEMENT 1.2 WHAT HAPPENS TO SULFUR TRIOXIDE AND SULFURIC ACID WHEN THEY ENTER THE ENVIRONMENT? Much of the sulfuric acid in the air is formed from sulfur dioxide released when coal, oil, and gas are burned. Some of the released sulfur dioxide forms sulfur trioxide, which reacts with water in the air to form sulfuric acid. Sulfuric acid dissolves in the water in the air and is removed from the air in rain. Sulfuric acid in rain contributes to the formation of acid rain. Sulfuric acid in water separates to form hydrogen ions and sulfate. The ability of sulfuric acid to change the acidity (pH) of the water is dependent on the amount of sulfuric acid and the ability of other substances in the water to neutralize the hydrogen ions (buffering capacity). For more information about sulfur trioxide and sulfuric acid in the environment, see Chapters 4 and 5. 1.3 HOW MIGHT | BE EXPOSED TO SULFUR TRIOXIDE OR SULFURIC ACID? You may be exposed to sulfur trioxide or sulfuric acid at your job if you work in the chemical or metal plating industry; if you produce detergents, soaps, fertilizers, or lead-acid batteries; or if you work in printing and publishing, or photography shops. Because sulfur trioxide forms sulfuric acid when it contacts the moist surfaces of your respiratory tract or your skin, the effects caused by sulfur trioxide and sulfuric acid are the same. In occupational settings, breathing small droplets of sulfur trioxide or sulfuric acid or touching it with your skin are the most likely ways you would be exposed to sulfuric acid. According to estimates from a survey conducted by the National Institute for Occupational Safety and Health (NIOSH) more than 56,103 U.S. workers may be exposed to sulfur trioxide, and more than 775,348 U.S. workers may be exposed to sulfuric acid. However, this survey used estimates from small samples, and the number of workers exposed to sulfur trioxide and sulfuric acid may be overestimated. You may be exposed to sulfuric acid by breathing small droplets in air, especially when the air is heavily polluted. Spending more time outdoors, especially if you exercise outdoors when air pollution levels are high, can increase your exposure to sulfuric acid. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 4 1. PUBLIC HEALTH STATEMENT You can also be exposed to sulfuric acid when you touch the material that forms on the outside of your car battery. Sulfuric acid is formed when some toilet bowl cleaners mix with water. Therefore, if these products touch wet skin or are accidentally swallowed, you could be exposed to sulfuric acid. When you cut onions a chemical called propanethiol S-oxide is released into the air. When this chemical reaches your eyes, it reacts with the water in your eyes to form sulfuric acid, which causes your eyes to water. People have also been exposed following accidental spills of sulfuric acid or oleum. These accidents occurred more frequently at a site than while the substances were being transported. For more information on the ways people might be exposed to sulfuric acid, see Chapter 5. 1.4 HOW CAN SULFUR TRIOXIDE AND SULFURIC ACID ENTER AND LEAVE MY BODY? If you breathe in sulfur trioxide, small droplets of sulfuric acid will form when the sulfur trioxide contacts water. Small droplets of sulfuric acid may also enter the respiratory tract when you breathe. Where the droplets will deposit in the respiratory tract depends on the size of the droplets and how deeply you are breathing. Smaller droplets will deposit deeper into the lung. If you breathe through your mouth, more droplets will deposit in your lungs than if you breathe only through your nose. Extra sulfur in your body is excreted in the urine. Sulfuric acid causes its effects by direct action on tissues that it touches. With the exception of how sulfuric acid droplets deposit in the lungs, how sulfur trioxide and sulfuric acid enter and leave your body does not alter the effects of sulfuric acid. For more information, see Chapter 2. 1.5 HOW CAN SULFUR TRIOXIDE AND SULFURIC ACID AFFECT MY HEALTH? To protect the public from the harmful effects of toxic chemicals and to find ways to treat people who have been harmed, scientists use many tests. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 5 1. PUBLIC HEALTH STATEMENT One way to see if a chemical will hurt people is to learn how the chemical is absorbed, used, and released by the body; for some chemicals, animal testing may be necessary. Animal testing may also be used to identify health effects such as cancer or birth defects. Without laboratory animals, scientists would lose a basic method to get information needed to make wise decisions to protect public health. Scientists have the responsibility to treat research animals with care and compassion. Laws today protect the welfare of research animals, and scientists must comply with strict animal care guidelines. Sulfuric acid and other acids are very corrosive and irritating and cause direct local effects on the skin, eyes, and respiratory and gastrointestinal tracts when there is direct exposure to sufficient concentrations. Breathing sulfuric acid mists can result in tooth erosion and respiratory tract irritation. Drinking concentrated sulfuric acid can burn your mouth and throat, and it can erode a hole in the stomach and has resulted in death. If you touch sulfuric acid, it will burn your skin. If you get sulfuric acid in your eyes, it will burn your eyes and cause them to water. People have been blinded by sulfuric acid being thrown in their faces. Breathing small droplets of sulfuric acid at levels that might be in the air on a day with high air pollution may make it more difficult to breathe. This effect is more likely to occur if you have been exercising or if you have asthma. This effect is also more likely to occur in children than adults. Breathing large amounts of sulfuric acid droplets will also decrease the ability of your respiratory tract to remove other small particles that are in your respiratory tract. If you breathe sulfur trioxide, it turns into sulfuric acid in your respiratory tract, and the effects you may experience will be the same as if you breathe sulfuric acid. Birth defects have not been observed in animals that breathed high levels of sulfuric acid mist. Although birth defects have not been studied in humans exposed to sulfuric acid, it is unlikely to result in birth defects in humans. Studies of people who breathed high concentrations of sulfuric acid at work have shown an increase in cancers of the larynx. However, most of the cancers were in smokers who were also exposed to other acids and other chemicals. There is no information that exposure to ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 1. PUBLIC HEALTH STATEMENT sulfuric acid by itself is carcinogenic. The carcinogenicity of sulfuric acid has not been studied in animals. The EPA and the U.S. Department of Health and Human Services (DHHS) have not classified sulfur trioxide or sulfuric acid for carcinogenic effects. Based on the very limited human data, the International Agency for Research on Cancer (IARC) believes that evidence is sufficient to say that occupational exposure to strong inorganic acid mists containing sulfuric acid is carcinogenic to humans. IARC has not classified pure sulfuric acid for its carcinogenic effects. For more information on the health effects of sulfuric acid, see Chapter 2. 1.6 IS THERE A MEDICAL TEST TO DETERMINE WHETHER | HAVE BEEN EXPOSED TO SULFUR TRIOXIDE OR SULFURIC ACID? There is no medical test to determine if you have been exposed to sulfur trioxide or sulfuric acid. If you breathe in acids including sulfuric acid, the acidity of your saliva will increase. Measuring the acidity of saliva may help determine if you have been exposed to acid, but it will not determine if you have been exposed to sulfur trioxide, sulfuric acid, or another acid. For more information on where and how sulfuric acid can be detected in your body after you have been exposed to it, see Chapters 2 and 6. 1.7 WHAT RECOMMENDATIONS HAS THE FEDERAL GOVERNMENT MADE TO PROTECT HUMAN HEALTH? The federal government develops regulations and recommendations to protect public health. Regulations can be enforced by law. Federal agencies that develop regulations for toxic substances include the Environmental Protection Agency (EPA), the Occupational Safety and Health Administration (OSHA), and the Food and Drug Administration (FDA). Recommendations provide valuable guidelines to protect public health but cannot be enforced by law. Federal organizations that develop recommendations for toxic substances include the Agency for Toxic Substances and Disease Registry (ATSDR) and the National Institute for Occupational Safety and Health (NIOSH). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 7 1. PUBLIC HEALTH STATEMENT Regulations and recommendations can be expressed in not-to-exceed levels in air, water, soil, or food that are usually based on levels that affect animals; then they are adjusted to help protect people. Sometimes these not-to-exceed levels differ among federal organizations because of different exposure times (an 8-hour workday or a 24-hour day), the use of different animal studies, or other factors. Recommendations and regulations are also periodically updated as more information becomes available. For the most current information, check with the federal agency or organization that provides it. Some regulations and recommendations for sulfur trioxide and sulfuric acid include the following: EPA limits the amount of sulfur dioxide that can be released into the air. This limits the amount of sulfur trioxide and sulfuric acid that form from sulfur dioxide in the air. OSHA limits the amount of sulfuric acid that can be present in workroom air to 1 mg/m’. NIOSH also recommends a time-weighted average limit of 1 mg/m®. For more information on regulations and guidelines to protect human health, see Chapter 7. 1.8 WHERE CAN | GET MORE INFORMATION? If you have any more questions or concerns, please contact your community or state health or environmental quality department or: Agency for Toxic Substances and Disease Registry Division of Toxicology 1600 Clifton Road NE, Mailstop E-29 Atlanta, GA 30333 * Information line and technical assistance Phone: (404) 639-6000 Fax: (404) 639-6315 or 6324 “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 1. PUBLIC HEALTH STATEMENT ATSDR can also tell you the location of occupational and environmental health clinics. These clinics specialize in recognizing, evaluating, and treating illnesses resulting from exposure to hazardous substances. * To order toxicological profiles, contact: National Technical Information Service 5285 Port Royal Road Springfield, VA 22161 Phone: (800) 553-6847 or (703) 487-4650 ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 9 2. HEALTH EFFECTS 2.1 INTRODUCTION The primary purpose of this chapter is to provide public health officials, physicians, toxicologists, and other interested individuals and groups with an overall perspective of the toxicology of sulfur trioxide/sulfuric acid. It contains descriptions and evaluations of toxicological studies and epidemiological investigations and provides conclusions, where possible, on the relevance of toxicity and toxicokinetic data to public health. This profile does not discuss studies regarding exposure to sulfur dioxide, from which sulfur trioxide and sulfuric acid are formed. Studies regarding effects of sulfur dioxide are discussed in a separate ATSDR profile (ATSDR 1997). A glossary and list of acronyms, abbreviations, and symbols can be found at the end of this profile. 2.2 DISCUSSION OF HEALTH EFFECTS BY ROUTE OF EXPOSURE To help public health professionals and others address the needs of persons living or working near hazardous waste sites, the information in this section is organized first by route of exposure—inhalation, oral, and dermal; and then by health effect—death, systemic, immunological, neurological, reproductive, developmental, genotoxic, and carcinogenic effects. These data are discussed in terms of three exposure periods—acute (14 days or less), intermediate (15-364 days), and chronic (365 days or more). Levels of significant exposure for each route and duration are presented in tables and illustrated in figures. The points in the figures showing no-observed-adverse-effect levels (NOAELSs) or lowest- observed-adverse-effect levels (LOAELS) reflect the actual doses (levels of exposure) used in the studies. LOAELS have been classified into "less serious" or "serious" effects. "Serious" effects are those that evoke failure in a biological system and can lead to morbidity or mortality (e.g., acute respiratory distress or death). "Less serious" effects are those that are not expected to cause significant dysfunction or death, or those whose significance to the organism is not entirely clear. ATSDR acknowledges that a considerable amount of judgment may be required in establishing whether an end “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 10 2. HEALTH EFFECTS point should be classified as a NOAEL, "less serious" LOAEL, or "serious" LOAEL, and that in some cases, there will be insufficient data to decide whether the effect is indicative of significant dysfunction. However, the Agency has established guidelines and policies that are used to classify these end points. ATSDR believes that there is sufficient merit in this approach to warrant an attempt at distinguishing between "less serious" and "serious" effects. The distinction between "less serious” effects and "serious" effects is considered to be important because it helps the users of the profiles to identify levels of exposure at which major health effects start to appear. LOAELs or NOAELSs should also help in determining whether or not the effects vary with dose and/or duration, and place into perspective the possible significance of these effects to human health. The significance of the exposure levels shown in the Levels of Significant Exposure (LSE) tables and figures may differ depending on the user’s perspective. Public health officials and others concerned with appropriate actions to take at hazardous waste sites may want information on levels of exposure associated with more subtle effects in humans or animals (LOAEL) or exposure levels below which no adverse effects (NOAELs) have been observed. Estimates of levels posing minimal risk to humans (Minimal Risk Levels or MRLs) may be of interest to health professionals and citizens alike. Estimates of exposure levels posing minimal risk to humans (Minimal Risk Levels or MRLs) have been made for sulfuric acid. An MRL is defined as an estimate of daily human exposure to a substance that is likely to be without an appreciable risk of adverse effects (noncarcinogenic) over a specified duration of exposure. MRLs are derived when reliable and sufficient data exist to identify the target organ(s) of effect or the most sensitive health effect(s) for a specific duration within a given route of exposure. MRLs are based on noncancerous health effects only and do not consider carcinogenic effects. MRLs can be derived for acute, intermediate, and chronic duration exposures for inhalation and oral routes. Appropriate methodology does not exist to develop MRLs for dermal exposure. Although methods have been established to derive these levels (Barnes and Dourson 1988; EPA 1990), uncertainties are associated with these techniques. Furthermore, ATSDR acknowledges additional uncertainties inherent in the application of the procedures to derive less than lifetime MRLs. As an example, acute inhalation MRLs may not be protective for health effects that are delayed in development or are acquired following repeated acute insults, such as hypersensitivity reactions, ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 11 2. HEALTH EFFECTS asthma, or chronic bronchitis. As these kinds of health effects data become available and methods to assess levels of significant human exposure improve, these MRLs will be revised. A User’s Guide has been provided at the end of this profile (see Appendix B). This guide should aid in the interpretation of the tables and figures for Levels of Significant Exposure. 2.2.1 Inhalation Exposure Few studies were identified regarding the toxic effects of sulfur trioxide. Within the respiratory tract, sulfur trioxide reacts rapidly with water to form sulfuric acid (IARC 1992). Therefore, the adverse effects of sulfur trioxide are expected to be the same as those of sulfuric acid, except that more heat may be generated with sulfur trioxide than with sulfuric acid. There are many factors in addition to exposure concentration that determine the response to the inhalation of sulfuric acid aerosols. One factor is aerosol size which determines the location in the respiratory tract where sulfuric acid aerosols will deposit and result in effects. Humidity, both in the environment and in the respiratory tract, helps to determine the aerosol size. As sulfuric acid droplets enter the respiratory tract they grow rapidly because of the humidity in the respiratory tract, and the size increases with increasing depth. Because of this growth in the respiratory tract, originally small sulfuric acid droplets have a greater probability of depositing than inert particles of the same original size, and have a greater probability of penetrating deeper into the lung than inert particles of the same size as the grown droplets (Carabine and Maddock 1976). Aerosols that do not change size as they enter the respiratory tract deposit in the nasopharyngeal region by inertial impaction if they are 5-30 pm in diameter, in the tracheobronchial region by sedimentation if they are 1-5 um in diameter, and in the alveolar region by diffusion if they are <1 pm in diameter (Witschi and Last 1996). Aerosols are usually a range of sizes that approximate a log-normal distribution. This size distribution is most frequently described by the median or geometric mean and the geometric standard deviation (Witschi and Last 1996). For studies of sulfuric acid aerosols, the diameters often reported are the mass median diameter (MMD) and the mass median aerodynamic diameter (MMAD) which takes into account both the density of the particle and the aerodynamic drag. Several inhalation studies of sulfuric acid aerosol report aerosol size as count median diameter (CMD) or volume median diameter (VMD). Aerosol size in pm is presented in the inhalation LSE table (Table 2-1), and the type of ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 12 2. HEALTH EFFECTS measurement is indicated. In Figure 2-1, aerosol sizes are indicated with footnotes as ultrafine (U) <0.1 pm, small (S) 0.1—<1 pm, medium (M) 1-<5 pm, and large (L) 5-30 pm. Acid aerosols typically found in the ambient air have an MMAD of 0.3-0.6 um, while industrial aerosols can have MMADs as large as 14 um (Lippmann et al. 1987). In addition to aerosol size, conditions of exposure are very important in determining the effect of sulfuric acid. For example, breathing rate, which is affected by physical activity, and the method of breathing (nose, mouth, oronasal) help to determine where in the respiratory tract the aerosol deposits, and the site of deposition determines the effect of the aerosol. How much of the acid is neutralized by ammonia or other alkaline substances, both in the ambient environment and within the respiratory tract, also determines the effects of sulfuric acid aerosols. Ammonia is emitted in relatively high concentrations in breath and sweat, with concentrations of 120-1280 ppb measured in the exhaled air of humans (Suh et al. 1992). Therefore, as sulfuric acid enters the breathing zone it may be neutralized resulting in lower personal exposure. More information about sources of ammonia can be found in the ATSDR profile on ammonia (ATSDR 1990). The acid neutralization capacity of the respiratory mucus may also determine whether or not inhalation of sulfuric acid aerosols will result in a response. For example, it has been suggested that asthmatics are more sensitive to sulfuric acid because the pH of their mucus is lower than normal subjects (Holma 1985). In the discussions that follow, conditions of exposure especially in human exposure studies will be presented. Exposures were whole-body chamber exposures unless indicated otherwise. In addition, in the inhalation LSE table (Table 2-1), studies in which the volunteers were asthmatics are indicated as human-a. 2.2.1.1 Death Studies regarding death of humans following acute- and intermediate-duration inhalation exposure to sulfuric acid aerosols were not identified in recent years. Increased mortality, especially of elderly persons and those with preexisting cardiac and respiratory disease, has been reported during or shortly after air pollution episodes (Costa and Amdur 1996). Because it is not possible to clearly separate the effects of sulfuric acid aerosols from other pollutants, including particulates, sulfur dioxide, and ozone, these studies are not discussed. In general, increased mortality in these studies seems to correlate more closely with particulate matter, including sulfuric acid aerosols. In a study that tried to separate ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 13 2. HEALTH EFFECTS out the effects of sulfuric acid aerosols from sulfur dioxide and from British smoke (a measure of particulates), the log of sulfuric acid aerosol concentrations in London was more strongly correlated with total mortality than either sulfur dioxide or British smoke (Thurston et al. 1989). The authors of the study concluded that their results were consistent with the hypothesis that sulfuric acid is the portion of the particulate mass with greater health significance. No association between mortality and environmental sulfate concentrations was observed among 6,340 non-smoking persons living in California (Abbey et al. 1995). Overall mortality of workers was not associated with acid exposure at steel factories (Beaumont et al. 1987) or at a sulfuric acid plant (Englander et al. 1988). Numerous studies are available concerning the mortality of animals following inhalation exposure to sulfuric acid. One-hour LCys of 347 and 420 ppm fuming sulfuric acid have been reported for female and male rats, respectively (Vernot et al. 1977). Fuming sulfuric acid is sulfuric acid with up to 80% free sulfur trioxide (Budavari 1989). The percentage of sulfur trioxide in the Vernot et al. (1977) study was not stated. The LC,, values expressed as mg sulfur trioxide/m® were 1,136 and 1,375 for female and male rats, respectively. Because fuming sulfuric acid was used in this study, the Vernot et al. (1977) study is not presented in Table 2-1 or Figure 2-1. The lowest concentration of sulfuric acid aerosols that resulted in the death of rats was 383 mg/m’ (Treon et al. 1950). One rat died during the 1st day of a 7-hour exposure, and one rat died on the 2nd day of a 7-hour exposure. Following one 7-hour exposure, two of two rats died at 699 mg/m’, while all rats survived a 7-hour exposure to sulfuric acid aerosols at 461 mg/m® (Treon et al. 1950). Following one 3.5-hour sulfuric acid aerosol exposure, two of two rats died at 1,470 mg/m’ with no deaths observed at 718 mg/m’ (Treon et al. 1950). The aerosol size used in the Treon et al. ( 1950) study was described as being in the range of 1-2 pm. In a 5-day exposure study in which the duration of the exposure each day was not stated, no rats died during exposure to 100 mg/m? sulfuric acid aerosols at an MMAD of 0.72 pm (Cavender et al. 1977). Mice were more susceptible to sulfuric acid aerosol exposure (diameter 1-2 um) than rats (Treon et al. 1950). Following five daily 7-hour exposures, four of five mice died at 383 mg/m’, with all surviving at 203 mg/m*. Exposure for 7 hours resulted in the deaths of two of five mice at 699 mg/m’, with all surviving at 461 mg/m’, while exposure for 3.5 hours resulted in the deaths of two of five at 549 mg/m’. Lower concentrations of sulfuric acid were not studied in mice exposed for 3.5 hours. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 14 2. HEALTH EFFECTS Among the species tested, guinea pigs are the most sensitive to exposure to sulfuric acid aerosols. During a 1-hour exposure to 52-61 mg/m’ sulfuric acid (MMAD 0.8-2.1 um), about 6% of the exposed guinea pigs died (Stengel et al. 1993). The lowest concentration of the range is shown in Table 2-1 and Figure 2-1. The number of guinea pigs exposed was not stated. Before death, the guinea pigs developed labored breathing. Exposure of guinea pigs to 87 mg/m’ sulfuric acid aerosols in the range of 1-2 pm resulted in the death of all three exposed animals within 2.75 hours (Treon et al. 1950). The deaths of guinea pigs were attributed to an acute respiratory response to the acid exposure. Younger guinea pigs are more sensitive to sulfuric acid aerosols than older guinea pigs. For guinea pigs exposed to sulfuric acid aerosols with a mean aerosol size of 1 pm, 8-hour LCsys of 18 and 50 mg/m* were reported for 1-2-month-old and 1.5-year-old guinea pigs, respectively (Amdur et al. 1952a). During a 72-hour exposure to 12 mg/m’ sulfuric acid aerosols (mean particle size 1 pm), approximately 10% of the exposed guinea pigs died during the first 8 hours, with no additional deaths occurring (Amdur et al. 1952a). No guinea pigs exposed to 8 mg/m’ sulfuric acid aerosol for 72 hours died. The effects observed in the guinea pigs that died included gross areas of hemorrhage in the lungs, which were frequently most pronounced around the hilar regions, surface hemorrhage of the adrenal glands, and nasal bleeding at higher concentrations. Microscopically, hemorrhage and edema were observed in the lungs, with leukocytes and erythrocytes in the alveolar spaces. Congestion of the bronchi, alveoli, and blood vessels was also observed. The effect of aerosol size on survival of guinea pigs exposed to sulfuric acid aerosols has been studied. Following exposure to sulfuric acid aerosols with MMADs of 0.8 and 0.4 um, LCqs of 30.3 and >109 mg/m’, respectively, were reported for guinea pigs exposed for 8 hours (Wolff et al. 1979). In another study, 8-hour LCys of 59.8 and 27.3 mg/m’ were reported for aerosols with MMADs of 0.8 and 2.7 um, respectively (Pattle et al. 1956). Pattle et al. (1956) also showed that a lowered ambient temperature enhanced the toxicity of sulfuric acid aerosols in guinea pigs. For an aerosol of MMAD 0.8 pm, the LCs were 59.8 and 46.9 mg/m’ at 20°C and 0°C, respectively. Following exposure of rabbits to sulfuric acid aerosols with a diameter in the range of 1-2 ym, one of two died following a 3.5-hour exposure to 1,470 mg/m’, one of two died following a 7-hour exposure to 1,610 mg/m?, and two of two died following five daily 7-hour exposures to 383 mg/m’ (Treon et al. 1950). No deaths of rabbits occurred at 718 mg/m? for 3.5 hours, 699 mg/m’ for 7 hours, or “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 15 2. HEALTH EFFECTS 203 mg/m’ for five daily 7-hour exposures. Among the exposed rabbits that died, most of the deaths were attributed to infectious pneumonia that occurred after the chemical injury, rather than an acute respiratory response as observed in guinea pigs. From their results in rats, mice, guinea pigs, and rabbits, Treon et al. (1950) concluded that at relatively high concentrations of sulfuric acid aerosols, the duration of exposure was more important in determining lethality than exposure concentration. No effect on survival was observed in cynomolgus monkeys or guinea pigs exposed to sulfuric acid aerosols 23.3 hours/day, 7 days/week, for 78 weeks (monkeys) or 52 weeks (guinea pigs) (Alarie et al. 1973). The monkeys were exposed at concentrations of 0, 0.38, 0.48, 2.43, or 4.79 mg/m* (MMDs of 2.15, 0.54, 3.6, and 0.73 pm, respectively), and the guinea pigs were exposed at concentrations of 0, 0.08, or 0.1 mg/m’ (MMDs of 0.84 and 2.78 um, respectively). All LOAEL and LCq, values from each reliable study for death in each species for acute exposure are recorded in Table 2-1 and plotted in Figure 2-1. 2.2.1.2 Systemic Effects The highest NOAEL and representative LOAEL values from reliable studies for systemic effects in each species and duration category are recorded in Table 2-1 and plotted in Figure 2-1. No studies were located regarding gastrointestinal, musculoskeletal, or dermal effects in humans or animals after inhalation exposure to sulfur trioxide or sulfuric acid. Respiratory Effects. Respiratory tract irritation was noted by 12 persons working next to a chemical plant that emitted sulfur trioxide (Stueven et al. 1993). The subjects were exposed to an unspecified concentration for approximately 2 hours, and 9 of 12 subjects went to the hospital. The symptoms reported included pleuritic chest pain in 3 subjects, chest tightness in 2 subjects, vague chest discomfort in 1 subject, cough in 1 subject, and an acidic taste in the mouth and nasal irritation in 1 subject. All subjects were asymptomatic 6 hours after the exposure when they were released from the hospital. Adult respiratory distress syndrome was reported in a man accidentally exposed to high concentrations of sulfuric acid fumes (Knapp et al. 1991). Effects noted upon initial hospital admission included hypotension, and a crackling sound from his lungs. A chest x-ray revealed diffuse confluent opacities consistent with chemical pneumonia. Less than 24 hours later, a chest X-ray ***DRAFT FOR PUBLIC COMMENT*** «+«INIWWOO O118Nd HOH 14VHJ... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation iii Lonel Keyto' Species frequency NOAEL Less serious Serious Reference figure (stain) (specific route) System {my/m3) {mg/m3) (mg/m3) aerosol size (um) ACUTE EXPOSURE Death 1 Rat 3.5hr 1470 (2/2 died) Treon et al. 1950 (NS) (WB) diameter 1-2 2 Rat 7 hr 699 (2/2 died) Treon et al. 1950 (NS) (WB) diameter 1-2 3 Rat 2d 383 (2/2 died) Treon et al. 1950 (NS) 7 hr/d diameter 1-2 (ws) 4 Mouse 3.5 hr 549 (2/5 died) Treon et al. 1950 (NS) (WB) diameter 1-2 5 Mouse 7 hr 699 (2/5 died) Treon et al. 1950 (NS) (w8) diameter 1-2 6 Mouse 5d 383 (4/5 died) Treon et al. 1950 (NS) 7 hr/d diameter 1-2 (WB) S103443 H1TV3H ¢ alioy 21dN47INS ANY 3aIXOIdL §N4dInNs 91 ++LNIWWNOD J1N8Nd HOH 14vHA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 7 Gn Pig 8 hr 18 (LC,, 1-2 months old) Amdur et al. (NS) (WB) 1952a mean particle size 1 50 (LC, 1.5 years old) 8 Gn Pig 72 hr 12 (approximately 10% died) ~~ Amdur etal. (NS) (WB) 1952a mean particle size 1 9 Gn Pig 8 hr 27.3 (LC,) Pattle et al. 1956 (NS) (WB) MMAD 2.7 10 Gn Pig 8 hr 59.8 (LC, at 20°C) Pattle et al. 1956 (NS) (WB) MMAD 0.8 46.9 (LC, at 0°C) 11 Gn Pig 1hr 52 M (about 6% died, total Stengel et al. (Hartley) (N) number exposed not 1993 stated) MMAD 0.8-2.1 12 Gn Pig 2.75 hr 87 (3/3 died) Treon et al. 1950 (NS) (Ws) diameter 1-2 S103443 H1TV3aH 2 aidv JIHN4TINS ANY 3AIX0IH.L HN4INsS Li «LNIJWWOD O178Nd HOH 14VHd... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure 2 duration/ LOAE! Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) aerosol size (um) 13 Gn Pig 8 hr 30.3 (LC) Wolff et al. 1979 (Hartley) (WB) MMAD 0.8 14 Gn Pig 8 hr 109 (5/16 died) Wolff et al. 1979 (Hartley) (WB) MMAD 0.4 15 Rabbit 3.5hr 1470 (1/2 died) Treon et al. 1950 (NS) (WB) diameter 1-2 16 Rabbit 7 hr 1610 (1/2 died) Treon et al. 1950 (NS) (WB) diameter 1-2 17 Rabbit 5d 383 (2/2 died) Treon et al. 1950 (NS) 7 hr/d diameter 1-2 (WB) Systemic 18 Human-a 1hr Resp 0.1 Anderson et al. (WB) 1992 MMAD 1 S103443 H1IV3aH ¢ alov OldN4INS anv 3aIXOold1L iN4INs 8 ++LNIFWWNOD OIN8Nd HOH L4vH..s Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) SYStem (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 19 Human-a 16 min Resp 3 Aris et al. 1991 (MO) VMD 0.4, 6 20 Human-a 1hr Resp 0.396 0.999 (3.5% increased specific Avol et al. 1988 (WB) airway resistance, 4% MMD 0.9 decreased FEV,) Ocular 0.396 0.999 (eye irritation) 21 Human-a 1hr Resp 0.127 Avol et al. 1990 (WB) MMAD 0.5 22 Human-a 3hr Resp 0.107 Frampton et al. (WB) 1995 MMAD 0.64 23 Human-a 40-45min Resp 0.07 (transient decrease in Hanley et al. (MO) forced vital capacity and 1992 MMAD 0.72 FEV) S103443 HITV3H ¢ aidv J1IHN4INS any 3aiXoidL n4ns 61 «-+«1NIWWNOO O1718Nd HOH 14VHQA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 24 Human-a 50 min Resp 0.1 (35-45% increased Koenig et al. (MO or FA) respiratory resistance, 1985 16-22% decreased MMAD 0.6 maximum flow at 50% and 75% of VC, 7-8% decreased FEV,) 25 Human-a 45,90 min Resp 0.07 Koenig et al. (M) 1992 MMAD 0.6 26 Human-a 40 min Resp 0.07 Koenig et al. (MO) 1993 MMAD 0.6 27 Human-a 1hr Resp 0.41 Linn et al. 1986 (WB) MMAD 0.6 28 Human-a 2d Resp 0.1 Linn et al. 1994 6.5 hr/d MMAD 0.5 (WB) 29 Human-a 16 min Resp 0.1 0.45 (15% decreased specific Utell et al. 1983 (MO) airway conductance at MMAD 0.8 rest) S103443 HLV3AH ¢ aiov 21dN41NS aNy 3aIXoldl ’UN4iNs 0c «+LNIJWWOD O118Nd HO4 14vHA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 30 Human-a 30 min Resp 0.35 (19% reduction FEV,, Utell et al. 1989 (MO) 47% reduction in MMAD 0.8 maximum expiratory flow rates at 60% total lung capacity) 31 Human-n 5-15 min Resp 0.35M (35% increase in Amdur et al. (FA) respiration rate, 20% 1952b decrease in maximum mean particle flow rates) size 1 32 Human-n 1hr Resp 1.578 Avol etal. 1988 We) MMD 0.9 33 Human-n 1hr Resp 0471 M Bowes etal. (H) 1995 MMAD 10 Cardio 0471 M 34 Human-n 2hr Resp 1 Frampton et al. (WB) 1992 MMAD 0.9 S103443 H11V3H ¢ ai0v JIN4INS ANY 3aIXOld.L UN4INs le Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) ++ LINTFWWOD O118Nd HOH L4VH..s Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 35 Human-n 2hr Resp 1.2M Horvath et al. (WB) 1987 MMD 0.05 36 Human-n 4hr Resp 0.1 Kulle et al. 1982 (WB) MMD 0.13 37 Human-n 4d Resp 0.471M (increased tracheal and Laube et al. 1993 60 min/d lung clearance of 3.4 MMAD 10.3 (H) micrometer particles) 38 Human-n 1 hr Resp 0.33 0.98 (decreased bronchial Leikauf et al. (N) clearance of 7.6 1981 micrometer particles) MMD 0.5 33 Human-n 1 hr Resp 0.108 (decreased bronchial Leikauf et al. (N) clearance of 4.2 1984 micrometer particles) MMD 0.5 40 Human-n 2hr Resp 1 (15% increased bronchial Newhouse et al. (MO) clearance of 3 1978 micrometer particles) MMD 0.5 alov O1dN4TINS ANY 3AIX0Id1 JN4dINs S103443 H1TV3H ¢ 2c «+«.NIWWOD OI18Nd HOH 14vHQ... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Key to Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 41 Human-n 1-2 hr Resp (N) 42 Human 8 hr Resp (occup) 43 Rat 5d Resp (Fischer- 344) NS hr/d (WB) 44 Rat 4 hr Resp (Fischer- 344) (WB) 45 Rat 7d Resp (Sprague- 23.5 hr/d Dawley) (WB) 0.1 M (reduced rate of bronchial mucociliary clearance of 5.2 micrometer particles) 0.18 M 100 M 94.1F (increased thickness of mucus layer) 1.29 M Spektor et al. 1989 MMAD 0.5 Gamble et al. 1984a MMAD 5 Cavender et al. 1977 MMD 0.7-0.9 Lee etal. 1995 MMD 0.8 Warren and Last 1987 MMAD 0.4 S103443 H1V3aH ¢ aldv J1ldN4INS aNv 3AIXOId1 4N41Ns £2 ++ LNIWWOD O118Nd HOS 14VHA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a . duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 46 Mouse Gd 6-15 Resp 20 F Murray et al. CF-1 7 hr/d 1979 (WB) CMD 1.6,2.4 Hepatic 20F Bd Wt 20 F 47 Gn Pig 1 hr Resp 1.9 (resistance increased Amdur 1958 (NS) (H) about 1.5-fold) MMD 0.8 48 Gn Pig 1hr Resp 2.3 (resistance increased 436 (resistance increased Amdur 1958 (NS) (H) about 1.4-fold) about 4.2-fold, increased ~~ MMD 2.5 lung weights, edema) 49 Gn Pig 1hr Resp 30.5 (resistance increased Amdur 1958 (NS) (H) about 1.4-fold) MMD 7 50 Gn Pig 1hr Resp 0.1 (resistance increased Amdur et al. (NS) (H) 41%, compliance 1978 decreased 27%) MMD 0.3 51 Gn Pig 1 hr Resp 0.11 (resistance increased Amdur et al. (NS) (H) 14%) 1978 MMD 1 S103443 H1IVaH ¢C aiov 21dN4INS ANY 3aiXoldL HN4INs ve «+ INIFWWOD O1M8Nd HOH 14VHO..s Table 2-1. Levels of Significant Exposure to Sulfuric Acid . Inhalation (continued) Exposure a duration/ LOAEL Key to Species gequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 52 Gn Pig 5d Resp 10F (diffuse regional alveolitis) Cavender et al. (Hartley) NS hr/d 1977 (WB) MMD 0.7-0.9 53 Gn Pig 1or4d Resp 0.3M (increased Chen et al. (Hartley) 3 hr/d beta-glucuronidase, 1992a (N) lactate dehydrogenase, MMD 0.3 and total protein in lung lavage fluid) 54 Gn Pig lor4d Resp 0.3M (increased protein, Chen etal. (Hartley) 3 hr/d lactate dehydrogenase 1992a (N) and beta-glucuronidase MMD 0.04 in lung lavage fluid) 55 Gn Pig 1 hr Resp 0.03 M 0.2M (increased airway Chen et al. (Hartley) (H) responsiveness to 1992b acetylcholine) MMD 0.06 56 Gn Pig 2d Resp 25 (edema and hemorrhage in Cockrell et al. (Hartley) 6 hr/d the lungs) 1978 (WB) MMD 1 S103443 H1IV3H ¢ aiov OidN4TINS dNV 3aIX0ld.L ’N4dINs 14 ~+LNIWWOD OIN8Nd HOS 14VHA..s Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOALL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) SYStem (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 57 Gn Pig 3,7,0or14d Resp 1M 3.2M (transient decrease and Kobayashi and (Hartley) 24 hr/d increase in airway Shinozaki 1993 (WB) responsiveness to MMAD 0.5 inhaled histamine) 58 Gn Pig 4 hr Resp 43.4 F (increased thickness of Lee etal. 1995 (Hartley) (WB) tracheal mucus layer, MMD 0.93 pulmonary edema in some guinea pigs) 59 Gn Pig 1 hr Resp 52 M (labored breathing, Stengel et al. (Hartley) (N) transient increased 1993 reactivity to substance P) MMAD 0.8-1.2 60 Gn Pig 8 hr Resp 17.4 (labored breathing, Wolff et al. 1979 (Hartley) (WB) hyperinflated lungs, MMAD 0.8 hemorrhage and transudation of the lungs) 61 Gn Pig 8 hr Resp 37.2 (hyperinflated lungs and Wolff et al. 1979 (Hartley) (WB) labored breathing) MMAD 0.4 S103443 H1V3AH °C aioy O1HN4INS ANY 3aIXOldL JN41Ns 9c Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) +«INIWWOD OI78Nd HOH L4VvH(Q... Exposure # duration/ LOAEL Keyto Species ggoquency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 62 Rabbit 3hr Resp 0.05 M 0.075M (increased El-Fawal and (New (N) responsiveness of Schlesinger Zealand) bronchial rings to 1994 acetylcholine and MMD03 histamine) 63 Rabbit Gd 6-18 Resp 5F 20F (subacute rhinitis and Murray et al. (New 7 hr/d tracheitis in dams) 1979 Zealand) (WB) CMD 16,24 Hepatic 20 F Bd Wt 20 F 64 Rabbit 14d Resp 0.05 (decreased clearance Schlesinger (New 0.5-4 hr/d from the respiratory 1990a Zealand) (WB) region of 3.5 micrometer MMAD 0.3 particles) 65 Rabbit 1hr Resp 0.25M (accelerated clearance Schlesinger and (New (N) of 3.5 micrometer Gearhart 1986 Zealand) particles from the MMD 0.3 alveolar region) 66 Rabbit 1hr Resp 0.1 M 0.2M (increased mucociliary Schlesinger et (New (MO) clearance of 4.5 al. 1984 Zealand) micrometer particles) MMAD 0.3 aidv OIl”HN4INS ANY 3AIXO0IHL HN4TNS S103443 H1TVaH 2 LZ Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) +++1NIWWOD OIN8Nd HOH 14vHQA... Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 67 Rabbit 3hr Resp 0.125 M Schlesinger et (New (N) al. 1992b Zealand) MMD 0.3 68 Rabbit 2hr Resp 0.5M Zelikoff and (New (N) Schlesinger Zealand) 1992 MMD 0.3 69 Rabbit 4d Resp 0.75 M 1M (increased lactate Zelikoff et al. (New 2 hr/d dehydrogenase and 1994 Zealand) (N) protein in lung lavage MMD 0.3 fluid 24 hours after the last exposure) 70 Ferret 4 hr Resp 05F 1F (significantly accelerated Mannix et al. (NS) (N) clearance from the lungs 1991 of 1.9 micrometer MMAD 0.3 particles) Immunological/Lymphoreticular 71 Human-n 2hr 1 Frampton et al. (WB) 1992 MMAD 0.9 aiov JldN4INS ANY 3AIX0I41L ’HN4NsS S103443 H1TV3H ¢ 8¢ +INIJWWOO O1M18Nd HOH L4VH uss Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 72 Mouse 1or5d 0.543 F Grose et al. (CD-1) 2 hr/d 1982 (H) VMD <0.1 73 Gn Pig lor4d 0.3 M Chen et al. (Hartley) 3 hr/d 1992a (N) MMD 0.3 74 Gn Pig 1ordd 0.3 M (decreased phagocytic Chen et al. (Hartley) 3 hr/d activity of alveolar 1992a (N) macrophages) MMD 0.04 75 Gn Pig 2 wk 0.3 M 1M (enhancement of Fujimaki et al. (Hartley) continuous antigen-induced 1992 (WB) histamine release by MMD 0.55-0.73 mast cells) 76 Gn Pig 3 hror 0.969M (15.6-23.3% reduced Quetal. 1993 (Hartley) 5d intracellular pH in MMD 0.3 3 hr/d alveolar macrophages) (ws) S103443 HLIV3H ¢ aiov 018N4INS ANV 3aiXoid.L "4n4dns 6C ++INIWWOD O118Nd HO4 L4vd(d... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a ] duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 77 Rabbit 3hr 0.05 M 0.125M (decreased pH of Chen et al. 1995 (New (N) alveolar macrophages) MMD 0.3 Zealand) 78 Rabbit 13d 0.5M (increased phagocytic Schlesinger (New 2 hrd activity of alveolar 1987 Zealand) (N) macrophages at day 3, MMD 0.3 decreased by day 14) 79 Rabbit 5d 05M 1M (decreased phagocytic Schlesinger et (New 1 hr/d activity of alveolar al. 1990a Zealand) (WB) macrophages) MMD 0.3 80 Rabbit 3 hr 0.05 M 0.075M (effects on Schlesinger et (New (N) macrophages: decreased al. 1992b Zealand) phagocytic activity, MMD 0.3 production of superoxide anion, tumor necrosis factor activity) 81 Rabbit 2h 0.05 M 0.075M (effects on Zelikott and (New (N) macrophages: decreased Schlesinger Zealand) tumor necrosis factor 1992 MMD 0.3 cytotoxic activity, decreased superoxide anion production) S103443 HIV3H 2 aiov OldN4INS aNV 3aiXoldL ’4Nn4dins oe +«1NIWWOO OI79Nd HO4 14VHQ... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a } duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 82 Rabbit 4d 05M 0.75M (suppressed Zelikoff et al. (New 2 hr/d macrophage-mediated 1994 Zealand) (N) immunity) MMD 0.3 Neurological 83 Human-a 1hr 0.396 0.999 (increased report of Avol et al. 1988 (WB) fatigue and headaches) MMD 0.9 84 Human-n 1hr 1.578 Avol et al. 1988 (WB) MMD 0.9 Reproductive 85 Mouse Gd 6-15 20F Murray et al. CF-1 7 hr/d 1979 (WB) CMD 1.6, 2.4 86 Rabbit Gd 6-18 20 F Murray et al. (New 7 hr/d 1979 Zealand) (WB) CMD 16,24 S103443 H1TV3H °C alov 01dN4INS ANY 3aiXoldl ’in4dins 85 Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) ++INIFWWOD O178Nd HO4 14VvHQA... Exposure a duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) Developmental 87 Mouse Gd 6-15 20 Murray et al. CF-1 7 hr/id 1979 (WB) CMD 1.6, 2.4 88 Rabbit Gd 6-18 20 Murray et al. (New 7 hr/d 1979 Zealand) (WB) CMD 16,24 INTERMEDIATE EXPOSURE Systemic 89 Gn Pig 32-139d Resp 2 25 (mild histopathologic Thomas et al. (NS) continuous changes in the lungs 1958 (WB) including edema) mean diameter 0.5 80 Gn Pig 32-139d Resp 2 (mild histopathologic Thomas et al. (NS) continuous changes in the lungs 1958 (WB) including edema) mean diameter 0.9 aldv J1"N4INS ANY 3AIX0ld.L °UN4InsS S1O03443 H1TV3H 2 ce «+ INIWWOD O179Nd HOH 14VHO.s Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure a ) duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 91 92 93 94 95 Gn Pig 32-139 d Resp (NS) continuous (WB) Dog 225d Resp (Beagle) 21 hr/d (WB) Rabbit 4 or 8 mo Resp (New 5 d/wk Zealand) 1 hr/d (N) Rabbit 570r240d Resp (New 5 d/wk Zealand) 1 hr/d (N) Donkey 6 mo Resp (NS) 5 d/wk 1 hr/d (N) 2 (mild histopathologic changes in the lungs including edema, histopathological changes in the upper respiratory tract) 0.755 (15% decreased carbon monoxide diffusion capacity) 0.25M (increased bronchial sensitivity to acetylcholine) 0.25M (accelerated clearance of 3.5 micrometer particles from the alveolar region) 0.106 (erratic and slower bronchial clearance of 5 micrometer ferric oxide particles) Thomas et al. 1958 mean diameter 4 Lewis et al. 1969 90% <0.5 Gearhart and Schlesinger 1986 MMD 0.3 Schlesinger and Gearhart 1986 MMD 0.3 Schlesinger et al. 1979 MMAD 0.5 S103443 H1TV3H ¢ aiov 214N41NS ANY 3aiXOoidL JN4dINs €e = LNIFWWOD ON8Nd HOH 14VYHA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure 2 ) duration/ LOAEL Keyto Species gequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) Immunological/Lymphoreticular 96 Gn Pig 4 wk 1M 3.2M (suppression of Fujimaki et al. (Hartley) continuous A23187-induced 1992 (WB) histamine release by MMD 0.55-0.73 mast cells) CHRONIC EXPOSURE Systemic 97 Human 1->15 yr Resp 126 M El-Sadik et al. (occup) 1972 NS Other 12.6 M (lowered saliva pH; erosion of teeth in 39.4%) 98 Human average Resp 0.1 0.21 (5% decrease in forced Gamble et al. 12.2yr vital capacity) 1984b (occup) NS Other 0.1 0.21 (prevalence of tooth etching and erosion 37.9% compared to 7.9% at the lower concentration) 99 Human 9yr Resp 0.8 (bronchitis, pulmonary Kitagawa 1984 (environ) emphysema, sore throat) MMD 0.7-3.3 S103443 H1IV3H ¢ aidv OldN4INS ANY 3dIX0IH1 ’UN4INs ve +» LNFWNOD O178Nd HOH 14VHOus Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure 2 duration/ LOARL Key to Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 100 Human max 4.5yr Resp 0.5M Kremer ot al. (occup) 1994 NS 101 Human NS Other 3M (erosion of the teeth) Malcolm and (occup) Paul 1961 NS 102 Human few d Resp 1.4 M (slight increase in Williams 1970 to >40 yr bronchitis) NS (occup) 103 Monkey 78 wk Resp 0.48 4.79 (moderate to severe Alarie et al. 1973 (Cynomol- 7 d/wk bronchiolar epithelial MMD 0.54, 0.73 gus) 23.3 hr/d hypertrophy and (WB) hyperplasia, thickening of respiratory bronchioles in 9/9, no change in arterial oxygen) Cardio 4.79 Hemato 4.79 Hepatic 4.79 Renal 4.79 Bd Wt 4.79 S103443 H1TV3H ¢ alov 214N4INS ANY 3dIXOoldL °ndINs SE ~+INIJWWOO O179Nd HOH 14vHQA... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure 2 duration/ LOAE. Keyto Species gequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 104 Monkey 78 wk Resp 0.38 (slight bronchiolar 2.43 (moderate bronchiolar and Alarie etal. 1973 (Cynomol- 7 d/wk epithelial hyperplasia in alveoli epithelial MMD 2.15, 3.6 gus) 23.3 hr/d 5/9, slight thickening of hyperplasia, thickening of (WB) the walls of the walls of alveoli in 9/9, respiratory bronchioles in decreased arterial oxygen 3/9, no change in arterial to a mean of 70 mm Hg) oxygen) Cardio 2.43 Hemato 2.43 Hepatic 2.43 Renal 2.43 Bd Wt 2.43 105 Gn Pig 52 wk Resp 0.1 Alarie et al. 1973 (Hartley) 7 d/wk MMD 2.78 23 hr/d Cardio 0.1 (we) Hemato 0.1 Hepatic 0.1 Renal 0.1 Bd Wt 0.1 106 Gn Pig 52 wk Resp 0.08 Alarie et al. 1973 (Hartley) 7 d/iwk MMD 0.84 23 hr/d Cardio 0.08 (WB) Hemato 0.08 Hepatic 0.08 Renal 0.08 Bd Wt 0.08 S103443 H1V3H ¢ aiov 2iIdN4INS any 3dIXOIdL 4n4Ins 9€ «+INIFWWOD O1189Nd HOH L4VH... Table 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (continued) Exposure 2 } duration/ LOAEL Keyto Species frequency NOAEL Less serious Serious Reference figure (strain) (specific route) System (mg/m3) (mg/m3) (mg/m3) aerosol size (um) 107 Gn Pig 52 wk Resp 0.9 Alarie et al. 1975 (Hartley) 5 d/wk MMD 0.49 23 hr/d Cardio 0.9 (WB) Hemato 0.9 Hepatic 0.9 Renal 0.9 Bd Wt 0.9 108 Rabbit 1yr Resp 0.125M (decreased clearance of Schlesinger et (New 5 d/wk 4.5 micrometer particles al. 1992a Zealand) 2 hr/d MMD 0.3 (N) Bd Wt during 6 month recovery period) 0.125 M *The numbers correspond to entries in Figure 2-1. Bd Wt = body weight; Cardio = cardiovascular; CMD = count median diameter; d = day(s); F = female; FEV, = forced expiratory volume in 1 second; (FA) = face-mask; Gn Pig = guinea pig; Gd = gestation day; (H) = head-only; Hemato = hematological; hr = hour(s); Human-a = asthmatic; Human-n = normal; LCs, = lethal concentration S103443 H1TV3H 2 aiov O1dN41NS ANY 3aiXold.L 5N4INs 50% kill; LOAEL = lowest-observed-adverse-effect level; M = male; max = maximum; im = micrometer; min = minute(s); MMAD = mass median aerodynamic diameter; MMD = mass median diameter; mo = month(s); (MO) = mouth only; (N) = nose-only; NOAEL = no-observed-adverse-effect level; NS = not specified; (occup) = occupational; Resp = respiratory; VC = vital capacity; VMD = volume median diameter; (WB) = whole-body; wk = week(s); yr = year(s) LE ++«LNJWWOD O118Nd HOH 14vHd... Figure 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation Acute (<14 days) Systemic S$ Ls (mg/m?) 5 SE 3 &< 10000 1r 15h 16h v - ub 1000 | @ ww. ® ®ve Own 2r ® 14g & M 0 2g ‘s 17h 100 |} So PS ® M 79 M me = 11g HW Hn SM 13g 10 } ® S 8 19 M Rt 20 32 35 as A 3: BP 1} 27 2. a BAA 2 A A as S A A aS M A A 42 18 21 8 29 A 36 A 41 b am 22 2 aS 23 25 26 as as S 38 01} A A 3a A a a A A A S A A 39S 0.01 | Key k monkey HW LCs, (animals) a asthmatic r rat ; ; Aerosol sizes: 0.001 | i TE @ LOAEL for serious effects (animals) U ultrafine <0.1um g guinea pig @ LOAEL for less serious effects (animals) o Sel 0.1-<1um d dog O NOAEL (animals) im 0.0001 h rabbit L 5-30um tf forret A LOAEL for serious effects (humans) NS not specified o other A LOAEL for less serious effects (humans) ~The number next to each A point corresponds to 0.00001 t NOAEL (humans) entries in Table 2-1. S103443 H1IV3H 2 aidv 21lHN4INS aNY 3aIX0IdL HN4INs 8¢€ ++ IN3IWWOD O178Nd HOH 14vHQ... Figure 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (cont.) Acute (<14 days) (mg/m?) 10000 100 10 0.1 0.01 0.001 0.0001 0.00001 Systemic So oF E38 43r 44r Ss Ss 59 AQ a 48g 9 - 2 SM lg con 46m 60 M ® 5 52g ® °o © SS @ M O s ® 0 Qo 579 47g 3 S O sr 3 3 0 oan sth 00 O 53g 54g Oo M °F" a8 Qo S U 55 57 03" esh 0 0 sog S19 QQ @ VY s 62h 3 2 or $ 3 ao S 64h a? Oo $ Q 55g S oO : 8 oo Oo 62h S s Key k monkey H LCs, (animals) a asthmatic r rat . . Aerosol sizes: OUEE @® LOAEL for serious effects (animals) U ultrafine <0.1um g guinea pig ® LOAEL for less serious effects (animals) S small 0.1-<1um . M 1-<5um d dog O NOAEL (animals) L 5-30um ; rabbt A LOAEL for serious effects (humans) NS not specified I iy le A LOAEL for less serious effects (humans) The number next to each o other A point corresponds to NOAEL (humans) entries in Table 2-1. S103443 H1IV3H ¢ alov J1dN4INS aNv 3aIXoldl 4N4INs 6€ ++«INIWWOO O1N18Nd HOH L4VHO.ss Figure 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (cont.) Acute (<14 days) Systemic A o XS Q@ T gS = 83 5 go g Oo 5 OQ) = 8 3) % 2 oQ0 S S £ a 9 So S 3 q 3 2 s = $5 5 8 3 (mgm3) g 3S 3 ££ 5 8 5 © Q Q o £> 2 & 3S 10000 —E E e 2 mt 2 1000 100 46m 63h 46m 63h 85m 86h 87m 88h MM MM MM MM 0 O oO O oO O oO O 10 84 20 71 Te 769 en 82h 83 A as Ss 72m 78h Ss aS 1 3 A A o 73g 74g > 0 5 2 a A A 3 77h A Oo Qo oO Ss 79h 80h 81h 82h 4 20 759 0 S s s S 01 } as s 2 0 3 3 77h 8oh 81h S ss 0.01 Key k monkey WB | C_ (animals a asthmatic 0.001 } : rah so ( ) Aerosol sizes: @® LOAEL for serious effects (animals) U ultrafine <0.1um m mouse . yn g guinea pig ® LOAEL for less serious effects (animals) 3 $n) 0.1-<1um 0.0001 | d dog O NOAEL (animals) L 5 30nm } fe A LOAEL for serious effects (humans) NS not specified erre A a The number next to each 000001 L o oiher a LOAEL for less serious effects (humans) HO EorB RIE 16 NOAEL (humans) entries in Table 2-1. S103443 H1TV3H ¢ alov 01HN4TINS ANY 3aIXOldl 4N4INs ov ++LNIWWOD O1718Nd HOH 14VHAusx Figure 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (cont.) Intermediate (15-364 days) Systemic Ne S § s& a §< (mg/m?) & §& 3 10000 sg = 1000 100 89g s Qo 10 96g 90g 91g S S M Q ©) Qo 0 % 1 89g O S 0 Ca oh so Qo a 3 0.1 Qo 0.01 Key k monkey un LCs, (animals) a asthmatic 0.001 oC A ee ® LOAEL for serious effects (animals) A i ium g guinea pig @ LOAEL for less serious effects (animals) 5 $a Ojai =<; d dog O NOAEL (animals) L 5 30pm b.001 f fay A LOAEL for serious effects (humans) NS not specified oc other A LOAEL for less serious effects (humans) ~~ The number next to each 0.00001 point corresponds to entries in Table 2-1. A NOAEL (humans) S103443 H1V3aH 2 aidv 21dN4INS ANY 3AIXOIHL UN4INsS Lv ++ INIWWOO O118Nd HOH 14VHQ.an Figure 2-1. Levels of Significant Exposure to Sulfuric Acid - Inhalation (cont.) Chronic (>365 days) (mg/m?) 10000 1000 100 10 0.1 0.01 0.001 0.0001 0.00001 Systemic g 3 3 .O 2 § 8 $ S 5 5 2 Q 3 S = [0] = © As § § § & 5 g 8 a O L I @x Q oO 97 NS 4 103k 103k 103k 103k 103k 103k A i. S P S S 104k S 104k S 104k NS 02 @ Oo Er om M Om NS 2 NS 1079 Oo 107g oO 107g oO 107g oO 107g O 107g A SM WK oa So A S Mm oO M Oo oO O O NS A O 0 103h 105 105g 105 105 105g 108h ne 5 106g S Mo 106g mM 106g MS 106g M° 106g Mo 106g S A NS LI S S S s FA Oo OC o Oo o O45 4 0G A 98 105g 98 NS M NS i Key k monkey H LC, (animals) a asthmatic I r rat . . Aerosol sizes: m mouse ® LOAEL for serious effects (animals) U ultrafine <0.1um g guinea pig @ LOAEL for less serious effects (animals) ~~ S smal 0.1-<1pm ; —<5um ] ‘ 2 O NOAEL (animals) L 5-30um rabbi ferret A LOAEL for serious effects (humans) NS not specified o other A LOAEL for less serious effects (humans) ~~ The number next to each | A point corresponds to NOAEL (humans) entries in Table 2-1. S103443 H1TV3H ¢ aldVv J1dN47INS ANY 3aiXOoldL 4N4INs cy SULFUR TRIOXIDE AND SULFURIC ACID 43 2. HEALTH EFFECTS revealed a pneumomediastinum and a right pneumothorax. After 12 days in the hospital he was released feeling weak but without a cough or exertional dyspnea. After 3 days at home he returned to the hospital with an abscess in his lung. He was treated with antibiotics and released after 1 week. No permanent deficits in lung function were noted. Numerous studies are available regarding lung function in volunteers (healthy and asthmatic) exposed to sulfuric acid aerosols for short periods of time. In these studies lung function is often assessed using spirometry, which measures lung volumes and flows. Spirometric methods require subject cooperation and effort. Some of the most frequent measurements reported are forced vital capacity (FVC), forced expiratory volume in 1 second (FEV), and forced expiratory volume at 50% or 75% (FEV sq, FEV). FVC is the volume (in liters) of air that can be exhaled forcefully and rapidly after a maximal inspiration. FEV, is the volume of air that can be forcefully exhaled in 1 second. FEV, and FEV, are the volumes at 50% and 75% of the FEV curves (EPA 1994). Additional lung function tests can be completed using a whole-body plethysmograph. With this method, specific airway resistance (SRaw), the product of airway resistance and thoracic gas volume, can be determined. The effect of relative humidity on sulfuric acid-induced respiratory tract symptoms has been studied. Twelve normal male volunteers were exposed to 39.4 mg/m’ sulfuric acid aerosols at a relative humidity of 62% for 1 hour, or to 20.8 mg/m’ at a relative humidity of 91% for 30 minutes (Sim and Pattle 1957). The MMD for both humidity conditions was 0.99 um. The exposure at 62% relative humidity was well tolerated. There was some coughing on entering the chamber, which wore off within a few minutes. Resistance to airflow was increased 36-100% above normal in all 12 exposed subjects. At a relative humidity of 91%, the study authors indicated that the "mist was almost intolerable at the onset but the men were able to continue for a period of 30 minutes." Intense coughing was observed throughout the experimental period, and resistance to air flow was increased 43-150%. The study authors note that during the chamber exposures, the men were "allowed to walk around or smoke if they wished." Because exposure conditions were not well controlled, this study is not presented in Table 2-1 or Figure 2-1. The pattern of respiration was studied in an unspecified number of normal male volunteers exposed to sulfuric acid aerosols (mean particle size 1 um) with a face mask for 5-15 minutes at 0.35-5 mg/m’ (Amdur et al. 1952b). Changes in respiration were observed at all concentrations. At 0.35 mg/m?, a “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 44 2. HEALTH EFFECTS 35% increase in respiration rate and a 20% decrease in maximum flow rate occurred and continued throughout the exposure period. At 5 mg/m’, the major response was a decrease in minute volume. No effects on minute volume, tidal volume, respiratory frequency, or minute ventilation were noted in 7 healthy male volunteers exposed to 0.471 mg/m” sulfuric acid (MMAD 10 pm) for 1 hour using a head dome (Bowes et al. 1995). The 1-hour exposure consisted of 40 minutes of rest, followed by 20 minutes of moderately heavy exercise. The 10-pum aerosol size used in this study would not reach the lungs without oral breathing. In a 2-hour exposure study, no effects on pulmonary function were observed in nine normal male subjects exposed to 1.2-1.6 mg/m’ sulfuric acid (MMD 0.05 pm) with intermittent exercise (Horvath et al. 1987). Additional acute-duration exposures of normal humans have also not caused any adverse effects on pulmonary function tests (Anderson et al. 1992; Avol et al. 1988; Frampton et al. 1992; Koenig et al. 1993; Kulle et al. 1982; Laube et al. 1993; Leikauf et al. 1981, 1984: Linn et al. 1994; Newhouse et al. 1978; Stacy et al. 1983; Utell et al. 1984). All of the studies, except those by Leikauf et al. (1981, 1984) and Utell et al. (1984), used intermittent periods of exercise during exposure periods that lasted from 16 minutes to 4 hours. Studies of both normal and asthmatic subjects indicate that asthmatics are more sensitive to sulfuric acid exposures. A concentration-related increase in specific airway resistance (SRaw) was observed in asthmatics (12 men, 9 women) exposed to sulfuric acid aerosols (MMD 0.9 um) at 0, 0.396, 0.999, and 1.46 mg/m’ for 1 hour with three 10-minute exercise periods (Avol et al. 1988). The effect was significant at 0.999 mg/m’, and the lowest concentration is considered a NOAEL. No effects on pulmonary function were observed in normal subjects (14 men, 7 women) exposed to sulfuric acid aerosols at concentrations as high as 1.578 mg/m’ (Avol et al. 1988). Self-reported respiratory symptoms also showed a concentration-related increase in asthmatics, with no clear effect in normal subjects. Decreased specific airway conductance was observed in 17 asthmatics exposed to sulfuric acid aerosols (MMAD 0.8 um) through a mouthpiece at 0.45 mg/m’, while at rest for 16 minutes (Utell et al. 1983). At a concentration of 1 mg/m’, a reduction in FEV, was also observed. No effects on pulmonary function were observed when these subjects were exposed to 0.1 mg/m’. Reductions in FEV, and maximum expiratory flow rates at 60% of total lung capacity were observed in 15 asthmatic volunteers exposed to sulfuric acid aerosols (MMAD 0.8 pm) through a mouthpiece at 0.35 mg/m’ for 30 minutes ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 45 2. HEALTH EFFECTS (Utell et al. 1989). The response was greater when the subjects reduced ammonia concentrations in the mouth (tooth brushing, gargling with citrus juice) just before the exposure. Acute-duration exposure studies of volunteers indicate that adolescent asthmatics are generally more sensitive to inhalation of sulfuric acid aerosols than healthy older individuals. In a study of 22 adolescent (age 12-19) asthmatics exposed to 0.07 mg/m’ sulfuric acid aerosols (MMAD 0.71 pum) through a mouthpiece, transient decreases in FVC and FEV, were observed (Hanley et al. 1992). During the 40-45-minute exposures, the subjects exercised for 10 or 30 minutes. The investigators indicated that the response was small and was no longer significant 20 minutes after the end of the exposure. No effects on maximal flow at 50% or 75% of expired vital capacity or on total respiratory resistance were observed. Self-reported respiratory symptoms were not consistently related to exposure. Increased respiratory resistance, decreased maximum flow at 50% and 75% of vital capacity, and decreased FEV, were observed in 10 asthmatic adolescents exposed to 0.1 mg/m’ sulfuric acid (MMAD 0.6 pm) through a mouthpiece while wearing noseclips or through a face mask that allowed oronasal breathing (Koenig et al. 1985). Exposures were for 30 minutes at rest, followed by 20 minutes with moderate exercise. There were no statistically significant differences in pulmonary function between the two methods of exposure. A significant (p=0.03) decrease in FEV, of 6.1% was observed in 14 adolescent asthmatics that were exposed to 0.035 mg/m’ sulfuric acid (MMAD 0.6 pm) for 45 minutes (Koenig et al. 1992). During the exposures, the subjects exercised for alternating 15-minute periods. No significant effects on lung function were observed after 90 minutes of exposure at 0.035 mg/m’, or after 45 or 90 minutes of exposure at a concentration of 0.07 mg/m’. Therefore, the 0.07-mg/m’ concentration is presented as a NOAEL in Table 2-1 and Figure 2-1. Lung function, assessed by measuring SRaw and FEV, was not affected in exercising asthmatic volunteers (20 male and 12 female, age 6-16) exposed to sulfuric acid aerosols (MMAD 0.5 um) oronasally at up to 0.127 mg/m’, or orally at 0.134 mg/m” for 1 hour (Avol et al. 1990). The study authors noted that in 1 subject, SRaw increased by 14.2 cm H,O-second during the oronasal study, and by 8.4 cm H,0-second in the oral study, suggesting that there may be an acid-sensitive subpopulation of young asthmatics. Exposure of 9 asthmatic and 8 healthy seniors (age 60-75) to 0.07 mg/m’ sulfuric acid (MMAD 0.6 pm) through a mouthpiece while wearing noseclips (30 minutes at rest, 10 minutes of exercise) did not have any significant effects on FVC, FEV, or total respiratory resistance (Koenig et al. 1993). No effects on SRaw were observed in 9 asthmatics exposed to sulfuric acid aerosols for 16 minutes ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 46 2. HEALTH EFFECTS through a mouthpiece at 3 mg/m’ using aerosols of VMDs of 0.4 or 6 um (Aris et al. 1991). Exposure of 10 asthmatics to 1.4 mg/m’ sulfuric acid aerosols (VMD 6 um) for 1 hour with exercise during alternating 15-minute periods also had no effect on SRaw (Aris et al. 1991). Compared to exercise in clean air, no effects on SRaw or forced expiratory function were observed in 27 asthmatics exposed to 0.41 mg/m’ sulfuric acid aerosols (MMAD 0.5 pm) in a chamber for 1 hour with alterna- ting 10-minute periods of exercise (Linn et al. 1986). Compared to exposure to sodium chloride aerosols (0.105 mg/m’; MMAD 0.64 pm), a 3-hour exposure of 30 asthmatic or 30 normal volunteers to 0.107 mg/m’ sulfuric acid (MMAD 0.64 pm) had no significant effects on FVC or FEV, (Frampton et al. 1995). During the exposures, the subjects exercised intermittently. Changes in pulmonary function tests (thoracic gas volume, airway resistance, FVC, FEV,, specific airway conductance) were not observed in 12 normal volunteers immediately after and 18 hours after a 2-hour exposure to 1 mg/m’ sulfuric acid (MMAD 0.9 um) (Frampton et al. 1992). Bronchoscopy, completed 18 hours after the exposure, did not reveal any effects on the appearance of the airways or the bronchial mucosa. Collection of bronchial secretions from these subjects for 12 hours after sodium chloride or acid exposure did not reveal any changes in airway mucin glycoproteins or other closely associated proteins (Culp et al. 1995). Changes in SRaw, FVC, and FEV, were not observed in 30 asthmatic or 15 normal subjects exposed to 0.1 mg/m’ sulfuric acid (MMAD 1 pm) for 6.5 hours per day for 2 days (Linn et al. 1994). The subjects exercised during the first 50 minutes of each exposure hour and then rested for 10 minutes, during which pulmonary function tests were completed. Not all subjects were fit enough to exercise through six 50-minute periods. It is not stated whether these were normal or asthmatic subjects. In a study of asthmatic and normal volunteers exposed to 0.1 mg/m’ sulfuric acid aerosols (MMAD 0.5 pm) for 1 hour with alternating 10-minute exercise periods, only 1 of 14 asthmatics responded with a fall in FEV, during the first 15 minutes of exposure (Anderson et al. 1992). This study provides further evidence that there may be a subgroup of asthmatics that are more sensitive to sulfuric acid aerosol exposure. The response to unbuffered sulfuric acid aerosols compared to glycine-buffered sulfuric acid aerosols, both at pH 2, was studied by Fine et al. (1987). The 8 asthmatic subjects were exposed to the aerosols (MMD 5.3 um) through a mouthpiece during 3 minutes of tidal breathing. The exposure concentration was not stated, but the nebulizer had a mean liquid water output of 5.7 g/minute. SRaw ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 47 2. HEALTH EFFECTS was not increased after inhalation of unbuffered sulfuric acid at pH 2, while a >50% increase was observed in 7 of 8 subjects exposed to the glycine-buffered sulfuric acid at pH 2. This study shows that the composition of the acid, which determines its titratable acidity, will determine the airway responsiveness of asthmatics to acid aerosols. A number of human exposure studies suggest that exposure to sulfuric acid aerosols may have more of an effect on clearance of particles than on pulmonary function tests. The results reported in these studies are not only dependent on the sulfuric acid aerosol size but also on the size of the test particles. The size of the test particles determines where in the respiratory tract they will deposit. Sulfuric acid appears to have different effects on clearance in different regions of the respiratory tract. Enhanced clearance of a *"technetium-tagged albumin saline aerosol (MMD 3 pm) was noted in 10 humans exposed by mouth only to 1 mg/m’ sulfuric acid aerosol (MMD 0.5 pm) for 2 hours (Newhouse et al. 1978). Compared to exposure to water mist, bronchial clearance 2 hours after the exposure was increased by about 15%. Exposure to sulfuric acid aerosol had no effects on vital capacity, FEV, or FEV; ;s,. The study authors cautioned that enhanced bronchial clearance should not be considered a beneficial effect, and they attributed the effect to a patho-physiological response of the airways to inhaled irritants. The authors also suggested that longer term exposure may decrease clearance. Enhanced tracheal and lung clearance of 3.4 um **™technetium-tagged sulfur colloid was observed in 7 men exposed to 0.471 mg/m’ sulfuric acid (MMAD 10.3 um) 60 minutes/day for 4 days (Laube et al. 1993). Pulmonary function tests were not affected in these subjects. The study authors indicated that the mechanism underlying the observed changes in clearance was not known. In studies of clearance of *"technetium-tagged ferric oxide particles, subjects were exposed nose only to ferric oxide particles at an MMD of 7.6 ym (n=10) (Leikauf et al. 1981) or 4.2 pm (n=8) (Leikauf et al. 1984), followed by nose-only exposure to sulfuric acid aerosols (MMD 0.5 um) for 1 hour at about 0, 0.1, 0.3, or 1 mg/m®. No effects on tracheal mucociliary transport rate were noted for either particle size. For the 7.6-um particles, bronchial clearance half-times were 80, 50, 88, and 118 minutes at 0, 0.1, 0.3, and 1 mg/m’, respectively (Leikauf et al. 1981). The values were significantly different (p<0.05) from air exposure at the low and high concentrations. The study authors noted two response patterns in the subjects of this study. Six persons with slower clearance had significant alterations in bronchial clearance, while four subjects with faster clearance did not ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 48 2. HEALTH EFFECTS respond to sulfuric acid aerosol exposure. For the 4.2-um particles, bronchial clearance half-times were 80, 110, 106, and 142 minutes at 0, 0.1, 0.3, and 1 mg/m’, respectively (Leikauf et al. 1984). The values were significantly different (p<0.05) from air exposure at the low and high concentrations. In a comparison of their two studies, the authors stated that the inhibitory effect of the high concentration started sooner and lasted longer in the group inhaling the smaller radiolabelled ferric oxide particles. The high concentration had a greater effect on clearance from the tracheobronchial region compared to clearance from the nasopharyngeal region. After exposure to the low concentration, clearance half-time was longer than air exposure in the group inhaling the smaller ferric oxide particles, and faster than air exposure in the group inhaling the larger iron oxide particles. The low concentration decreased clearance in the tracheobronchial region and enhanced clearance in the nasopharyngeal region. Slower clearance was also reported in 10 male volunteers exposed to 0.1 mg/m’ sulfuric acid aerosols (MMAD 0.5 pm) for 1 or 2 hours (Spektor et al. 1989). The subjects were exposed to '**gold-tagged iron oxide before the sulfuric acid exposures and **“technetium-tagged iron oxide particles after the exposures. Both labeled particles had a size of about 5.2 ym. Clearance of the particles deposited after the exposure was slower compared to that of particles deposited before the sulfuric acid exposure. After 2 hours of exposure to sulfuric acid aerosols, the clearance half-time tripled compared to air exposure, and reduced clearance was still noted 3 hours after the end of the exposure. After 1 hour of exposure, clearance half-time was doubled compared to air exposure, and the reduced rate of clearance lasted for 2 hours after the exposure. The results of this study suggest a cumulative response of duration of exposure to sulfuric acid aerosols. In addition to experimental exposure studies of humans, the effect of sulfuric acid exposure has been studied after pollution episodes and following occupational exposure. Hospital admissions for respiratory effects in southern Ontario, Canada, were increased on days with high sulfate concentrations (Bates and Sizto 1987). This association was observed in the summer but not the winter. In an asthma episode in Japan in which more than 600 cases of chronic bronchitis, allergic asthma bronchitis, pulmonary emphysema, and sore throat were reported, measurements revealed the presence of acid mist particles and a sulfur trioxide/sulfur dioxide ratio of 0.48, indicative of sulfuric acid mist (Kitagawa 1984). The study authors concluded that the respiratory symptoms were a result of concentrated sulfuric acid mist with an MMD of 0.7-3.3 um. Concentrations of sulfuric acid were ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 49 2. HEALTH EFFECTS estimated to be 0.8-12.8 mg/m’. In a large study of non-smokers in California, the development of asthma symptoms was associated with ambient concentrations of sulfate (Abbey et al. 1993, 1995). Lead-acid battery workers (n=225) were studied for evidence of changes in acute pulmonary function after an 8-hour shift (Gamble et al. 1984a). The average sulfuric acid exposure concentration was 0.18 mg/m’, with a range of 0.08-0.35 mg/m’ (MMAD 5 um). Lung function tests (FVC, FEV, FEV, FEV.) completed before and after the shift provided no evidence of acute pulmonary effects. A slight increase in bronchitis was observed in 460 battery factory workers exposed to sulfuric acid aerosols at an average concentration of 1.4 mg/m’ for up to 40 years (Williams 1970). No effects on FVC or FEV, were observed. A small decrease in FVC was observed in 248 workers exposed to an average sulfuric acid aerosol concentration of 0.21 mg/m’ compared to workers exposed to an average concentration of 0.1 mg/m’ (Gamble et al. 1984b). The FVC was 4.83 L in the high-exposure group, and 5.11 L in the low-exposure group, and the difference was statistically significant (p=0.02). The workers were exposed for an average of 12.2 years. No other significant changes in lung function tests (FEV, peak flow) were noted. Effects on FEV, were not observed in workers exposed to acid aerosols (hydrochloric acid, 2.1 mg/m’; sulfuric acid, 0.5 mg/m’) for a maximum of 4.5 years (n=119-180) (Kremer et al. 1994), or to sulfuric acid aerosols (12.6-35 mg/m’) for from 1 to >15 years (n=20-33) (El-Sadik et al. 1972). For presentation in the Table 2-1 and Figure 2-1 only the low end of the concentration range is shown for the El-Sadik et al. (1972) study. Among the animal species studied, guinea pigs are the most sensitive to exposure sulfuric acid aerosols. During 1-hour nose-only exposures to 52-61 mg/m’ sulfuric acid aerosols in the size range of 0.8-1.2 um (MMAD), guinea pigs developed labored breathing and about 6% of the animals died (total number exposed was not stated) (Stengel et al. 1993). Excised lung gas volume was decreased in guinea pigs killed directly after the exposure but not 24 or 72 hours later. Labored breathing and hyperinflated lungs were reported in guinea pigs (8 male, 8 female) exposed to sulfuric acid aerosols for 8 hours (Wolff et al. 1979). The effects were observed at 17.4 mg/m® for aerosols with an MMAD of 0.8 um, and at 37.2 mg/m’ for aerosols with an MMAD of 0.4 pm. Hemorrhage and transudation of the lungs were also observed following exposure to the large, but not the small, aerosol size. The effect of aerosol size on lung function was studied in guinea pigs (n=5-11) exposed head-only to sulfuric acid while the animals were in a body plethysmograph (Amdur 1958). Control measurements ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 50 2. HEALTH EFFECTS for each guinea pig were completed during the 30 minutes before the 1-hour exposure. In guinea pigs exposed to an aerosol size of 0.8 pm (MMD), resistance increased about 1.5-fold at 1.9 mg/m’, and about 2.2-fold at 42 mg/m’. Exposure to 2.5-pum aerosols resulted in resistance increases of about 1.4-fold at 2.3 mg/m’ and 4.2-fold at 43.6 mg/m’. Increased lung weights and edema were also observed at the high concentration of 2.5-pm aerosols. Resistance was increased about 1.4-fold in guinea pigs exposed to 30.5 mg/m’ sulfuric acid aerosols with an aerosol size of 7 pm. In a comparison of the toxicity of the two smaller aerosol sizes, Amdur (1959) indicated that at higher concentrations the larger aerosols produced a greater response, while at the lower concentrations the smaller aerosols produced the greater response. The time course of the response to the two particle sizes was also different. The response to the smaller aerosol began at once, and after 10-15 minutes of exposure reached the final degree of response present at the end of the hour. Following exposure to the larger aerosol, there was little initial response; the effect occurred during the last 15-20 minutes of the exposure. Amdur (1958, 1959) suggested different mechanisms of response for the different aerosol sizes. The small aerosol (0.8 pm) which would reach the more peripheral regions of the lungs may result in simple bronchoconstriction. The 2.5-pm aerosols would have their major action on the main bronchi and may have resulted in local irritation of the larger air passages causing mucosal swelling, increased secretion, and possibly exudation of fluid leading to complete obstruction of major air passages. The larger aerosols (7 pm) had little effect because they would not be expected to penetrate beyond the upper respiratory tract. In an additional study of the effect of aerosol size on the response to sulfuric acid aerosols, Amdur et al. (1978) exposed 20-25 guinea pigs head-only to sulfuric acid aerosols with MMDs of 0.3 or 1 pm. Pulmonary function measurements completed before and during the 1-hour exposures included pulmonary flow resistance, pulmonary compliance, tidal volume, respiratory frequency, and minute volume. No changes in tidal volume, respiratory frequency, or minute volume were noted. Pulmonary resistance was significantly increased by all exposures, with the smaller particles producing a greater response. For the 0.3-um aerosols, resistance was increased 41%, 60%, and 78% at 0.1, 0.51, and 1 mg/m’, respectively. For the 1-um aerosols, resistance was increased 14%, 30%, 47%, and 60% at 0.11, 0.4, 0.69, and 0.85 mg/m’, respectively. The resistance returned to control levels by the end of the 0.5-hour post-exposure period only at the lowest concentration of 1 pm. Compliance was significantly decreased at all concentrations during exposure to 0.3-um aerosols (-27%, -33%, -40% at 0.1, 0.51, and 1 mg/m’, respectively), and at the two highest concentrations during exposure to 1 pm aerosols (-25% and -28% at 0.69 and 0.85 mg/m’, respectively). “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 51 2. HEALTH EFFECTS No effect on SRaw was observed in 18 guinea pigs exposed to 3.2 mg/m® sulfuric acid aerosols (MMAD 0.5 pm) continuously for 3, 7, 14, or 30 days (Kobayashi and Shinozaki 1993). Transient changes in airway responsiveness to inhaled histamine were observed. After 3 days of exposure, a significant decrease in airway responsiveness was noted. An increase in responsiveness was noted after 14 days of exposure. The response to histamine was normal after 7 and 30 days of exposure. Increased airway responsiveness to acetylcholine was observed in 6-9 guinea pigs exposed head-only to sulfuric acid aerosols (MMD 0.06 pm) at 0.2 mg/m® for 1 hour (Chen et al. 1992b). No effects were observed at 0.03 mg/m’. Increased responsiveness to acetylcholine and histamine in vitro was observed in bronchial rings taken from 5 rabbits exposed nose-only to 0.075 mg/m’ sulfuric acid (MMD 0.3 pm) for 3 hours (El-Fawal and Schlesinger 1994). No effects were observed at 0.05 mg/m’. Bronchoprovocation challenge with intravenous acetylcholine was studied in 4-12 rabbits exposed nose-only to 0 or 0.25 mg/m’ sulfuric acid aerosols (MMD 0.3 pm) 1 hour per day, 5 days per week, for 4, 8, or 12 months (Gearhart and Schlesinger 1986). Sulfuric acid exposure resulted in increased bronchial sensitivity at all exposure durations. The doses of acetylcholine that resulted in an increase in pulmonary resistance 150% of baseline (EDs) in pg/kg/minute were 0, 18.7, 2, 1.5, and 1.2 at 0, 2, 4, 8, and 12 months of exposure, respectively. Values at all time points were significantly different from the controls but not from each other. Exposure to sulfuric acid had no effects on dynamic compliance or respiratory rate. The study authors suggest that the lack of effect on dynamic compliance suggests that the site of increased airway responsiveness induced by sulfuric acid may have been predominantly the larger bronchi. A significant (p=0.01) decrease in carbon monoxide diffusion capacity was observed in 4 beagle dogs exposed to 0.755 mg/m’ sulfuric acid (90% of the particles were <0.5 um in diameter) 21 hours per day for 225 days (Lewis et al. 1969). The diffusion capacity was 6.3 mL/mm Hg/minute in exposed dogs and 7.4 mL/mm Hg/minute in control dogs. Residual volume was 163+11 mL and 182+12 mL in control and exposed dogs, respectively. A statistical test for residual volume was not provided. Clearance of particles has also been studied in animals. Clearance of *'chromium-labeled microspheres (activity median aerodynamic diameter [AMAD] 1.9 um) from the head was not affected in 10 ferrets exposed nose-only to 0.5 or 1 mg/m’ sulfuric acid aerosols (MMAD 0.3 um) for 4 hours (Mannix et al. 1991). Clearance from the lungs was significantly accelerated. The half-time of clearance was “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 52 2. HEALTH EFFECTS 1,126 hours in air-exposed ferrets, 773 hours at 0.5 mg/m’, and 630 hours at 1 mg/m’. Decreased clearance of ¥strontium-labelled latex microspheres (MMAD 3.5 pm) from the respiratory region of the lungs was observed in 3 rabbits exposed to 0.05 mg/m’ sulfuric acid aerosols (MMAD 0.3 pm) 4 hours per day for 14 days (Schlesinger 1990a). Increased alveolar clearance of 3.5-um latex particles was observed in 4 rabbits exposed to sulfuric acid aerosols (MMD 0.3 pm) at 0.25 mg/m’ for 1 hour per day, 5 days per week, for 1, 57, or 240 days (Schlesinger and Gearhart 1986). The mucociliary clearance of *“technetium-labeled ferric oxide particles (MMAD 4.5 um) was studied in groups of 8 rabbits exposed to sulfuric acid aerosols (MMAD 0.3 pm) for 1 hour via an oral delivery tube. A concentration range of 0.1-1.084 mg/m® was studied by Schlesinger et al. (1984), and a concentration range of 0.260-2.155 mg/m’ was studied by Chen and Schlesinger (1983). In these studies each rabbit was exposed multiple times. A series of 10 air-sham exposures was completed before any sulfuric acid aerosol exposures. Tests at each concentration were completed twice for each rabbit, and the order of exposure was randomized. The results of both studies in terms of mean residence times were presented in the Schlesinger et al. (1984) report. The complete data set was subjected to polynomial regression analysis, and the threshold concentration for no effects on clearance was 0.1 mg/m’. At 0.2 mg/m’, clearance was significantly increased, while at 1.5 mg/m’ clearance was significantly decreased. The study authors suggested that the increase in clearance at low concentrations and the decrease at higher concentrations may be a result of differential effects on the upper and lower bronchial tree. At low concentrations, sulfuric acid can stimulate mucus transport in the proximal airways of the bronchial tree where only small amounts of the aerosol are deposited, while it may slow transport in more distal airways. The effect of sulfuric acid exposure on particle clearance has been studied in donkeys and rabbits following intermediate or chronic exposure. For mucociliary clearance, donkeys are considered to closely model humans. A trend toward erratic and slower bronchial clearance of 9mechnetium-tagged ferric oxide particles (MMAD 5 pm) was observed in 4 donkeys exposed nose-only to about 0.1 mg/m® sulfuric acid aerosols (MMAD 0.5 pm) 1 hour per day, 5 days per week, for 6 months (Schlesinger et al. 1979). Each of the donkeys studied served as its own control. The effects on clearance were more prominent in 2 of the donkeys that had been used in a previous study involving 12 1-hour sulfuric acid exposures. There was no evidence for persistence of effects from the earlier study. Effects on clearance of *"technetium-tagged ferric oxide particles (MMAD 4.5 pm) were not observed during the exposure period in 5 rabbits exposed to 0.125 mg/m’ sulfuric acid (MMD 0.3 pum) ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 53 2. HEALTH EFFECTS 2 hours per day, 5 days per week, for 4, 8, or 12 months (Schlesinger et al. 1992a). During a 6- month recovery period, decreased clearance was observed in rabbits exposed for 12 months. The effects of sulfuric acid exposure on tracheal mucus were studied in rats and guinea pigs exposed in a chamber for 4 hours (Lee et al. 1995). Six rats were exposed to a concentration of 94.1 mg/m’ (MMD 0.8 um), and 5 guinea pigs were exposed to a concentration of 43.3 mg/m’ (MMD 0.93 pm). Surface tension of the mucus was not affected by sulfuric acid exposure in either species, but electron microscopy indicated that the mucus layer was five or more times thicker in both species following sulfuric acid exposure, with a greater effect observed in guinea pigs. In water-exposed control guinea pigs the mucus layer was about 1 um, while it was 5-40 pm in acid-exposed guinea pigs. The mucus of both species contained granular material and membrane-bound vesicles. Despite the changes in mucus, the acid aerosol exposure did not affect the ability of the mucus to submerge other particles. Some of the guinea pigs developed pulmonary edema, but further details were not provided. The effect of aerosol size on the levels of total protein, B-glucuronidase, and lactate dehydrogenase in lung lavage fluid has been studied in 6 guinea pigs exposed nose-only for 3 hours to filtered air or to 0.3 mg/m’ sulfuric acid aerosols with an MMD of 0.3 or 0.04 pum (Chen et al. 1992a). The 3-hour exposure to the 0.3-um aerosols resulted in increases in total protein, B-glucuronidase, and lactate dehydrogenase, while only B-glucuronidase was increased after exposure to the 0.04-um aerosol. The increases were observed immediately after the exposure and were not observed 24 hours later. Lung lavage fluid levels of lactate dehydrogenase, prostaglandin E,, and prostaglandin F,, were not affected in 5 rabbits exposed to 0.125 mg/m* sulfuric acid aerosols (MMD 0.3 um) for 3 hours (Schlesinger et al. 1992b). Lactate dehydrogenase in lung lavage fluid was also not affected in 5 rabbits exposed to 0.5 mg/m’ sulfuric acid (MMD 0.3 um) for 2 hours (Zelikoff and Schlesinger 1992). Lactate dehydrogenase and protein were increased in lung lavage fluid 24 hours after 5 rabbits were exposed to 1 mg/m® sulfuric acid aerosols (MMD 0.3 um) 2 hours per day for 4 days (Zelikoff et al. 1994). No significant effects on the protein in the lung lavage fluid or on the lung tissue protein content were observed in 4-36 rats exposed to 1.29 mg/m’ sulfuric acid aerosols (MMAD 0.4 um) for 23.5 hours per day for 3 or 7 days (Warren and Last 1987). The collagen synthesis rate of the lungs was not affected in 12-41 rats exposed to 1.09 mg/m’ sulfuric acid (MMAD 0.4 pm) 23.5 hours per day for 7 days (Warren and Last 1987). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 54 2. HEALTH EFFECTS Arachidonic acid metabolites (prostaglandins E, [PGE,] and F,, [PGF,,], thromboxane B,, and leukotriene B,) were measured in the lung lavage fluid of 5 rabbits exposed to sulfuric acid (MMD 0.3 pm) 1 hour per day for 5 days at 0, 0.25, 0.5, or 1 mg/m’ (Schlesinger et al. 1990b). Sulfuric acid exposure resulted in a reduction in PGE, production that was statistically significant beginning at 0.5 mg/m’, a reduction in PGF,, production that was significant at 1 mg/m’, and reduction in thromboxane B, production that was statistically significant at all exposure concentrations. No change in leukotriene B, production was observed. The significance of the effect of the reduction in these arachidonic acid metabolites that act as vasoconstrictors is not known. In an 8-hour LC, study of groups of 5-12 guinea pigs exposed to 1-um sulfuric acid aerosols in the range of 8-85 mg/m’, effects observed in the lungs of animals that survived for up to 3 weeks after the exposure included spotty areas of old hemorrhage and some areas of consolidation especially around the hilar regions (Amdur et al. 1952a). Adherence of the lungs to the diaphragm and pleural walls was sometimes observed. Microscopically, pneumonic changes, fibrosis, thickening of the alveolar walls, atelectasis, and congestion of the alveolar space and bronchi were observed. The study authors indicated that the changes were consistent with a severe inflammatory process that had subsided. The concentrations at which the effects were observed were not stated. Microscopic lesions of the respiratory tract of the rats, mice, guinea pigs, and rabbits that died in the Treon et al. (1950) study were described as degenerative changes of the epithelium, pulmonary hyperemia and edema, some cases of focal pulmonary hemorrhages, and areas of atelectasis and emphysema. The microscopic changes were not described in relation to exposure concentration. Diffuse regional alveolitis and varying degrees of septal edema were observed in 20 guinea pigs exposed to 10 mg/m’ sulfuric acid aerosols (MMD 0.89 um) for 5, 7, 14, 21, or 28 days (Cavender et al. 1977). Microscopic examination of the lungs did not reveal any effects in 20 rats exposed to 100 mg/m’ sulfuric acid for 5 days (Cavender et al. 1977). The number of hours the guinea pigs and rats were exposed each day was not stated. Edema and hemorrhage were observed in the lungs of 10 male and 10 female guinea pigs exposed to 25 mg/m’ sulfuric acid aerosols (MMD 1 pm) 6 hours per day for 2 days (Cockrell et al. 1978). Transmission electron microscopy showed an increased number of type II alveolar cells and alveolar macrophages in the alveoli, and vacuoles were observed in type I cells. Lesions were not observed in the more proximal segments of the airways including the bronchi, trachea, or larynx. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 55 2. HEALTH EFFECTS Gross and microscopic examination of the nasal turbinates, trachea, and lungs of 35 mice exposed to 20 mg/m’ sulfuric acid aerosols (CMD 2.4 um) 7 hours per day on gestation days 6-15 revealed no evidence of toxicity that could be attributed to the exposure (Murray et al. 1979). Subacute rhinitis and tracheitis were observed in 20 rabbits exposed to 20 mg/m® sulfuric acid (CMD 2.4 um) 7 hours per day on gestation days 6-18 (Murray et al. 1979). The effect of aerosol size on pathological changes in the respiratory tract was studied in groups of 6-19 guinea pigs exposed to sulfuric acid aerosols for 32-139 days (Thomas et al. 1958). Exposure concentrations were 0, 2, or 25 mg/m’ for the 0.5-um aerosols, and 0 or 2-4 mg/m’ for the 0.9- and 4-um aerosols. The guinea pigs, including controls, were sacrificed with chloroform which may also have caused some lung effects. Microscopic examinations of pulmonary tissues were scored on a scale of 0-4, with 4 indicating the most severe effects. The alterations that were scored were atelectasis, emphysema, hyperemia, edema, hemorrhage, thrombosis of the alveolar capillaries, perivenous lymphocytic infiltration, distention of the lymph channels, extent and density of alveolar exudate, and the presence or absence of fibrosis. The medium aerosol size caused more effects in the lungs than the other sizes, while the large aerosol size caused greater effects in the upper respiratory tract. In the lungs, the average histological scores were 0.15, 0.63, and 0.28 for the small, medium, and large aerosols, respectively. In the upper respiratory tract, the average histological scores were 0.1, 0.04, and 0.76 for the small, medium, and large aerosols, respectively. The scores for individual histopathological changes never exceeded 2. In a study using three aerosol sizes, histopathological changes in the respiratory tract were not observed in guinea pigs (50 male, 50 female) exposed to sulfuric acid 23 hours per day, 7 days per week, for 52 weeks (Alarie et al. 1973, 1975). No effects were observed at 0.9 mg/m® at an MMD of 0.49 pm, at 0.08 mg/m’ at an MMD of 0.84 pm, or at 0.1 mg/m* at an MMD of 2.78 pm. In cynomolgus monkeys (groups of 4-5 of each sex) exposed to sulfuric acid aerosols 23.3 hours per day, 7 days per week, for 78 weeks, histopathological changes were reported in the respiratory tract (Alarie et al. 1973). For the smaller aerosol size, moderate-to-severe bronchial epithelial hyperplasia and thickening of the walls of the respiratory bronchioles were observed in all 9 monkeys exposed at 4.79 mg/m’ (MMD 0.73 pm), with no effects at 0.48 mg/m* (MMD 0.54 pm). In the monkeys exposed at 4.79 mg/m’, no change in arterial oxygen was observed. For the larger aerosol size, moderate bronchiolar epithelial hyperplasia, thickening of the walls of the respiratory bronchioles, increases in the thickness of the alveolar walls, and hyperplasia and hypertrophy of the alveolar ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 56 2. HEALTH EFFECTS epithelial cells were observed in all 9 monkeys exposed to 2.45 mg/m* (MMD 3.6 pm). Because these effects were associated with decreased arterial oxygen (from 102 mm Hg before exposure to 70 mm Hg at 77 weeks) and a blood pH of 7.26-7.30, the 2.45-mg/m’ concentration is considered a serious LOAEL. At a concentration of 0.38 mg/m’ (MMD 2.15 um), slight bronchiolar epithelial hyperplasia was observed in 5 of 9 monkeys, and slight thickening of the walls of the respiratory bronchioles was observed in 3 of 9 monkeys. No effects on alveoli or on arterial oxygen were observed at 0.38 mg/m’. Cardiovascular Effects. Heart rate at the time of transition between nasal and oronasal breathing was not affected in 7 exercising healthy human subjects exposed head-only to 0.471 mg/m® sulfuric acid aerosols (MMAD 10 pm) for 1 hour (Bowes et al. 1995). No association between ambient sulfate concentrations and myocardial infarctions was observed among 6,340 nonsmokers in California (Abbey et al. 1995). Histopathological changes in the heart were not observed in 9 cynomolgus monkeys exposed to sulfuric acid aerosols at up to 4.79 mg/m’, 23.3 hours per day, 7 days per week, for 78 weeks (Alarie et al. 1973), or in guinea pigs (groups of 50 of each sex) at concentrations up to 0.9 mg/m’, 23 hours per day, 5 days per week, for 52 weeks (Alarie et al. 1973, 1975). Hematological Effects. No studies were located regarding hematological effects in humans after inhalation exposure to sulfur trioxide or sulfuric acid. Changes in hematocrit, hemoglobin, red blood cell counts, and white blood cell counts were not observed in 9 cynomolgus monkeys exposed to sulfuric acid aerosols at up to 4.79 mg/m’, 23.3 hours per day, 7 days per week, for 78 weeks (Alarie et al. 1973), or in guinea pigs at concentrations up to 0.9 mg/m’, 23 hours per day, 5 days per week, for 52 weeks (Alarie et al. 1973, 1975). Hepatic Effects. No studies were located regarding hepatic effects in humans after inhalation exposure to sulfur trioxide or sulfuric acid. No effects on liver weight were noted in mice or rabbits exposed to 20 mg/m’ sulfuric acid aerosols (CMD 2.4 um) 7 hours per day on gestation days 6-15 for 35 mice and days 6-18 for 20 rabbits (Murray et al. 1979). Microscopic changes in the liver and treatment-related changes in serum levels “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 57 2. HEALTH EFFECTS of liver enzymes were not observed in cynomolgus monkeys exposed to sulfuric acid aerosols at up to 4.79 mg/m’, 23.3 hours per day, 7 days per week, for 78 weeks (Alarie et al. 1973), or in guinea pigs at concentrations up to 0.9 mg/m’, 23 hours per day, 5 days per week, for 52 weeks (Alarie et al. 1973, 1975). Aspartate aminotransferase (AST) and alanine aminotransferase (ALT) were measured in both species; lactic acid dehydrogenase and alkaline phosphatase were also measured in monkeys. The liver enzyme data were not presented in the paper. Renal Effects. No studies were located regarding renal effects in humans after inhalation exposure to sulfur trioxide or sulfuric acid. Treatment-related microscopic changes in the kidneys were not observed in 9 cynomolgus monkeys (Alarie et al. 1973) or in guinea pigs (50 of each sex) (Alarie et al. 1973, 1975) exposed chronically to sulfuric acid aerosols. The monkeys were exposed to sulfuric acid aerosols at up to 4.79 mg/m’ 23.3 hours per day, 7 days per week, for 78 weeks (Alarie et al. 1973). The guinea pigs were exposed at concentrations up to 0.9 mg/m® 23 hours per day, 5 days per week, for 52 weeks (Alarie et al. 1973, 1975). Ocular Effects. Lacrimation was reported in volunteers exposed to sulfuric acid aerosols (MMD 1.54 ym) at 20.8 mg/m’ (Sim and Pattle 1957). The exposures, completed at a relative humidity of 91%, were almost intolerable at the onset. Eye irritation was not reported by subjects exposed to a concentration of 39.4 mg/m* (MMD 0.99 um) at a relative humidity of 63%. This study is of limited value because the subjects were allowed to smoke during the exposures. Eye irritation was reported by asthmatic subjects exposed to sulfuric acid aerosols (MMD 0.9 um) at 0.999 mg/m? for 1 hour (Avol et al. 1988). Eye irritation was not reported at 0.396 mg/m’, nor was it reported by normal subjects exposed at 1.578 mg/m’. No studies were located regarding ocular effects in animals after inhalation exposure to sulfur trioxide or sulfuric acid. Body Weight Effects. No effects on body weight gain were noted in mice or rabbits exposed to 20 mg/m’ sulfuric acid aerosols (CMD 2.4 um) 7 hours per day on gestation days 6-15 for mice and days 6-18 for rabbits (Murray et al. 1979). Effects on body weight were not observed in rabbits exposed to 0.125 mg/m’ sulfuric acid aerosols (MMD 0.3 pm) 2 hours per day, 5 days per week, for ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 58 2. HEALTH EFFECTS 4, 8, or 12 months (Schlesinger et al. 1992a). Chronic exposure to sulfuric acid aerosols also had no effect on body weights of cynomolgus monkeys (Alarie et al. 1973) or guinea pigs (Alarie et al. 1973, 1975). The monkeys were exposed to sulfuric acid aerosols at up to 4.79 mg/m’ 23.3 hours per day, 7 days per week, for 78 weeks (Alarie et al. 1973). The guinea pigs were exposed at concentrations up to 0.9 mg/m’ 23 hours per day, 5 days per week, for 52 weeks (Alarie et al. 1973, 1975). Other Systemic Effects. Studies of workers indicate that exposure to sulfuric acid aerosols can result in lowered pH of the saliva (El-Sadik et al. 1972), erosion of the teeth (El-Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961), and increased prevalence of periodontal pockets (Tuominen 1991). The subjects in the El-Sadik et al. (1972) study were exposed to concentrations of 12.6-35 mg/m’. Only the low end of the concentration range is shown in Table 2-1 and Figure 2-1. The lowest average concentration at which effects on the teeth were noted was 0.21 mg/m’ for 248 workers exposed an average of 12.2 years (Gamble et al. 1984a). Malcolm and Paul (1961) indicated that the front teeth of the 63 exposed workers in their study were the teeth most often affected, suggesting the effect was the result of direct impingement of acid mist on the teeth. No studies were located regarding other systemic effects in animals after inhalation exposure to sulfur trioxide or sulfuric acid. 2.2.1.3 Immunological and Lymphoreticular Effects The function of alveolar macrophages was studied in cells collected by lung lavage 18 hours after 12 volunteers were exposed to 1 mg/m’ sulfuric acid and sodium chloride aerosol (MMAD 0.9 um) for 2 hours each (Frampton et al. 1992). The sulfuric acid and sodium chloride exposures were separated by at least 2 weeks. Sulfuric acid exposure had no effect on cell recovery in the lavage fluid, providing no evidence of an inflammatory response. The ability of alveolar macrophages to lyse antibody-coated red blood cells showed a small increase following sulfuric acid exposure. This effect was not considered to be adverse. The ability of alveolar macrophages to become associated with and inactivate influenza virus was not significantly affected by sulfuric acid exposure. Increased mortality was not observed in 80 mice challenged for 20 minutes with an aerosol of Streptococcus pyrogens directly after head-only exposures to ultrafine (VMD <0.1 pm) sulfuric acid ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 59 2. HEALTH EFFECTS aerosols (Grose et al. 1982). The mice were exposed to sulfuric acid for 2 hours at 0.543 mg/m’ or for 2 hours per day for 5 days at 0.365 mg/m’. Additional animal studies have examined the in vitro function of immune cells collected by lung lavage from animals exposed to sulfuric acid aerosols. Intracellular pH of alveolar macrophages was decreased in guinea pigs 15.6% following a single 3-hour chamber exposure and by 23.5% after five 3-hour exposures to 0.97 mg/m’ sulfuric acid (MMD 0.3 pm) (Qu et al. 1993). Decreased intracellular pH of alveolar macrophages was also observed in macrophages from rabbits exposed nose-only to 0.125 mg/m’ sulfuric acid aerosols (MMD 0.3 pum) for 3 hours (Chen et al. 1995). No effect was observed at 0.05 mg/m’. A single 3-hour exposure of guinea pigs to 0.3 mg/m’ sulfuric acid aerosol with an MMD of 0.3 um enhanced the phagocytic activity of alveolar macrophages 24 hours after exposure (Chen et al. 1992a). A single 3-hour exposure to 0.3 mg/m’ sulfuric acid aerosol with an MMD of 0.04 pm depressed the ability of alveolar macrophages to phagocytize particles. The study authors suggested that, compared to larger droplets, smaller droplets deliver a higher dose to the alveolar macrophages. Endotoxin- stimulated production of tumor necrosis factor (TNF) was significantly increased by four daily 3-hour exposures to 0.3 mg/m’ sulfuric acid at MMDs of both 0.04 and 0.3 pm (Chen et al. 1992a). A series of studies has been completed in which macrophage function in rabbits has been studied following exposure to sulfuric acid aerosols with an MMD of 0.3 um (Schlesinger 1987; Schlesinger et al. 1990a, 1992b; Zelikoff and Schlesinger 1992; Zelikoff et al. 1994). A 2-hour exposure to 0, 0.05, 0.075, 0.125, or 0.5 mg/m’ sulfuric acid aerosols had no effect on the number of cells recovered in lavage fluid, the percentage of polymorphonuclear cells, or macrophage viability (Zelikoff and Schlesinger 1992). At the three highest concentrations, sulfuric acid exposure significantly reduced TNF cytotoxic activity by macrophages and reduced zymosan-stimulated production of superoxide anion. The effects at the three highest concentrations were not significantly different from each other. Following a 3-hour exposure to 0.075 mg/m’, decreased phagocytic activity, production of superoxide anion, and TNF activity were observed, with no effects at 0.05 mg/m’ (Schlesinger et al. 1992b). Macrophage-mediated immunity was suppressed following 4 daily 2-hour exposures to 0.75 mg/m? (Zelikoff et al. 1994), 5 daily 1-hour exposures to 1 mg/m’ (Schlesinger et al. 1990a), and 13 daily 2-hour exposures to 0.5 mg/m’ (Schlesinger 1987). Based on the results of their studies of macrophage function, Zelikoff et al. (1994) concluded that there was an absence of a ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 60 2. HEALTH EFFECTS concentration—response relationship. Once a critical level of acid was reached, no further effects were observed. The release of histamine from antigen- or A23187-induced mast cells was studied in cells collected from guinea pigs exposed continuously to 0, 0.3, 1, or 3.2 mg/m’ sulfuric acid aerosols with MMDs in the range of 0.55-0.73 um for 2 or 4 weeks (Fujimaki et al. 1992). Sulfuric acid exposure did not have any effects on the number of mast cells in the lavage fluid. Antigen-induced histamine release from mast cells was significantly enhanced at 1 and 3.2 mg/m’ following 2 weeks of exposure, but not after 4 weeks of exposure. A23187-induced histamine release was enhanced at 1 mg/m’ following 2 weeks of exposure but was suppressed at 3.2 mg/m’ following 4 weeks of exposure. No effects on mast cell function were noted at 0.3 mg/m’. The highest NOAEL values and all LOAEL values from each reliable study for immunological and lymphoreticular effects in each species and duration category are recorded in Table 2-1 and plotted in Figure 2-1. 2.2.1.4 Neurological Effects Lightheadedness and dizziness were reported by 3 of 12 persons accidentally exposed to sulfur trioxide for approximately 2 hours (Stueven et al. 1993). The exposure concentrations were not stated. Fatigue and headaches were reported more frequently in 21 asthmatic volunteers exposed to sulfuric acid aerosols at 0.999 mg/m’ (MMD 0.9 um) for 1 hour (Avol et al. 1988). These subjective symptoms were not reported at 0.396 mg/m’, nor were they reported by 21 normal volunteers exposed to sulfuric acid aerosol concentrations as high as 1.578 mg/m’. No studies were located regarding neurological effects in animals after inhalation exposure to sulfur trioxide or sulfuric acid. The NOAELSs and LOAEL for neurological effects in humans identified in the Avol et al. (1988) study are recorded in Table 2-1 and plotted in Figure 2-1. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 61 2. HEALTH EFFECTS 2.2.1.5 Reproductive Effects No studies were located regarding reproductive effects in humans after inhalation exposure to sulfur trioxide or sulfuric acid. No significant effects on the mean numbers of implants/dam or resorptions/litter were noted in 35 mice or 20 rabbits exposed to 20 mg/m’ sulfuric acid aerosols (CMD 2.4 um) 7 hours per day on gestation days 6-15 for mice and 6-18 for rabbits (Murray et al. 1979). The NOAEL values for mice and rabbits for reproductive effects are recorded in Table 2-1 and plotted in Figure 2-1. 2.2.1.6 Developmental Effects No studies were located regarding developmental effects in humans after inhalation exposure to sulfur trioxide or sulfuric acid. No significant effects on fetal body weights or on the incidence of major or minor malformations were noted in the offspring of 35 mice or 20 rabbits exposed to 20 mg/m’ sulfuric acid aerosols (CMD 2.4 um) 7 hours per day on gestation days 6-15 for mice and 6-18 for rabbits (Murray et al. 1979). The NOAEL values for mice and rabbits for developmental effects are recorded in Table 2-1 and plotted in Figure 2-1. 2.2.1.7 Genotoxic Effects No studies were located regarding genotoxic effects in humans or animals after inhalation exposure to sulfur trioxide or sulfuric acid. Genotoxicity studies are discussed in Section 2.5. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 62 2. HEALTH EFFECTS 2.2.1.8 Cancer In a study regarding the effect of air pollutants in nonsmokers, sulfates were not shown to be associated with cancer (Abbey et al. 1995). Increases in respiratory tract cancers were not observed among a cohort of 400 male workers at a sulfuric acid plant in Sweden (Englander et al. 1988). The men were exposed to sulfuric acid aerosols at concentrations of <0.1-2.9 mg/m’ for at least 6 months. There was a significant (p=0.006) increase in bladder cancer in this population. The study authors suggested that bladder cancer in this population may not be a result of sulfuric acid aerosol exposure but may have been a result of chance or smoking or other factors such as diet. A case of laryngeal cancer was reported in a man (life-long nonsmoker) exposed to sulfuric acid from poorly maintained batteries used to operate an electric fork lift truck (Houghton and White 1994). The man operated a fork lift truck for 11 years. Exposure concentrations were not stated, but the man described the surface of the batteries as always being wet with sulfuric acid and he often suffered burns on his legs and clothing damage. Employment history did not reveal exposure to any other industrial carcinogens. Three cases of laryngeal cancer were reported among 78 workers at a factory that pickled stainless steel pipes (Ahlborg et al. 1981). Based on cancer registry data, 0.05 laryngeal cancer cases would have been expected in this population. All three persons with laryngeal cancer were moderate smokers. Exposures included sulfuric acid, nitric acid, oxalic acid, ammonium bifluoride, soap, sodium thiosulfate, sodium hydrosulfite, hydrogen fluoride, and low levels of chromium, nickel, and asbestos. Occupational studies of isopropyl alcohol production workers (Alderson and Rattan 1980), soap production workers (Forastiere et al. 1987), and refinery and chemical plant workers (Soskolne et al. 1984, 1992) have reported small increases of upper respiratory tract cancers (nasal, laryngeal) and lung cancers in workers exposed to sulfuric acid aerosols. Exposure concentrations were not well characterized in these studies. In a study of workers from two battery manufacturers and two steel works in Britain, a small increase in upper respiratory tract cancers (lip, retromolar area, tongue, nasopharynx, tonsil, larynx, gum, nasal sinus) was observed (Coggon et al. 1996). The study authors indicated that a small increase in risk occurred at 1 mg/m’, but not at lower concentrations. Although this study provides limited evidence that the risk of upper aerodigestive cancer is increased, the risk estimate was based on a small number of cases, and the excess was not significant. The study does ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 63 2. HEALTH EFFECTS not provide any information on alcohol or tobacco use. There is also no information about exposure before 1970. In a study of male steel workers exposed to acid mists during pickling operations at an average concentration of 0.2 mg/m? for an average of 9.5 years, a statistically significant increase in laryngeal cancer was observed (Steenland et al. 1988). Nine of 879 workers were diagnosed with laryngeal cancer, while after adjusting for smoking, 3.44 cases of laryngeal cancer were expected. All cases were either current or former smokers. Quantitative individual sulfuric acid exposure data were not provided. The study authors indicated that the pickling process did not generate appreciable levels of metal particulates. This population has also been studied for lung cancer (Beaumont et al. 1987; Steenland and Beaumont 1989). A total of 41 lung cancers in a cohort of 1,165 steelworkers were identified (Steenland and Beaumont 1989). The standardized mortality ratio (SMR) for lung cancer after adjusting for smoking for those with 20 years or more since first exposure was 1.5, with a 95% confidence interval of 1.05-2.27 (Steenland and Beaumont 1989). No studies were located regarding cancer in animals after inhalation exposure to sulfur trioxide or sulfuric acid. 2.2.2 Oral Exposure No studies in humans or animals were located regarding oral exposure to sulfur trioxide. 2.2.2.1 Death Mineral acids, including sulfuric acid, are commonly used as cleaning agents in India. In a report of 10 human cases of sulfuric acid ingestion from January 1978 to December 1980, 2 died (Dilawari et al. 1984). One person died of gastric perforation, and the second person died of bronchopneumonia. Although the concentration of sulfuric acid ingested by these subjects was not stated, the concentration of sulfuric acid available in India is in the range of 26.4-35.4 Normal (N). The LD, in rats treated by gavage with reagent grade sulfuric acid in water at a concentration of 0.25 g/mL was reported as 2,140 mg/kg (Smyth et al. 1969). No deaths were reported in chicks fed sulfuric acid in the diet at 11,117 mg/kg/day for 14 days (Capdevielle and Scanes 1995b), or mallard “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 64 2. HEALTH EFFECTS ducklings fed sulfuric acid in the diet at 12,393 mg/kg/day for 15 days (Capdevielle and Scanes 1995a). These studies indicate that a much larger dose of sulfuric acid can be tolerated if it is given in the food compared to gavage treatment. When sulfuric acid is added to food, some will be neutralized. The LDy, for rats is recorded in Table 2-2 and plotted in Figure 2-2. 2.2.2.2 Systemic Effects No studies were located regarding cardiovascular, hematological, dermal, or ocular effects in humans or animals after oral exposure to sulfuric acid. Respiratory Effects. In a report of 10 humans that ingested sulfuric acid, 2 died (Dilawari et al. 1984). One person died of bronchopneumonia. The amount of sulfuric acid ingested by this subject was not provided. No studies were located regarding respiratory effects in animals after oral exposure to sulfuric acid. Gastrointestinal Effects. A 2-year-old boy that ingested an unspecified amount of sulfuric acid required surgery to replace his stomach with a jejunal pouch (Aktug et al. 1995). In a report from India regarding 10 humans that ingested sulfuric acid, 2 died (Dilawari et al. 1984). The cause of death was gastric perforation in 1 person. Endoscopy was completed in all 10 subjects and the gastrointestinal lesions were graded as follows: I, mild mucosal hyperaemia; II, moderate superficial ulcerations; and III, severe, extensive, deep ulcerations. Among the survivors, there were 4 cases each with esophageal lesions of grade II and grade III. Stomach lesions of grade III were observed in 6 survivors, and grade II in 2 survivors. Grade III lesions were observed only in the duodenum of the 2 subjects that died. Duodenal lesions were grade I in 3 survivors, with no duodenal lesions observed in the other 5 survivors. The amount and concentration of the acid consumed by the individuals were not known, but the study authors estimated that the amount was in the range of 15-50 mL, and the concentration was up to 26.4-35.4 N, the concentration of acid readily available in India. No studies were located regarding gastrointestinal effects in animals after oral exposure to sulfuric acid. "**DRAFT FOR PUBLIC COMMENT*** ++LNFJWWOD O178Nd HOH 14VHO.us Table 2-2. Levels of Significant Exposure to Sulfuric Acid - Oral Exposure/ LOAEL a duration/ Keyto species frequency NOAEL Less serious Serious figure (Strain) (Specific route) System (mg/kg/day) (mg/kg/day) (mg/kg/day) Reference ACUTE EXPOSURE Death 1 Rat once 2140 (LD) Smyth et al. 1969 (NS) (GW) *The numbers correspond to entries in Figure 2-2. (GW) = gavage water; LD, = lethal dose 50% kill; LOAEL = lowest-observed-adverse-effect level; NOAEL = no-observed-adverse-effect level; (NS) = not specified S103443 H1TV3H ¢ aiov 21dN4INS ANY 3aiXold.L ’iN4dINs <9 +» LNJWWOD O1N8Nd HOS 14VHA... (mg/kg/day) 100000 10000 t 1000 100 | 10 0.1 0.01 t Figure 2-2. Levels of Significant Exposure to Sulfuric Acid - Oral Acute (<14 days) Dea, Key r rat =n LD, (animals) The number next to each point corresponds to entries in Table 2-2. S103443 H1IvaH 2 aidv 2ldN4INS ANY 3AIXOIYL HN4INS 99 SULFUR TRIOXIDE AND SULFURIC ACID 67 2. HEALTH EFFECTS Musculoskeletal Effects. No studies were located regarding musculoskeletal effects in humans after oral exposure to sulfuric acid. As an indication of growth, tibia length was measured in chicks (Capdevielle and Scanes 1995b) and mallard ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. Decreased tibia length, | associated with an 18% decrease in food intake, was observed in chicks fed 11,117 mg/kg/day for 14 days, with no effects at 2,338 mg/kg/day (Capdevielle and Scanes 1995b). No effect on tibia length or food intake was observed in mallard ducklings fed sulfuric acid at 12,393 mg/kg/day for 15 days (Capdevielle and Scanes 1995a). The study authors suggested that the difference between chickens and ducks may be a result of the eating habits of ducks. Ducks generally drink water after they take some food, which may have diluted the acid minimizing the effects on ducks. Hepatic Effects. No studies were located regarding hepatic effects in humans after oral exposure to sulfuric acid. No changes in liver weight were observed in chicks fed 11,117 mg/kg/day of sulfuric acid in the diet for 14 days (Capdevielle and Scanes 1995b) or in mallard ducklings fed 12,393 mg/kg/day sulfuric acid in the diet for 15 days (Capdevielle and Scanes 1995a). Renal Effects. No studies were located regarding renal effects in humans after oral exposure to sulfuric acid. No changes in kidney weights were observed in chicks fed 11,117 mg/kg/day of sulfuric acid in the diet for 14 days (Capdevielle and Scanes 1995b) or in mallard ducklings fed 12,393 mg/kg/day of sulfuric acid in the diet for 15 days (Capdevielle and Scanes 1995a). Endocrine Effects. No studies were located regarding endocrine effects in humans after oral exposure to sulfuric acid. No changes in plasma growth hormone, insulin-like growth factor, and insulin-like growth factor binding proteins were observed in chicks fed 11,117 mg/kg/day of sulfuric acid in the diet for 14 days (Capdevielle and Scanes 1995b) or in mallard ducklings fed 12,393 mg/kg/day of sulfuric acid in the ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 68 2. HEALTH EFFECTS diet for 15 days (Capdevielle and Scanes 1995a). The lack of an endocrine effect suggests that the decreases in growth observed in chicks were a result of the decreased food intake. Body Weight Effects. Decreased body weight gain associated with an 18% decrease in food intake was observed in chicks fed 11,117 mg/kg/day sulfuric acid in the diet for 14 days, with no effects at 2,338 mg/kg/day (Capdevielle and Scanes 1995b). No effect on body weight gain or food intake was observed in mallard ducklings fed sulfuric acid in the diet at 12,393 mg/kg/day for 15 days (Capdevielle and Scanes 1995a). The study authors suggest that the difference between chickens and ducks may be a result of different eating habits of ducks. Ducks generally drink water after they take some food, which may have diluted the acid minimizing the effects on the ducks. 2.2.2.3 Immunological and Lymphoreticular Effects No studies were located regarding immunological and lymphoreticular effects in humans or animals following oral exposure to sulfuric acid. 2.2.2.4 Neurological Effects No studies were located regarding neurological effects in humans or animals following oral exposure to sulfuric acid. 2.2.2.5 Reproductive Effects No studies were located regarding reproductive effects in humans after oral exposure to sulfuric acid. Changes in testes weights were not observed in chicks fed 11,117 mg/kg/day of sulfuric acid in the diet for 14 days (Capdevielle and Scanes 1995b) or in mallard ducklings fed 12,393 mg/kg/day of sulfuric acid in the diet for 15 days (Capdevielle and Scanes 1995a). 2.2.2.6 Developmental Effects No studies were located regarding developmental effects in humans after oral exposure to sulfuric acid. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 69 2. HEALTH EFFECTS As indicated under musculoskeletal effects and body weight effects, decreased growth (decreased tibia length and decreased body weight gain) associated with an 18% decrease in food intake was observed in chicks fed 11,117 mg/kg/day sulfuric acid in the diet for 14 days, with no effects at 2,338 mg/kg/day (Capdevielle and Scanes 1995b). This effect on growth was not accompanied by changes in plasma growth hormone, insulin-like growth factor, or insulin-like growth factor binding protein. No effect on growth or food intake was observed in mallard ducklings fed sulfuric acid in the diet at 12,393 mg/kg/day for 15 days (Capdevielle and Scanes 1995a). The study authors suggest that the difference between chickens and ducks may be a result of different eating habits of ducks. Ducks generally drink water after they take some food, which may have diluted the acid minimizing the effects on the ducks. 2.2.2.7 Genotoxic Effects No studies were located regarding genotoxic effects in humans or animals after oral exposure to sulfuric acid. Genotoxicity studies are discussed in Section 2.5. 2.2.2.8 Cancer No studies were located regarding cancer in humans or animals after oral exposure to sulfuric acid. 2.2.3 Dermal Exposure No studies in humans or animals were located regarding dermal exposure to sulfur trioxide. 2.2.3.1 Death Death can occur from dermal burns from chemicals including sulfuric acid. In a report of burns from chemicals that included sulfuric acid that occurred in Jamaica as a result of assault, Branday et al. (1996) indicated that deaths occurred in people whose chemical burn injuries exceeded 50% of the total body surface area. The death of a man 5 days after he was deliberately splashed with a solution containing concentrated sulfuric acid (concentration not reported) was attributed to extensive burns and ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 70 2. HEALTH EFFECTS chemical damage to the respiratory tract (Schultz et al. 1968). The man was splashed over his face and body, and he received second-degree burns over 60% of his body and third-degree burns over 20% of his body. No studies were located regarding deaths in animals after dermal exposure to sulfuric acid. 2.2.3.2 Systemic Effects The highest NOAEL and all LOAEL values from each reliable study for systemic effects in each species and duration category are recorded in Table 2-3. No studies were located regarding respiratory, cardiovascular, gastrointestinal, hematological, musculoskeletal, hepatic, renal, or body weight effects in humans or animals after dermal exposure to sulfuric acid. Dermal Effects. Direct application of concentrated sulfuric acid to the skin resulted in chemical burns in exposed humans (Branday et al. 1996; Schultz et al. 1968). The effects reported included coagulative necrosis and third-degree burns (Schultz et al. 1968). The concentration required to result in dermal burns in humans has not been determined. Dermal exposure of humans for 4 hours to a 10% sulfuric acid solution was considered non-irritating (Nixon et al. 1975). The sulfuric acid was applied to both intact and abraded skin on a 4-cm area on the back of each person. The sites were evaluated for erythema and edema on a scale of 0-4 at 4, 24, and 48 hours after the application. Additional details about the methods were not provided by the study authors, although they indicate that the test was completed by a procedure proposed by the FDA in 1972. The mean score for humans was 0.2 for both intact and abraded skin. Sulfuric acid placed directly on the skin is corrosive. Available animal studies do not agree on the concentration required to produce direct skin effects. Erosion of the skin at 10%, erythema and edema at 5%, and no effects at 2.5% were reported in rats and mice in which 1 mL/kg of the acid was placed on the electric razor—shaved skin of the back (Sekizawa et al. 1994). The application area was left unoccluded, and the animals wore collars and were caged separately to prevent licking. The skin was examined for 1 week after the application. In comparison to the Sekizawa et al. (1994) study, no skin effects were observed in guinea pigs or rabbits in which a 10% sulfuric acid solution was applied to ***DRAFT FOR PUBLIC COMMENT*** »+LNIWWOD O1719Nd HOL 14vHd... Table 2-3. Levels of Significant Exposure to Sulfuric Acid - Dermal’ Exposure/ FOALL Species Duration/ Less serious p ; Frequency System NOAEL ou Serious Reference (Strain) y (percent) (percent) (percent) ACUTE EXPOSURE Systemic Human-a 1 hr Ocular 0.396 0.999 (eye irritation) Avol et al. 1988 (WB) mg/m’ mg/m® MMD 0.9 Human 4 hr Dermal 10 Nixon et al. 1975 Rat once Dermal 2.5M 5M (erythema, edema) 10 M (erosion of skin) Sekizawa et al. (Wistar) 1994 Rat once Ocular 1-1.25M 2.5M (iris swelling, cornea Sekizawa et al. (Wistar) diffuse) 1994 Mouse once Dermal 2.5M 5M (erythema, edema) 10 M (erosion of skin) Sekizawa et al. (ddY) 1994 Mouse once Ocular 1-1.25M 2.5M (iris swelling, cornea Sekizawa et al. (dd) diffuse) 1994 Gn Pig 4 hr Dermal 10 Nixon et al. 1975 (Hartley) Rabbit once Ocular 10 Jacobs 1992 (New Zealand) S103443 H1IV3H 2 aiov O1dN47NS ANY 3AIX0IdL HN4INS LL ++LNIWWNOO O178Nd HOS L4VHd... Table 2-3. Levels of Significant Exposure to Sulfuric Acid - Dermal (continued) LOAEL Exposure/ Species ~~ duration/ NOAEL Less serious Serious (Strain) frequency System (percent) (percent) (percent) Reference Rabbit once Ocular 5 (minimal corneal opacities 10 (severe corneal opacities in Murphy et al. (New in 3/12) 12/12) 1982 Zealand) Rabbit 4 hr Dermal 10 Nixon et al. 1975 (NS) *Units are percent sulfuric acid except where indicated otherwise. *mg/m’ in air hr = hour; Human-a = asthmatic; LOAEL = lowest-observed-adverse-effect level; M = male; NOAEL = no-observed-adverse-effect level; NS = not specified; (WB) =whole-body S103443 HLTV3H ¢ aloy 01dN47INS ANV 3aIXoldL "in4dns cL SULFUR TRIOXIDE AND SULFURIC ACID 73 2. HEALTH EFFECTS the skin for 4 hours (Nixon et al. 1975). The sites were evaluated for erythema and edema on a scale of 0-4 at 4, 24, and 48 hours after the application. Additional details about the methods were not provided by the study authors, although they indicate that the test was completed by a procedure proposed by the FDA in 1972. The mean score was 0 for both intact and abraded skin in guinea pigs and for intact skin in rabbits. The mean score was 0.1 for abraded skin in rabbits. During a 4-hour exposure, sulfuric acid was not corrosive to the skin when 0.5 mL of a 4% solution was placed on the backs of rabbits, clipped of hair 24 hours before exposure (Vernot et al. 1977). Ocular Effects. Accidental contact of the eyes with concentrated sulfuric acid is very destructive and results in devastating injuries including dissolution of the anterior segment of the globe (Grant 1974). Additional complications that have been reported include glaucoma and cataracts. Ocular damage that was limited to external structures (reported as edematous corneas with necrotic epithelium of the cornea, conjunctival, and lids) was reported in a man deliberately splashed with a solution containing concentrated sulfuric acid (Schultz et al. 1968). With the exception of light detection, the man lost vision the day after the exposure. During the next several days his vision improved. The man died from extensive burns and chemical damage to the respiratory tract 5 days after the exposure. Eye damage as a result of contact with sulfuric acid from car batteries has been reported (Holekamp and Becker 1977). Among 93 cases of eye injuries, 9 cases were serious requiring hospitalization or resulting in permanent damage. In this series of cases, the most common injuries were conjunctival and corneal chemical burns, and iritis. Two-thirds of the injuries occurred when a battery exploded. As indicated in the section regarding inhalation exposure, contact with sulfuric acid aerosols in air results in ocular irritation. Lacrimation was reported in volunteers exposed to sulfuric acid aerosols (MMD 1.54 pm) at 20.8 mg/m® (Sim and Pattle 1957). The exposures, completed at a relative humidity of 91%, were almost intolerable at the onset. Eye irritation was not reported by subjects exposed to a concentration of 39.4 mg/m* (MMD 0.99 um) at a relative humidity of 63%. Because the subjects may have smoked during the exposures, this study is not presented in Table 2-3. Eye irritation was reported by asthmatic volunteers exposed to 0.999 mg/m’ sulfuric acid (MMD 0.9 pm) for 1 hour (Avol et al. 1988). Eye irritation was not reported at 0.396 mg/m’, nor was it reported by normal subjects exposed at 1.578 mg/m’. Sulfuric acid placed directly in the eyes is corrosive. Available animal studies do not agree on the concentration of sulfuric acid required to produce direct eye effects. A 10% (0.1 mL) sulfuric acid ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 74 2. HEALTH EFFECTS solution was considered non-irritating to the eyes when examined in a Draize test in rabbits (Jacobs 1992). Swelling of the iris and "diffuse cornea" were observed in both rats and mice in which 0.01 mL of a 2.5% sulfuric acid solution was placed in one eye (Sekizawa et al. 1994). The other eye was treated with saline as a control. After treatment, the eyes were kept open for 30 seconds. No effects were observed at concentrations of 1-1.25%. In a study in rabbits, 0.1 mL of a 5% (0.51 M; pH 0.6) or 10% (1.02 M; pH 0.1) sulfuric acid solution was placed directly on the cornea of the right eye (Murphy et al. 1982). The left eye served as a control. Directly after treatment, the lid was closed for about 1 second, then released. In six of the exposed rabbits at each concentration, the eyes were gently washed for 2 minutes with 300 mL of tap water 30 seconds after exposure. The eyes of another 6 rabbits at each concentration were not washed. Washing had no effect at 10%, a concentration at which severe corneal opacities were observed in 12 of 12 animals. At 5%, minimal corneal opacities were observed in 1 of 6 washed eyes and 2 of 6 unwashed eyes. The effect at 5% was considered minimal and was no longer present 7 days after the exposure. Although washing did not affect the severity of the effect, it did tend to result in an earlier effect following exposure to 5% sulfuric acid. Because the composition of acid is more completely described in the Murphy et al. (1982) study, it is presented in Table 2-3. No studies were located regarding the following health effects in humans or animals after dermal exposure to sulfuric acid. 2.2.3.3 Immunological and Lymphoreticular Effects 2.2.3.4 Neurological Effects 2.2.3.5 Reproductive Effects 2.2.3.6 Developmental Effects 2.2.3.7 Genotoxic Effects Genotoxicity studies are discussed in Section 2.5. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 75 2. HEALTH EFFECTS 2.2.3.8 Cancer No studies were located regarding cancer in humans or animals after dermal exposure to sulfuric acid. 2.3 TOXICOKINETICS Toxicokinetic studies regarding sulfur trioxide were not identified. Because sulfur trioxide reacts with water to form sulfuric acid, the toxicokinetics of sulfur trioxide would be expected to be the same as sulfuric acid. Sulfuric acid is a direct irritant that results in adverse effects at the site of contact. The effects of sulfuric acid are a result of pH change rather than a result of sulfate. The important toxicokinetic issue is where in the respiratory tract sulfuric acid aerosols will deposit. Factors that help determine the site of deposition in the respiratory tract include environmental conditions, especially relative humidity which affects aerosol size, and physiological factors of the subject including breathing rate, depth of breathing, and method of breathing, e.g., mouth, nose, or oronasal. The effect of hygroscopic growth on deposition within the respiratory tract has been modeled in adults (Martonen and Patel 1981) and children (Martonen and Zhang 1993). Once in the lung, the sulfur from sulfuric acid has been shown to be rapidly absorbed into the blood stream (Dahl et al. 1983). Sulfate is a metabolite of sulfur amino acids, and excess sulfate is excreted in the urine (Vander et al. 1975). 2.3.1 Absorption 2.3.1.1 Inhalation Exposure The retention of sulfuric acid mist was studied in humans exposed through a face mask to 0.4-1 mg/m’ sulfuric acid mist with an average aerosol size of 1 um (Amdur et al. 1952b). During the 5-15-minute exposures, the average retention of the acid aerosols was 77%, with a range of 50-87%. The clearance of *sulfur-labeled sulfuric acid aerosols from the respiratory tract was studied in rats, guinea pigs, and dogs exposed nose-only to 1-20 mg/m’ (MMAD 0.4-1.2 pm) for 30 seconds, and in rats and guinea pigs following intranasal installation (Dahl et al. 1983). The results indicated that the “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 76 2. HEALTH EFFECTS sulfur from sulfuric acid is rapidly cleared from the lungs into the blood following inhalation exposure. The lung clearance half-times were 170, 230, and 261 seconds in rats, guinea pigs, and dogs, respectively. Very little of the sulfur from the sulfuric acid placed in the nose was absorbed into the rest of the body. Five minutes after treatment, 97.1% and 96.8% of the dose remained in the nose of rats and guinea pigs, respectively. To further study absorption of sulfuric acid by the respiratory tract of dogs, ¥sulfur-labeled sulfuric acid was instilled in one dog 1-2 cm past the nares, in a second generation bronchus of another dog, and in a seventh generation bronchus of a third dog. Clearance from the nasal region was insignificant. Clearance half-time from the second generation bronchus was 200 seconds, and from the seventh generation bronchus 110 seconds. 2.3.1.2 Oral Exposure No studies were identified regarding the absorption of sulfuric acid following oral exposure of humans or animals. 2.3.1.3 Dermal Exposure No studies were identified regarding the absorption of sulfuric acid following dermal exposure of humans or animals. 2.3.2 Distribution Sulfate is a normal constituent of the blood, with concentrations of 0.8-1.2 mg/dL normally found in the serum of humans (Hensyl 1990). Studies in which sulfate in blood or urine were measured following exposure to sulfuric acid were not identified. 2.3.2.1 Inhalation Exposure The dose of hydrogen ion delivered to the lungs was estimated in 7 healthy male adults exposed to 0.471 mg/m’ sulfuric acid aerosols (MMAD 10 pm) using a head dome that allowed continuous measurement of breathing frequency, tidal volume, and minute ventilation, as well as the onset and persistence of oronasal breathing (Bowes et al. 1995). The 1-hour exposure period consisted of 40 minutes of rest followed by 20 minutes of moderately heavy exercise on a bicycle ergometer. The ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 77 2. HEALTH EFFECTS amount of hydrogen ion delivered to the lungs was estimated from the total time in minutes of oronasal breathing, the ventilation rate during oral nasal breathing, the hydrogen ion concentration, and the estimated fraction of inhaled air that entered the oral passage during oronasal breathing. Based on an earlier study by this group regarding the lung distribution of 10-um fog droplets following oronasal breathing, the fractional deposition was assumed to be 85.4% for the oropharynx and 14.6% for the lower airways. The investigators estimated that about 55% of each breath was inhaled orally during oronasal breathing. The estimated amount of hydrogen ion inhaled orally was 6,466+1,778 nmol, with 9424259 nmol penetrating to the lower airways including the larynx, trachea, and bronchopulmonary region. Of the parameters used to estimate the dose delivered to the lung, the investigators estimated that the combined physiologic parameters accounted for 70% of the variability (minute ventilation during oronasal breathing, 36%; time in minutes of oronasal breathing, 34%), and the environmental hydrogen ion concentrations accounted for 30% of the variation. Dosimetric models that examine the effect of hygroscopic growth within the human respiratory tract on the deposition of sulfuric acid aerosols have been developed. Martonen and Patel (1981) modeled sulfuric acid aerosol deposition in the adult, while Martonen and Zhang (1993) modeled deposition in both children and adults at different breathing rates. Both models use the Weibel model A of the human lung which assumes a symmetric dichotomously branching network of airways. In the Martonen and Patel (1981) model, it was assumed that the sulfuric acid droplets reached equilibrium size and density at the entrance to the trachea. Relative humidity in the respiratory tract was assumed to be 100%. Compared to smaller particles, larger particles were predicted to grow more as they traversed the respiratory tract. For particles with initial geometric diameters of 0.01, 0.1, and 1 pm the estimated equilibrium geometric diameters in the respiratory tract were 0.022, 0.72, and 16 um, respectively. At an inspiratory flow rate of 30 L/minute, the model indicated that total tracheobronchial deposition would be increased for particles with an initial geometric diameter of >0.1 pm. The increase would result because of increased efficiency of inertial impaction and sedimentation mechanisms. For particles with an initial geometric diameter of <0.1 um the model predicted that tracheobronchial deposition would decrease because of reduced efficiency of diffusion with increased particle size. In the Martonen and Zhang (1993) model, growth of a sulfuric acid droplet was assumed to occur in the first 11 generations of the tracheobronchial tree, with relative humidities increasing from 90% in ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 78 2. HEALTH EFFECTS generation 0, to 99.5% in generation 10. Five subject ages (7, 22, 48, 98, and 240 months) were con- sidered, and the respiratory parameters used for each age are shown in Table 2-4. The model focused on mouth breathing, and sulfuric acid deposition was compared to the deposition of nonhygroscopic iron oxide particles. Total deposition in the respiratory tract was greatest for 7-, 22-, and 48-month- old children, and decreased monotomically as the lungs matured. Deposition was also dependent on particle size. When breathing at rest, for particles with an initial geometric diameter of 0.3 pm, hygroscopicity decreased deposition, while for larger particles hygroscopicity increased deposition. For initial particle sizes of 1-2.5 pm, hygroscopicity almost doubled the probability of deposition in the lung. Increased breathing rate through exertion increased the differences in total deposition between children and adults. The effects of hygroscopicity and age on the regional deposition of particles were also studied (Martonen and Zhang 1993). At resting respiration rates, deposition of iron oxide particles in the alveolated compartment of the lung peaked at a particle size of 3-5 pm (Martonen and Zhang 1993). While for hygroscopic particles, deposition in the alveolar compartment of the lung peaked at an initial particle size of 1-1.5 um. Deposition in the alveolar compartment did not change monotomically with age; deposition was highest for the adult and lowest for the 48-month-old child. Breathing rate also changed the regional deposition of particles. For example, in a 48-month-old child at resting breathing rates, deposition of hygroscopic particles with an initial diameter of 1 ym was greatest in the alveolar compartment. During exertion, deposition was greatest in the tracheobronchial region. The Martonen and Zhang (1993) model indicates that, in addition to particle size, subject age and exertion level should be considered in studies of the health effects of sulfuric acid particles. The model also suggests that children are a sensitive subpopulation for exposure to sulfuric acid aerosols. Martonen and Zhang (1993) cautioned that few general observations regarding the effect of hygrosco- picity, age, and breathing rate on the deposition of sulfuric acid aerosols could be made, and that respiratory tract deposition should be considered on a case-by-case basis. 2.3.2.2 Oral Exposure No studies were identified regarding the distribution of sulfuric acid following oral exposure of humans or animals. ***DRAFT FOR PUBLIC COMMENT*** +LNJWWOD O118Nd HOS L4vHd... TABLE 2-4. Age-Dependent Respiratory Parameters as a Function of Subject Physical Activity Levels Used in the Martonen and Zhang (1993) Model Resting Moderate Exertion Subject age Frequency Tidal Frequency Tidal Frequency Tidal (months) (min™) Volume (mL) (min) Volume (mL) (min™) Volume (mL) 7 35 42 32.0 187 81.1 2% 22 28 84 36.9 222 79.9 308 48 22 152 37.3 289 70.4 460 98 18 266 28.4 494 46.5 903 240 14 500 15.5 1,291 245 2,449 min" = per minute S103443 HLV3H ¢ aidv 21ldN41INS ANY 3AIX0oldl 4n41ns 6. SULFUR TRIOXIDE AND SULFURIC ACID 80 2. HEALTH EFFECTS 2.3.2.3 Dermal Exposure No studies were identified regarding the distribution of sulfuric acid following dermal exposure of humans or animals. 2.3.3 Metabolism Sulfur trioxide in contact with water forms sulfuric acid with the evolution of heat. Further contact with water results in the dissociation of sulfuric acid into hydrogen ions and hydrated sulfate ions, which can combine with other ions that are present in the body. Sulfate does not need to be further metabolized to be excreted in the urine. Route-specific studies of the metabolism of sulfuric acid were not identified. 2.3.4 Elimination and Excretion Sulfate, which is a normal metabolite of sulfur-containing amino acids, is excreted in the urine (Vander et al. 1975). 2.3.4.1 Inhalation Exposure No studies were identified regarding the excretion of sulfuric acid following inhalation exposure of humans or animals. 2.3.4.2 Oral Exposure No studies were identified regarding the excretion of sulfates following oral exposure of humans or animals to sulfuric acid. 2.3.4.3 Dermal Exposure No studies were identified regarding the excretion of sulfuric acid following dermal exposure of humans or animals. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 81 2. HEALTH EFFECTS 2.3.5 Physiologically Based Pharmacokinetic (PBPK)/Pharmacodynamic (PD) Models Physiologically based pharmacokinetic (PBPK) models use mathematical descriptions of the uptake and disposition of chemical substances to quantitatively describe the relationships among critical biological processes (Krishnan et al. 1994). PBPK models are also called biologically based tissue dosimetry models. PBPK models are increasingly used in risk assessments, primarily to predict the concentration of potentially toxic moieties of a chemical that will be delivered to any given target tissue following various combinations of route, dose level, and test species (Clewell and Andersen 1985). Physiologically based pharmacodynamic (PBPD) models use mathematical descriptions of the dose-response function to quantitatively describe the relationship between target tissue dose and toxic end points. PBPK/PD models refine our understanding of complex quantitative dose behaviors by helping to delineate and characterize the relationships between: (1) the external/exposure concentration and target tissue dose of the toxic moiety, and (2) the target tissue dose and observed responses (Andersen et al. 1987; Andersen and Krishnan 1994). These models are biologically and mechanistically based and can be used to extrapolate the pharmacokinetic behavior of chemical substances from high to low dose, from route to route, between species, and between subpopulations within a species. The biological basis of PBPK models results in more meaningful extrapolations than those generated with the more conventional use of uncertainty factors. The PBPK model for a chemical substance is developed in four interconnected steps: (1) model representation, (2) model parametrization, (3) model simulation, and (4) model validation (Krishnan and Andersen 1994). In the early 1990s, validated PBPK models were developed for a number of toxicologically important chemical substances, both volatile and nonvolatile (Krishnan and Andersen 1994; Leung 1993). PBPK models for a particular substance require estimates of the chemical substance-specific physicochemical parameters, and species-specific physiological and biological parameters. The numerical estimates of these model parameters are incorporated within a set of differential and algebraic equations that describe the pharmacokinetic processes. Solving these differential and algebraic equations provides the predictions of tissue dose. Computers then provide process simulations based on these solutions. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 82 2. HEALTH EFFECTS The structure and mathematical expressions used in PBPK models significantly simplify the true complexities of biological systems. If the uptake and disposition of the chemical substance(s) is adequately described, however, this simplification is desirable because data are often unavailable for many biological processes. A simplified scheme reduces the magnitude of cumulative uncertainty. The adequacy of the model is, therefore, of great importance, and model validation is essential to the use of PBPK models in risk assessment. PBPK models improve the pharmacokinetic extrapolations used in risk assessments that identify the maximal (i.e., the safe) levels for human exposure to chemical substances (Andersen and Krishnan 1994). PBPK models provide a scientifically-sound means to predict the target tissue dose of chemicals in humans who are exposed to environmental levels (for example, levels that might occur at hazardous waste sites) based on the results of studies where doses were higher or were administered in different species. Figure 2-3 shows a conceptualized representation of a PBPK model. If PBPK models for sulfur trioxide and sulfuric acid exist, the overall results and individual models are discussed in this section in terms of their use in risk assessment, tissue dosimetry, and dose, route, and species extrapolations. PBPK models for sulfur trioxide and sulfuric acid were not identified. Dosimetric models that examine the effect of hygroscopic growth within the respiratory tract on deposition of sulfuric acid aerosols in the lungs are discussed in Section 2.3.2.1. 2.4 MECHANISMS OF ACTION 2.4.1 Pharmacokinetic Mechanisms Sulfuric acid is a direct irritant that results in adverse effects at the site of contact. The concentration of sulfuric acid is important in determining effects. For example, a small amount of concentrated sulfuric acid will erode and possibly cause perforation of the gastrointestinal tract if swallowed. The same amount of acid diluted sufficiently will have no effects. The effects of sulfuric acid are thought to be a result of pH change rather than a result of sulfate. If there is enough acid-neutralizing capacity at the site of contact with sulfuric acid, there will be no effects. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 83 2. HEALTH EFFECTS Figure 2-3. Conceptual Representation of a Physiologically Based Pharmacokinetic (PBPK) Model for a Hypothetical Chemical Substance Inhaled chemical ----- 1 ----* Exhaled chemical 1 1 / . y Ingestion < A (a < oD = 5 | ; Vv max Km Gal |_| Tract Fat » nwcozm< r>—ImM-4I0> Slowly perfused M tissues Richly perfused tissues OO0O0Orw ooOorw > Kidney pee Urine - Skin < £% Ew Chemical in air contacting skin Note: This is a conceptual representation of a physiologically-based pharmacokinetic (PBPK) model for a hypothetical chemical substance. The chemical substance is shown to be absorbed via the skin, by inhalation, or by ingestion, metabolized in the liver, and excreted in the urine or by exhalation. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 84 2. HEALTH EFFECTS For inhalation exposure to sulfuric acid aerosols, the important issues are where in the respiratory tract the aerosols deposit and the duration of exposure. Factors that determine the site of deposition in the respiratory tract include environmental conditions, especially relative humidity which affects aerosol size, and physiological factors of the subject including breathing rate and depth, and method of ‘breathing, e.g., mouth, nose, or oronasal. The effect of hygroscopic growth on deposition within the respiratory tract has been modeled in adults (Martonen and Patel 1981) and children (Martonen and Zhang 1993), and because of differences in airway size, children are more sensitive to the respiratory tract effects of sulfuric acid aerosols. 2.4.2 Mechanisms of Toxicity Sulfuric acid aerosol toxicity is dependent on the hydrogen ion content of the aerosol. For any of the observed health effects of sulfuric acid, the acid is more potent than its neutralization products (Utell and Frampton 1992). One mechanism by which sulfuric acid may produce its toxicity is by changing extracellular and intracellular pH. There is evidence that pH plays a critical role in growth control and cell differentiation, and that disrupting the control of pH may lead to adverse effects (Soskolne et al. 1989). A sufficiently low pH is genotoxic to some cell systems and teratogenic. Therefore, a significant change in pH produced by sulfuric acid exposure could potentially lead to carcinogenic and teratogenic effects if it reached susceptible targets. A preliminary in vitro study that exposed a human tracheal epithelial cell line to sulfuric acid aerosols of 0.75, 1.4, or 3.28 um for 10 minutes, revealed that intracellular pH decreased, and that at equal mass concentrations, the change in pH was greater for the smaller particle sizes (Chen et al. 1993). Respiratory mucus serves as a barrier to the penetration of hydrogen ions into the tissue. The buffering capacity and pH of a person’s mucus may determine whether there will be a response to a sulfuric acid aerosol exposure. The pH of mucus is generally in the range of 7.4-8.2, and it shows diurnal and day-to-day variations. Asthmatics have been reported to have lower pH mucus in the range of 5.3-7.6. In vitro studies have shown that when the pH of mucus is lowered below about 7.4 the viscosity increases (Holma 1985). Mucus with greater viscosity would serve to decrease mucociliary clearance. It has been estimated that persons with normal mucus buffer capacity and protein content can accommodate about 300 pg/m® of sulfuric acid per 30 minutes (Holma 1989). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 85 2. HEALTH EFFECTS Rather than a change in viscosity, an animal study suggests that increased mucus thickness may affect clearance. Changes in mucus viscosity were not observed in rats exposed to 94.4 mg/m® for 4 hours, or in guinea pigs exposed to 43.3 mg/m’ for 4 hours (Lee et al. 1995). The thickness of the mucus layer was increased in these animals. The genotoxic effects of lowered pH may contribute to the ability of sulfuric acid to produce respiratory tract tumors. Sulfuric acid may also act as a respiratory tract carcinogen by acting as a direct irritant leading to chronic inflammation (Soskolne et al. 1989). Chronic inflammation results in the release of free radicals which have a genotoxic action. In addition, chronic inflammation may increase susceptibility to infection which may contribute to a carcinogenic response. 2.4.3 Animal-to-Human Extrapolations Guinea pigs, which are the most sensitive animal species, are thought to react to sulfuric acid aerosol exposures in a manner similar to asthmatics, the most sensitive segment of the human population (Amdur 1989a). 2.5 RELEVANCE TO PUBLIC HEALTH Overview Sulfuric acid, which forms in the atmosphere from sulfur dioxide, is a common atmospheric pollutant. Sulfur trioxide is an intermediate in the formation of sulfuric acid from sulfur dioxide. The effects of sulfuric acid are a result of hydrogen ion and not sulfate. The potential for other substances, especially ammonia, in the atmosphere to neutralize sulfuric acid determines whether or not humans are exposed to sulfuric acid aerosols. Numerous experimental acute-duration exposure studies of humans and animals indicate that exposure to sulfuric acid aerosols can result in changes in lung function and can affect clearance of particles from the respiratory tract. In addition to exposure concentration, the response to sulfuric acid is also dependent on the size of the aerosol, relative humidity (Sim and Pattle 1957), the buffering capacity of the aerosol (Fine et al. 1987), respiratory tract ammonia levels (Utell et al. 1989), as well as the breathing pattern of the subject (Bowes et al. 1995). Children are generally more sensitive to sulfuric ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 86 2. HEALTH EFFECTS acid aerosols than adults, and asthmatic individuals are more sensitive than healthy subjects. The lowest concentrations and exposure durations resulting in transient changes in pulmonary function tests in asthmatics were a 40—45-minute exposure to 0.07 mg/m’ (MMAD 0.72 pm) (Hanley et al. 1992) and a 50-minute exposure to 0.1 mg/m’ (MMAD 0.6 um) (Koenig et al. 1985). The effects noted included a transient decrease in FVC, a decrease in FEV, and increased respiratory resistance. Other studies of pulmonary function in asthmatics exposed to similar concentrations of sulfuric acid have not shown adverse effects (Anderson et al. 1992; Avol et al. 1990; Koenig et al. 1992; Utell et al. 1983). The most sensitive effect in normal subjects is clearance of test particles of sizes in the range of 3-7.6 um. A concentration of about 0.1 mg/m’ has resulted in a reduced rate of bronchial mucociliary clearance in normal subjects (Laube et al. 1993; Spektor et al. 1989). Acute studies in animals exposed to sulfuric acid aerosols have also shown changes in pulmonary function tests (Amdur 1958; Amdur et al. 1978) and clearance of test particles (Chen and Schlesinger 1983; Mannix et al. 1991; Schlesinger et al. 1984). Guinea pigs are more sensitive to changes in pulmonary function than other species and are thought to respond in a manner similar to asthmatic humans (Amdur 1989a). In the United States, sulfuric acid or hydrogen ion (as sulfuric acid) levels in the atmosphere are generally below 0.005 mg/m’ (Lioy and Waldman 1989), although higher concentrations, up to about 0.7 mg/m?, can occur during pollution episodes (Amdur 1989b). Epidemiological studies do not provide clear evidence linking environmental exposure to sulfuric acid aerosols alone to adverse health effects in humans (Lioy and Waldman 1989). More sulfuric acid is produced in the United States than any other chemical (C&EN 1996). Therefore, there is a high potential for accidental and occupational exposure to sulfuric acid. Among states reporting accidental events during the time period 1990-1996 (5 states 1990-1991, 9 states 1992-1994, 14 states 1995-1996) 905 events occurred which involved only sulfuric acid and oleum (3 oleum releases), and 173 events occurred which involved mixtures or multi-chemical releases that included sulfuric acid or oleum (HSEES 1997). Among the events in which only sulfuric acid and oleum were released, 53 required evacuation (information not available for 39 events), there was one death, and a total of 203 victims. Chemical burns (38.5%), respiratory irritation (21.6%), and eye irritation (15.4%) were the most frequently reported effects following these releases. Among the mixture or multi-chemical releases that included sulfuric acid or oleum, 40 required evacuation ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 87 2. HEALTH EFFECTS (information not available for 3 events), there were 3 deaths, and a total of 322 victims. The most frequently reported effects following the release of mixtures were respiratory irritation (56.5%), eye irritation (17.8%), and nausea and vomiting (5.1%). Industries with potential exposure to sulfuric acid include fertilizer, sulfuric acid, isopropanol, synthetic ethanol, and detergent production; building and construction; electric and electronic equipment; food products; health services; leather; oil and gas extraction; petroleum and coal products; photography shops; printing and publishing; paper and allied products; rubber and plastic products; steel; and textile products (IARC 1992). In occupational settings, exposure can be above 0.5 mg/m’, with the highest concentrations generally found in metal pickling operations. Effects observed in persons occupationally exposed to sulfuric acid included a slight increase in bronchitis without a change in lung function (Williams 1970), a small decrease in FVC (Gamble et al. 1984b), tooth erosion (El- Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961), and an increase in periodontal pockets (Tuominen 1991). The lowest average concentration resulting in effects in these occupational studies was 0.2 mg/m’ (Gamble et al. 1984b). Average concentrations were generally greater than 1 mg/m’ in other studies in which exposure concentrations were reported (El-Sadik et al. 1972; Malcolm and Paul 1961; Williams 1970). The permissible exposure limit for sulfuric acid aerosols is 1 mg/m® (OSHA 1996). Chronic-duration inhalation studies in monkeys exposed to sulfuric acid aerosols reported histopathological changes in the lungs at 0.38 mg/m’ (MMD 2.15 pm), 2.45 mg/m? (MMD 3.6 pum), and 4.79 mg/m’ (MMD 0.73 um), with no effects at 0.48 mg/m’ (MMD 0.54 pum) (Alarie et al. 1973). Arterial oxygen was affected only at 2.45 mg/m’ (MMD 3.6 um), the only exposure concentration utilized in these studies that resulted in histopathologic changes in the alveoli. Chronic exposure of guinea pigs at concentrations up to 0.9 mg/m* (MMD 0.49 um) did not result in any histopathological changes in the lungs (Alarie et al. 1973, 1975). Additional treatment-related adverse effects on other organ systems were not observed in either monkeys or guinea pigs, although all the data were not presented. Inhalation exposure to sulfuric acid aerosols has not been shown to result in reproductive or develop- mental effects in mice or rabbits (Murray et al. 1979). Because sulfuric acid is a direct-acting toxicant and not likely to reach reproductive organs or the fetus, reproductive and developmental effects are unlikely to occur in humans exposed to sulfuric acid. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 88 2. HEALTH EFFECTS Occupational exposure to mineral acid aerosols including sulfuric acid has been associated with respiratory tract cancers (Alderson and Rattan 1980; Beaumont et al. 1987; Coggon et al. 1996; Forastiere et al. 1987; Houghton and White 1994; Soskolne et al. 1984, 1992; Steenland and Beaumont 1989; Steenland et al. 1988). However, most of the cancers were in smokers who were also exposed to other chemicals. There is no information that exposure to sulfuric acid by itself is carcinogenic, and there is no clear data on exposure concentrations of sulfuric acid associated with cancer in humans. DHHS (1994) and EPA have not classified sulfur trioxide or sulfuric acid for carcinogenic effects. Based on the limited human data, which associate occupational exposure to mineral acid aerosols with the development of lung and laryngeal cancers, IARC (1992) considers occupational exposure to strong-inorganic-acid mists containing sulfuric acid carcinogenic to humans (Group 1). The carcinogenicity of sulfuric acid alone has not been classified by IARC. The carcino- genicity of sulfuric acid has not been studied in animals. In addition to inhalation exposure to sulfuric acid aerosols, there is potential for accidental oral or dermal exposure to concentrated sulfuric acid. Sulfuric acid is found in lead-acid batteries, and cleaners (especially toilet bowl cleaners) contain compounds that release sulfuric acid when they contact water. Therefore, the general population may come into contact with sulfuric acid when using these products and others that contain sulfuric acid. At sufficient concentrations, sulfuric acid has been shown to corrode the gastrointestinal tract when swallowed (Aktug et al. 1995; Dilawari et al. 1984) and corrode the skin (Branday et al. 1996) and eyes (Grant 1974; Holekamp and Becker 1977, Schultz et al. 1968) on contact. Minimal Risk Levels for Sulfur Trioxide/Sulfuric Acid Inhalation MRLs No inhalation MRLs were derived for sulfur trioxide or sulfuric acid exposure. The only inhalation study regarding sulfur trioxide exposure is a report of respiratory irritation in persons accidently exposed (Stueven et al. 1993). Exposure concentrations were not provided in this report. Several acute-duration human exposure studies have reported respiratory effects including bronchoconstriction resulting in changes in lung function tests and changes in bronchial mucociliary clearance. The lowest concentration that resulted in changes in lung function tests was 0.07 mg/m’ “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 89 2. HEALTH EFFECTS (MMAD 0.72 pm), a concentration at which transient decreases in FVC and FEV, were observed in asthmatics exposed for 40-45 minutes with intermittent exercise (Hanley et al. 1992). Increased respiratory resistance, decreased maximum flow at 50% and 75% of total vital capacity, and decreased FEV, have also been reported in asthmatics exposed to 0.1 mg/m’ (MMAD 0.6 um) for 50 minutes with exercise (Koenig et al. 1985). Although asthmatics are considered more sensitive to changes in lung function following exposure to sulfuric acid, all studies have not reported changes in lung function tests in asthmatics exposed to sulfuric acid aerosols. For example, changes in lung function tests were not observed in asthmatics exposed to 0.1 mg/m® sulfuric acid aerosols (MMAD 0.5 um) for 1 hour with intermittent exercise (Anderson et al. 1992). Lung function was affected in 1 of the 15 exposed subjects leading the study authors to conclude that there may be a subgroup of asthmatics that are more sensitive to sulfuric acid exposure. Bronchial mucociliary clearance has only been studied in normal individuals. Decreased clearance was observed in subjects exposed to sulfuric acid aerosols (MMD 0.5 pm) with a nasal mask for 1 hour at 0.98 mg/m’ for test particles of 7.6 um (Leikauf et al. 1981), and at 0.108 mg/m? for test particles of 4.2 um (Leikauf et al. 1984). These studies are not being used as the basis of an MRL because physiological factors and conditions under which humans are exposed are just as important in determining the response to sulfuric acid aerosols as the aerosol concentration and aerosol size. Factors which will affect the response to sulfuric acid include aerosol size, relative humidity, condition of the subject (e.g., asthmatic), amount of ammonia present in the mouth, breathing rate, and depth of breathing. Bowes et al. (1995) estimated the deposition of hydrogen ion in seven healthy male adults exposed to 0.471 mg/m* sulfuric acid aerosols (MMAD 10 pm) using a head-dome that allowed continuous measurement of frequency, tidal volume, and minute ventilation, as well as the onset and persistence of oronasal breathing. They indicated that of the parameters used to estimate the dose of hydrogen ion delivered to the lung, 70% of the variability was accounted for by physiologic parameters (minute ventilation during oronasal breathing 36%; time in minutes of oronasal breathing 34%), and the environmental hydrogen ion concentration accounted for only 30% of the variation. Because the response to sulfuric acid aerosol exposure is so dependent on individual factors rather than exposure concentrations it would be very difficult to identify a NOAEL for human exposure. Intermediate-duration inhalation studies are limited to animal studies (Fujimaki et al. 1992; Gearhart and Schlesinger 1986; Lewis et al. 1969; Schlesinger et al. 1979; Thomas et al. 1958), and chronic- duration inhalation studies include human occupational studies (El Sadik et al. 1972; Gamble et al. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 90 2. HEALTH EFFECTS 1984; Kitagawa 1984; Kremer et al. 1994; Malcolm and Paul 1961; Williams 1970) and animal studies (Alarie et al. 1973, 1975; Schlesinger et al. 1992a). Because the occupational studies identified NOAELSs higher than LOAELSs in acute-duration studies they were not considered appropriate for MRL derivation. The methodology for extrapolating from inhalation exposure of animals to hygroscopic aerosols has yet to be developed (EPA 1994). Therefore, inhalation MRLs could not be developed from animal studies. Oral MRLs No oral MRLs for sulfuric acid were derived. Although high concentrations of sulfuric acid are corrosive to the gastrointestinal tract (Aktug et al. 1995; Dilawari et al. 1984), there were insufficient data regarding oral exposure to sulfuric acid for the development of oral MRLs. This profile did not consider the oral toxicity of sulfites, which are used as food preservatives, or the oral toxicity of sulfate-containing compounds. Death Studies regarding death of humans following acute- and intermediate-duration inhalation exposure to sulfuric acid aerosols were not identified. Increased mortality, especially of elderly persons and those with preexisting cardiac and respiratory disease, has been reported during or shortly after air pollution episodes (Costa and Amdur 1996). Because it is not possible to clearly separate the effects of sulfuric acid aerosols from other pollutants including particulates, sulfur dioxide, and ozone, these studies are not discussed further. Deaths of humans have been reported following acute oral (Dilawari et al. 1984) and dermal exposure (Branday et al. 1996; Schultz et al. 1968). One-hour LCs of 347 and 420 ppm fuming sulfuric acid have been reported for female and male rats, respectively (Vernot et al. 1977). The lowest concentration of sulfuric acid aerosols that resulted in the death of rats was 383 mg/m’ (Treon et al. 1950). Mice were more susceptible to sulfuric acid aerosol exposure (diameter 1-2 um) than rats (Treon et al. 1950). Among the species exposed to sulfuric acid aerosols, guinea pigs are the most sensitive. During a 1-hour exposure to 52-61 mg/m’ sulfuric acid (MMAD 0.8-2.1 pm), about 6% of the exposed guinea pigs died (Stengel et al. 1993). Younger guinea pigs are more sensitive to sulfuric acid aerosols than older guinea pigs (Amdur et al. 1952a). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 91 2. HEALTH EFFECTS The effect of aerosol size on survival of guinea pigs exposed to sulfuric acid aerosols has been studied. Following exposure to sulfuric acid aerosols with MMADs of 0.8 and 0.4 pm, LCs;s of 30.3 and >109 mg/m’, respectively, were reported for guinea pigs exposed for 8 hours (Wolff et al. 1979). Eight-hour LCs of 59.8 and 27.3 mg/m’ were reported for aerosols of MMAD:s of 0.8 and 2.7 pm, respectively (Pattle et al. 1956). No effect on survival was observed in cynomolgus monkeys or guinea pigs exposed to sulfuric acid aerosols 23.3 hours/day, 7 days/week, for 78 weeks (monkeys) or 52 weeks (guinea pigs) (Alarie et al. 1973). The LD, in rats treated by gavage with reagent grade sulfuric acid in water at a concentration of 0.25 g/mL was reported as 2,140 mg/kg (Smyth et al. 1969). Deaths of laboratory animals following longer term oral exposure to sulfuric acid were not reported. No studies were located regarding deaths in animals after dermal exposure to sulfuric acid. Deaths are unlikely to occur at concentrations of sulfuric acid normally found in the environment or at hazardous waste sites. Systemic Effects Respiratory Effects. Acute inhalation exposure to sulfur trioxide and sulfuric acid results in respiratory tract irritation in humans (Sim and Pattle 1957; Stueven et al. 1993) and animals (Stengel et al. 1993; Wolff et al. 1979). At lower concentrations acute inhalation exposure adversely affects pulmonary function tests in both humans (Avol et al. 1988; Hanley et al. 1992; Koenig et al. 1992; Utell et al. 1983) and animals (Amdur 1958, 1959; Amdur et al. 1978; Kobayashi and Shinozaki 1993). Adolescent asthmatics are the humans most sensitive to sulfuric acid aerosol exposure (Hanley et al. 1992; Koenig et al. 1992), and guinea pigs, which are thought to react in a manner similar to asthmatic humans, are the most sensitive of animal species tested (Amdur 1989a). The lowest concentrations and exposure durations resulting in transient changes in pulmonary function tests in adolescent asthmatics were a 40-45-minute exposure to 0.07 mg/m’ (Hanley et al. 1992) and a 50-minute exposure to 0.1 mg/m® (Koenig et al. 1985). The effects noted included a transient decrease in FVC, a decrease in FEV, and increased respiratory resistance. Other studies of pulmonary function in asthmatics exposed to similar concentrations of sulfuric acid have not shown adverse effects (Anderson et al. 1992; Avol et al. 1990; Koenig et al. 1992). Factors that affect the respiratory response to sulfuric acid aerosols include aerosol size, relative humidity (Sim and Pattle 1957), the ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 92 2. HEALTH EFFECTS buffering capacity of the aerosol (Fine et al. 1987), respiratory tract ammonia levels (Utell et al. 1989), as well as the breathing pattern of the subject (Bowes et al. 1995). A sensitive effect of sulfuric acid exposure in healthy subjects is clearance of test particles. A concentration of about 0.1 mg/m’ has resulted in a reduced rate of bronchial mucociliary clearance in healthy subjects (Laube et al. 1993; Leikauf et al. 1981, 1984; Spektor et al. 1989). Clearance of test particles has also been shown to be adversely affected in animals following both acute- and intermediate-duration exposures (Chen and Schlesinger 1983; Mannix et al. 1991; Schlesinger and Gearhart 1986; Schlesinger et al. 1979, 1984). It has been suggested that decreased clearance induced by some exposures to sulfuric acid aerosols may contribute to the development of chronic bronchitis (Lippmann et al. 1982). Epidemiological studies do not provide clear evidence linking environmental exposure to sulfuric acid aerosols alone to adverse respiratory effects in humans (Abbey et al. 1993, 1995; Lioy and Waldman 1989). Respiratory effects observed in persons occupationally exposed to sulfuric acid aerosols include a slight increase in bronchitis without a change in lung function (Williams 1970) and a small decrease in FVC (Gamble et al. 1984b). The lowest average concentration resulting in effects in these occupational studies was 0.2 mg/m’ (Gamble et al. 1984b). Chronic-duration inhalation studies in monkeys exposed to sulfuric acid aerosols reported histopathological changes in the lungs at 0.38 mg/m’ (MMD 2.15 pm), 2.45 mg/m* (MMD 3.6 pm), and 4.79 mg/m’ (MMD 0.73 pm), with no effects at 0.48 mg/m* (MMD 0.54 um) (Alarie et al. 1973). The 2.45-mg/m’ exposure concentration also resulted in decreased arterial oxygen and was the only exposure in which the histopathological changes also involved the alveoli. Chronic exposure of guinea pigs at concentrations up to 0.9 mg/m’ (MMD 0.49 pm) did not result in any histopathological changes in the lungs (Alarie et al. 1973, 1975). In the United States, sulfuric acid or hydrogen ion (as sulfuric acid) levels in the atmosphere are generally below 0.005 mg/m’ (Lioy and Waldman 1989), although higher concentrations, up to about 0.7 mg/m’, can occur during pollution episodes (Amdur 1989b). Therefore, during some pollution episodes, asthmatic subjects may respond with decrements in pulmonary function tests, and decreases in mucociliary clearance may occur in both normal and asthmatic subjects. Exercise, which increases breathing rate and oral breathing, increases the response to sulfuric acid aerosols. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 93 2. HEALTH EFFECTS Following oral exposure to sulfuric acid, death resulting from bronchopneumonia occurred in one subject (Dilawari et al. 1984). This case suggests that oral exposure to sulfuric acid could result in aspiration of the acid into the lungs leading to respiratory effects. Respiratory effects have not been reported following dermal exposure to sulfuric acid. Cardiovascular Effects. Based a limited human studies (Abbey et al. 1995; Bowes et al. 1995), and the lack of histopathological changes in the hearts of monkeys and guinea pigs exposed chronically, inhalation exposure to sulfuric acid aerosols does not result in cardiovascular effects. No studies were identified regarding cardiovascular effects of sulfur trioxide or sulfuric acid following exposure via other routes. Sulfuric acid is a direct-acting toxicant. Therefore, cardiovascular effects are not likely to occur following exposure to sulfuric acid. Gastrointestinal Effects. Studies reporting accidental ingestion of concentrated sulfuric acid by humans indicate that it erodes the gastrointestinal tract if it is swallowed (Aktug et al. 1995; Dilawari et al. 1984). The concentration of acid required to cause gastrointestinal erosion has not been studied. Gastrointestinal effects have not been studied in animals, nor have they been studied following exposure via other routes. Because sulfuric acid is not likely to be present at high concentrations in the environment, environmental exposure to sulfur trioxide or sulfuric acid is unlikely to result in gastrointestinal tract effects. Hematological Effects. Hematological effects have not been studied in humans exposed to sulfur trioxide or sulfuric acid via any exposure route. Hematological effects have not been reported in monkeys (Alarie et al. 1973) or guinea pigs (Alarie et al. 1973, 1975) following chronic inhalation exposure to sulfuric acid aerosols. Because sulfuric acid is a direct-acting toxicant, hematological effects are not likely to occur following exposure to sulfur trioxide or sulfuric acid by any route. Musculoskeletal Effects. Musculoskeletal effects have not been studied in humans exposed to sulfur trioxide or sulfuric acid, nor have they been studied by any other route of exposure. Because sulfuric acid 1s a direct-acting toxicant, musculoskeletal effects are not likely to occur following exposure by any route. The effect of sulfuric acid on growth, including tibia length, has been studied in chicks (Capdevielle and Scanes 1995b) and ducklings (Capdevielle and Scanes 1995a) treated with the acid in the diet. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 94 2. HEALTH EFFECTS Decreased tibia length associated with decreased food intake was observed in chicks but not ducklings. The objective of these studies was to determine if aluminum (or acid, which increases aluminum levels in the environment) affects the growth of birds. Aluminum was shown to have an effect on growth of chickens that could not be attributed to the changes in food intake, while the effects of acid were attributed to decreased food intake. Although sulfuric acid may not have a direct effect on growth, including bone length, in the environment lowered pH may lead to secondary effects by increasing levels of metals including aluminum. Hepatic Effects. Hepatic effects have not been studied in humans exposed to sulfur trioxide or sulfuric acid by any route. Effects on the liver have not been observed in mice or rabbits following inhalation exposure to sulfuric acid during gestation (Murray et al. 1979), or in monkeys (Alarie et al. 1973) or guinea pigs (Alarie et al. 1973, 1975) following chronic inhalation exposure to sulfuric acid. Liver weights were not affected in chicks (Capdevielle and Scanes 1995b) or ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. Because sulfuric acid is a direct-acting toxicant, hepatic effects are not likely to occur following exposure by any route. Renal Effects. Renal effects have not been studied in humans exposed to sulfur trioxide or sulfuric acid by any route. Microscopic changes in the kidneys were not observed in monkeys (Alarie et al. 1973) or guinea pigs (Alarie et al. 1973, 1975) following chronic inhalation exposure to sulfuric acid. Kidney weights were not affected in chicks (Capdevielle and Scanes 1995b) or ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. Because sulfuric acid is a direct-acting toxicant, renal effects are not likely to occur following exposure by any route. Endocrine Effects. Endocrine effects have not been studied in humans exposed to sulfur trioxide or sulfuric acid by any route of exposure. Changes in growth hormone, insulin-like growth factor, and insulin-like growth-factor binding proteins were not observed in chicks (Capdevielle and Scanes 1995b) or ducklings (Capdevielle and Scanes 1995b) fed sulfuric acid in the diet. The objective of these studies was to determine if aluminum (or ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 95 2. HEALTH EFFECTS acid, which increases aluminum levels in the environment) affects the growth of birds. High doses of aluminum were shown to reduce the levels of insulin-like growth factor in chicks. Although sulfuric acid may not have a direct effect on growth, in the environment lowered pH may lead to secondary effects by increasing levels of metals including aluminum. Because sulfuric acid is a direct-acting toxicant, endocrine effects are not likely to occur in humans following exposure by any route. Dermal Effects. Direct application of concentrated sulfuric acid to the skin or eyes can result in burns in humans (Branday et al. 1996; Schultz et al. 1968) and animals (Sekizawa et al. 1994). The concentration required to result in dermal burns has not been clearly determined. Dermal exposure of humans to a 10% sulfuric acid solution was considered non-irritating (Nixon et al. 1975). Erosion of the skin at 10%, erythema and edema at 5%, and no effects at 2.5% were reported in rats and mice in which the acid was placed on the electric razor-shaved skin of the back (Sekizawa et al. 1994). No skin effects were observed in guinea pigs or rabbits in which a 10% sulfuric acid solution was applied to the skin (Nixon et al. 1975). During a 4-hour exposure, sulfuric acid was not corrosive to the skin when 0.5 mL of a 4% solution was placed on the backs of rabbits, clipped of hair 24 hours before exposure (Vernot et al. 1977). In an in vitro study, application of a 40% solution to rat skin caused a large fall in the transcutaneous electrical resistance (Botham et al. 1992). This response correctly predicts that sulfuric acid is corrosive (Botham et al. 1992). Dermal effects have not been studied by other routes of exposure. Very high concentrations of sulfur trioxide or sulfuric acid aerosols in the air could potentially result in direct skin irritation. Because these same concentrations would also result in respiratory tract and eye irritation, skin effects would be the prominent effect of sulfuric acid aerosols only if the exposed persons were using respiratory and eye protective equipment. Ocular Effects. Direct exposure of the eyes to concentrated sulfuric acid can result in devastating destruction of the eye (Grant 1974; Holekamp and Becker 1977; Schultz et al. 1968). Direct exposure of the eyes to lower concentrations results in transient injury with complete recovery (Grant 1974). Eye irritation including lacrimation has been reported in humans exposed to sulfuric acid in air (Avol et al. 1988; Sim and Pattle 1957). The effect was worse at high humidity than at low humidity (Sim and Pattle 1957). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 96 2. HEALTH EFFECTS Animal studies indicate that direct application of sulfuric acid into the eyes is corrosive (Murphy et al. 1982; Sekizawa et al. 1994). The concentration of sulfuric acid required to result in direct eye effects has not been clearly defined. A concentration of 10% was considered non-irritating in rabbits in one study (Sekizawa et al. 1994), while a 10% concentration resulted in severe corneal opacities in rabbits with minimal effects observed at 5% in a second study (Murphy et al. 1992). Ocular effects are unlikely to occur at the levels of sulfuric acid that are found in the environment. Body Weight Effects. No effects on body weight were observed in mice or rabbits following inhalation exposure to sulfuric acid aerosols during gestation (Murray et al. 1979), or in monkeys (Alarie et al. 1973) or guinea pigs (Alarie et al. 1973, 1975) following chronic exposure to sulfuric acid aerosols. Decreased body weight gain associated with decreased food intake was observed in chicks (Capdevielle and Scanes 1995b) but not ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. The objective of these studies was to determine if aluminum (or acid, which increases aluminum levels in the environment) affects the growth of birds. Aluminum was shown to have an effect on growth of chickens that could not be attributed to changes in food intake; while the effects of acid were attributed to decreased food intake. Although sulfuric acid may not have a direct effect on growth, in the environment lowered pH may lead to secondary effects by increasing levels of metals including aluminum. Body weight changes have not been studied in animals dermally exposed to sulfuric acid. Because sulfuric acid is a direct toxicant, body weight changes are unlikely following dermal exposure, except possibly as a secondary effect as a result of the stress of dermal burns. Other Systemic Effects. Studies of workers indicate that exposure to sulfuric acid aerosols can result in lowered pH of the saliva (El-Sadik et al. 1972), erosion of the teeth (El-Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961), and increased prevalence of periodontal pockets (Tuominen 1991). Malcolm and Paul (1961) indicated that the front teeth were the teeth most often affected, suggesting that the effect was the result of direct impingement of acid mist on the teeth. Tooth erosion is unlikely to occur at sulfuric acid concentrations generally found in the environment. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 97 2. HEALTH EFFECTS Immunological and Lymphoreticular Effects. The function of alveolar macrophages collected from humans following inhalation exposure to sulfuric acid aerosols for 2 hours was not affected (Frampton et al. 1992). Alveolar macrophage function was affected in animals following inhalation exposure to sulfuric acid aerosols, resulting in decreased intracellular pH (Chen et al. 1995), depressed phagocytic activity (Chen et al. 1992a; Schlesinger et al. 1992b), and reduced TNF cytotoxic activity and zymosan-stimulated production of superoxide anion (Schlesinger et al. 1992b; Zelikoff and Schlesinger 1992). These effects on alveolar macrophage function have not been shown to be concentration related. Once a critical level of sulfuric acid was reached, no further effects were observed. Effects were greater following exposure to smaller aerosols (MMD 0.04 pm versus 0.3 um), leading Chen et al. (1992a) to suggest that the smaller droplets deliver a higher dose to the macrophages than the larger droplets. Inhalation exposure to sulfuric acid aerosols has also been shown to enhance antigen-induced histamine release from mast cells collected from exposed guinea pigs (Fujimaki et al. 1992). Mice challenged with Streptococcus pyrogens directly after ultrafine sulfuric acid aerosol exposure (2 hours/day for 5 days) did not show increased mortality (Grose et al. 1982). The studies of immune system function in animals suggest that although sulfuric acid exposure may adversely affect in vitro function of macrophages collected from exposed animals, the ability to defend against bacterial infections may not be adversely affected by inhalation exposure to sulfuric acid aerosols. Immunological and lymphoreticular effects have not been studied following oral or dermal exposure to sulfuric acid. Because sulfuric acid is a direct-acting toxicant, system-wide effects on the immune system are not likely following exposure to sulfuric acid by any route. Neurological Effects. Lightheadedness and dizziness have been reported by persons accidentally exposed to unspecified concentrations of sulfur trioxide (Stueven et al. 1993). Fatigue and headaches were reported more frequently in asthmatic volunteers when they were exposed to sulfuric acid aerosols at 0.999 but not 0.396 mg/m’ for 1 hour (Avol et al. 1988). Neurological effects have not been studied following oral or dermal exposure of humans to sulfuric acid, or in animals following exposure by any route. Because sulfuric acid is a direct-acting toxicant, neurological effects other than subjective symptoms and reflex response to pain are not likely following exposure to sulfuric acid by any route. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 98 2. HEALTH EFFECTS Reproductive Effects. No significant effects on the mean numbers of implants/dam or resorptions/litter were noted in mice or rabbits exposed by inhalation to sulfuric acid aerosols during gestation (Murray et al. 1979). Changes in testes weight were not observed in chicks (Capdevielle and Scanes 1995b) or ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. Additional studies regarding reproductive effects of sulfuric acid in humans or animals exposed by any route were not identified. Because sulfuric acid is a direct-acting toxicant, reproductive effects are not likely following exposure to sulfuric acid by any route. Developmental Effects. Significant effects on fetal body weights or on the incidence of major or minor malformations were not observed in mice or rabbits exposed by inhalation to sulfuric acid aerosols during gestation (Murray et al. 1979). No additional studies were identified regarding developmental effects of sulfuric acid in humans or animals following exposure by any route. Because sulfuric acid is a direct-acting toxicant, developmental effects in mammals are not likely following exposure by any route. In vitro studies have shown that sulfuric acid, or decreased pH, can induce chromosomal aberrations. Therefore, developing organisms that are in direct contact with the environment (e.g., insects, amphibians) could be adversely affected if there are sufficient levels of sulfuric acid to result in decreased pH. Genotoxic Effects. In vivo studies regarding the genotoxicity of sulfuric acid were not identified. In vitro studies regarding the genotoxicity of sulfuric acid are summarized in Table 2-5. Sulfuric acid did not increase gene mutation in Escherichia coli without metabolic activation (Demerec et al. 1951); it was not tested with metabolic activation in this study. In Salmonella typhimurium sulfuric acid was negative both with and without rat S9 metabolic activation (Cipollaro et al. 1986). Increases in chromosomal aberrations were observed in root meristimatic tissue of the plant Vicia faba (Zura and Grant 1981) and in Chinese hamster ovary cells (Morita et al. 1989) exposed to sulfuric acid. In a study on the effect of pH on the induction of mitotic aberrations in sea urchins (Sphaerechinus granularis, Paracentrotus lividus), an increase in aberrations was observed at pH <6.5 (Cipollaro et al. 1986). A similar genotoxic effect was observed with sulfuric acid, hydrochloric acid, and phosphoric acid. These results indicate that pH rather than sulfate was responsible for the effect. Other studies in which pH was adjusted with other acids indicate that acidic pH is genotoxic. At pH values (pH adjusted with lactic acid) of 6.5-7.0 the number of chromosomal anomalies in human ***DRAFT FOR PUBLIC COMMENT*** +LN3WWOO O118Nd HOH 1d4vHQd... Table 2-5. Genotoxicity of Sulfuric Acid In Vitro Results Species With Without (test system) End point activation activation Reference Prokaryotic organisms: Escherichia coli Gene mutation Not tested - Demerec et al. 1951 Salmonella typhimurium (TA97, TA9S, Gene mutation — - Cipollaro et al. 1986 TA102, TA1535) Eukaryotic organisms: Vicia faba (plant) Chromosomal Not tested + Zura and Grant 1981 aberrations Sphaerechinus granularis Chromosomal Not tested + Cipollaro et al. 1986 Parachetrotus lividus aberrations (sea urchins) Chinese hamster ovary cells Chromosomal + + Morita et al. 1989 aberrations — = negative result; + = positive result S103443 H1TV3H 2 aiov dldN4INS ANV 3aIXolidL "4N4InNs 66 SULFUR TRIOXIDE AND SULFURIC ACID 100 2. HEALTH EFFECTS lymphocytes in vitro was significantly increased compared with cells cultured at pH 7.5 (Shimada and Ingalls 1975). The anomalies observed included hypodiploidies, hyperdiploidies, and endoreduplica- tions. In mouse lymphoma L5178Y TK*" cells, pH of 6-6.8 (adjusted with hydrochloric acid) plus S9 resulted in an increase in mutations and chromosomal aberrations (Cifone et al. 1987). A transformed- like morphology was induced in Syrian hamster cells grown at pH values less than 6.9 (LeBoeuf and Kerckaert 1986). Cancer. Occupational exposure to sulfuric acid aerosols along with other chemicals has been associated with the development of respiratory tract cancers, especially laryngeal and lung cancers (Alderson and Rattan 1980; Beaumont et al. 1987; Coggon et al. 1996; Forastiere et al. 1987; Houghton and White 1994; Soskolne et al. 1984, 1992; Steenland and Beaumont 1989; Steenland et al. 1988). However, most of the cancers were in smokers who were also exposed to other chemicals. There is no information that exposure to sulfuric acid by itself is carcinogenic, and there are no clear data on exposure concentrations of sulfuric acid associated with cancer in humans. The U.S. DHHS (1994) and EPA have not classified sulfur trioxide or sulfuric acid for carcinogenic effects. Based on the human data, which associate occupational exposure to inorganic acid mists containing sulfuric acid with the development of lung and laryngeal cancers, IARC (1992) considers occupational exposure to strong inorganic acid mists containing sulfuric acid carcinogenic to humans (Group 1). Environmental exposure of humans to sulfuric acid has not been associated with cancer (Abbey et al. 1995). The carcinogenicity of sulfuric acid has not been studied in animals after exposure by any route. Environmental concentrations of sulfuric acid are generally much lower than those found in occupational settings and are unlikely to result in respiratory tract cancers. 2.6 BIOMARKERS OF EXPOSURE AND EFFECT Biomarkers are broadly defined as indicators signaling events in biologic systems or samples. They have been classified as markers of exposure, markers of effect, and markers of susceptibility (NAS/NRC 1989). Due to a nascent understanding of the use and interpretation of biomarkers, implementation of biomarkers as tools of exposure in the general population is very limited. A biomarker of exposure is a xenobiotic substance or its metabolite(s), or the product of an interaction between a xenobiotic agent “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 101 2. HEALTH EFFECTS and some target molecule(s) or cell(s) that is measured within a compartment of an organism (NAS/NRC 1989). The preferred biomarkers of exposure are generally the substance itself or substance-specific metabolites in readily obtainable body fluid(s) or excreta. However, several factors can confound the use and interpretation of biomarkers of exposure. The body burden of a substance may be the result of exposures from more than one source. The substance being measured may be a metabolite of another xenobiotic substance (e.g., high urinary levels of phenol can result from exposure to several different aromatic compounds). Depending on the properties of the substance (e.g., biologic half-life) and environmental conditions (e.g., duration and route of exposure), the substance and all of its metabolites may have left the body by the time samples can be taken. It may be difficult to identify individuals exposed to hazardous substances that are commonly found in body tissues and fluids (e.g., essential mineral nutrients such as copper, zinc, and selenium). Biomarkers of exposure to sulfur trioxide and sulfuric acid are discussed in Section 2.6.1. Biomarkers of effect are defined as any measurable biochemical, physiologic, or other alteration within an organism that, depending on magnitude, can be recognized as an established or potential health impairment or disease (NAS/NRC 1989). This definition encompasses biochemical or cellular signals of tissue dysfunction (e.g., increased liver enzyme activity or pathologic changes in female genital epithelial cells), as well as physiologic signs of dysfunction such as increased blood pressure or decreased lung capacity. Note that these markers are not often substance specific. They also may not be directly adverse, but can indicate potential health impairment (e.g., DNA adducts). Biomarkers of effects caused by sulfur trioxide sulfuric acid are discussed in Section 2.6.2. A biomarker of susceptibility is an indicator of an inherent or acquired limitation of an organism’s ability to respond to the challenge of exposure to a specific xenobiotic substance. It can be an intrinsic genetic or other characteristic or a preexisting disease that results in an increase in absorbed dose, a decrease in the biologically effective dose, or a target tissue response. If biomarkers of susceptibility exist, they are discussed in Section 2.8, Populations That Are Unusually Susceptible. 2.6.1 Biomarkers Used to Identify or Quantify Exposure to Sulfur Trioxide/Sulfuric Acid There are no established biomarkers of exposure for sulfur trioxide or sulfuric acid. The pH of saliva has been shown to decrease in persons occupationally exposed to sulfuric acid (El-Sadik et al. 1972). The pH of respiratory mucus may also decrease following inhalation exposure to sulfuric acid (Holma ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 102 2. HEALTH EFFECTS 1985). Because many things can affect the pH of saliva and respiratory mucus, a decrease in pH would not be a biomarker unique to sulfuric acid exposure. 2.6.2 Biomarkers Used to Characterize Effects Caused by Sulfur Trioxide/Sulfuric Acid Changes in pulmonary function tests following acute inhalation exposure of humans to sulfuric acid (Avol et al. 1988; Hanley et al. 1992; Koenig et al. 1985, 1992; Utell et al. 1984), and tooth etching following occupational exposure to sulfuric acid, have been reported (El-Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961). These effects are not unique to sulfuric acid exposure, and clear concentration-response relationships have not been established for these effects. Because the effects of sulfuric acid exposure are dependent on many factors in addition to concentration, including aerosol size, relative humidity, and breathing factors, a population-based concentration-response relationship for these effects would be difficult to establish. For more information on biomarkers for renal and hepatic effects of chemicals see ATSDR/CDC Subcommittee Report on Biological Indicators of Organ Damage (1990), and for information on biomarkers for neurological effects see OTA (1990). 2.7 INTERACTIONS WITH OTHER CHEMICALS In the environment, sulfuric acid exposure most frequently occurs in combination with exposure to other air pollutants including small metal particles, ozone, sulfur dioxide, and nitrogen oxides. Therefore, there are numerous studies that examine the effects of sulfuric acid in combination with other air pollutants. Exposure of 19 normal human volunteers to 0.37 ppm ozone, 0.37 ppm sulfur dioxide, and 0.1 mg/m’ sulfuric acid aerosols (MMAD 0.5 pm) for 2 hours of alternating 15-minute periods of exercise and rest resulted in a 3.7% depression in FEV, (Kleinman et al. 1981). The investigators indicated that exposure to ozone alone under the same conditions depressed FEV, by about 2.8%. A 3-hour exposure to sulfuric acid (0.107 mg/m’; MMAD 0.64 um) 24 hours before a 3-hour exposure to ozone at 0.08, 0.12, or 0.18 ppm significantly enhanced the effect of ozone in asthmatics (Frampton et al. 1995). An ozone concentration-related response was observed for both FVC and FEV, with the effect observed immediately after exposure for FVC, and 4 hours after exposure for FVC and FEV,. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 103 2. HEALTH EFFECTS Significant deficits in lung function were not observed in 30 young (11-18 years old) asthmatics exposed to sulfuric acid (0.127 mg/m’; MMAD 0.66 um), nitrogen dioxide (0.3 ppm), and ozone (0.2 ppm) for 90 minutes (Linn et al. 1995). The subjects exercised during the exposures. Sulfuric acid as a surface layer on aerosols of zinc oxide was more potent in decreasing the diffusing capacity of carbon monoxide in guinea pigs than sulfuric acid aerosol alone (Amdur 1989b). Some studies indicate that sulfuric acid potentiates the response to ozone. For example, potentiation of ozone has been observed in rats at sulfuric acid concentrations as low as 40 pg/m® (Amdur 1989a). Kimmel et al. (1997) reported a synergistic effect in rats exposed to both sulfuric acid and ozone. The rats were exposed for 4 hours per day for 2 days to 0.6 ppm ozone and 0.5 mg/m?® sulfuric acid with MMDs of 0.3 pum (fine) or 0.06 pm (ultrafine). Exposure to the fine aerosol resulted in significantly increased cell proliferation in the acinar region, an effect not observed with the ultrafine aerosol. Exposure to the ultrafine aerosol resulted in an increase in the volume percentage of markedly-to- severely injured tissue, an effect not observed with the fine aerosol. This study indicates that aerosol size also has a role in determining whether or not an interaction between sulfuric acid and other toxicants will occur. Combined exposure to sulfuric acid and ozone has also been shown not to have any potentiating effects compared to exposure to either substance alone. El-Fawal et al. (1995) exposed rabbits nose- only to both ozone (0.1, 0.3, or 0.6 ppm) and sulfuric acid (MMD 0.3 um; 50, 75, or 125 pg/m®) for 3 hours. After the exposures, sections of bronchi were removed and the responsiveness to acetylcholine was determined in an in vitro assay. The combination of ozone and sulfuric acid reduced the responsiveness to acetylcholine that was observed following ozone exposure alone. The effects of a 4-hour combined exposure of rats to ozone (0.5 ppm), nitric acid (0.7 mg/m?), and sulfuric acid (0.6 mg/m?) were not greater than the effects of a 4-hour ozone exposure (Mautz et al. 1991). Toxicity was assessed through the measurement of breathing patterns, metabolic rates, fatty acid composition of pulmonary surfactant, nasal epithelial injury, oxidant-induced lung parenchymal lesions, and changes in total protein lung in lavage fluid. Compared to results in rats exposed to 5 ppm nitrogen dioxide for 1 day, protein in lavage fluid was significantly increased in rats exposed to both 5 ppm nitrogen dioxide and sulfuric acid at 0.5 mg/m’ ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 104 2. HEALTH EFFECTS for 1 day (MMAD 0.4 um) (Last and Warren 1987). This increased response was not observed after 3 days of exposure. Rats were not exposed to sulfuric acid aerosols alone in this study. Guinea pigs exposed to sulfuric acid at 8 mg/m’ (mean diameter 1 pm) and sulfur dioxide at 89 ppm for 8 hours showed effects that were more severe than those of exposure to either substance alone (Amdur 1954). Body weight gain, lung pathology, and labored breathing were all more severe following the combined exposure, while the study author noted that exposure to either substance alone at the concentrations used was ineffective in producing a respiratory response. To examine the ability of air pollutants to act as a promoter, rats were exposed to nitrogen dioxide (0.4 ppm) and sulfuric acid aerosols (MMAD 0.71 pm; 1 mg/m?) for 13 months followed by an 11-month observation period, with and without pretreatment with a single intraperitoneal injection of N-bis(2-hydroxypropyl) nitrosamine (BHPN; 0.5 g/kg) (Ichinose and Sagai 1992). Nitrogen dioxide exposures were for 24 hours per day, and sulfuric acid aerosol exposures were for 10 hours per day. Treatment with BHPN alone did not result in any tumors, while treatment with nitrogen dioxide and sulfuric acid following BHPN treatment resulted in lung tumors (adenomas and adenocarcinomas) in 3 of 36 rats. This study suggests that the combination of nitrogen dioxide and sulfuric acid can act as a lung tumor promotor. 2.8 POPULATIONS THAT ARE UNUSUALLY SUSCEPTIBLE A susceptible population will exhibit a different or enhanced response to sulfur trioxide and sulfuric acid than will most persons exposed to the same level of sulfur trioxide and sulfuric acid in the environment. Reasons may include genetic makeup, age, health and nutritional status, and exposure to other toxic substances (e.g., cigarette smoke). These parameters may result in reduced detoxification or excretion of sulfur trioxide and sulfuric acid, or compromised function of target organs affected by sulfur trioxide and sulfuric acid. Populations who are at greater risk due to their unusually high exposure sulfur trioxide and sulfuric acid are discussed in Section 5.6, Populations With Potentially High Exposure. Asthmatics are more sensitive to sulfuric acid exposure. One reason for the enhanced sensitivity of asthmatics is that the pH of their mucus is lower (5.37.6) than in normal subjects (7.4-8.2). Therefore, the mucus of asthmatics can absorb fewer hydrogen ions before the pH of the mucus is ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 105 2. HEALTH EFFECTS changed significantly, resulting in pH changes in the surrounding tissue. Lowering the pH of mucus increases its viscosity (Holma 1985), which would decrease mucociliary clearance. Other persons with mucus of low pH would also be more sensitive to sulfuric acid. The mucus of smokers contains higher levels of lysozyme and total protein, and their mucus may also have a lower capacity to neutralize hydrogen ions (Holma 1989). Because mucus production is not fully developed in infants, they may also be more sensitive to sulfuric acid exposure (Holma 1985). In addition to effects on mucus, smokers may be at greater risk of the effects of sulfuric acid exposure because mucociliary clearance is already compromised by smoking (Albert et al. 1971). Other persons with compromised lung function would also be more sensitive to inhalation exposure to sulfuric acid aerosols. 2.9 METHODS FOR REDUCING TOXIC EFFECTS This section will describe clinical practice and research concerning methods for reducing toxic effects of exposure to sulfur trioxide and sulfuric acid. However, because some of the treatments discussed may be experimental and unproven, this section should not be used as a guide for treatment of exposures to sulfur trioxide and sulfuric acid. When specific exposures have occurred, poison control centers and medical toxicologists should be consulted for medical advice. The following texts provide specific information about treatment following exposures to sulfur trioxide and/or sulfuric acid: Bronstein AC, Currance PL. 1988. Emergency Care for Hazardous Materials Exposure; Gosselin RE, Smith RP, Hodge HC. 1984. Clinical Toxicology of Commercial Products; Haddad LM, Winchester H. 1990. Clinical Management of Poisoning and Drug Overdose; Stutz DR, Ulin S. 1992. Hazardous Materials Injuries. 2.9.1 Reducing Peak Absorption Following Exposure Human exposure to sulfur trioxide or sulfuric acid aerosols can occur by inhalation. Moving the subject to fresh air is the best way to reduce exposure to sulfur trioxide and sulfuric acid aerosols following inhalation exposure. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 106 2. HEALTH EFFECTS Human exposure to sulfuric acid can also occur via ingestion or direct contact with the skin or eyes. After ingestion, emesis should not be induced (Ellenhorn and Barceloux 1988), although gastric suction has been recommended (Haddad and Winchester 1990). Dilution with cold water or milk or neutralization with antacids are recommended only if the acid is not concentrated (Gosselin et al. 1984). If the acid is concentrated, dilution will produce considerable heat which may cause further damage to the gastrointestinal tract (Haddad and Winchester 1990). Following direct contact with the skin or eyes, the affected area should be irrigated continuously with water to help alleviate the increase in temperature (Gosselin et al. 1984). Continuous irrigation with saline has also been recommended (Ellenhorn and Barceloux 1988). Dilution of concentrated sulfuric acid with saline may produce less heat than dilution with water. 2.9.2 Reducing Body Burden Sulfur trioxide and sulfuric acid are direct-acting toxicants that do not need to be absorbed into the bloodstream to result in adverse effects. Methods for reducing body burden are not applicable for these direct-acting substances. Preventing sulfuric acid from contacting tissues will prevent the adverse effects of sulfuric acid. 2.9.3 Interfering with the Mechanism of Action for Toxic Effects Because sulfuric acid acts directly on tissues by changing pH, preventing this pH change by dilution or neutralization would reduce or prevent the effects of sulfuric acid. As discussed in Section 2.9.1, dilution must be used with caution if concentrated sulfuric acid is ingested because the heat that is produced could produce additional damage (Haddad and Winchester 1990). 2.10 ADEQUACY OF THE DATABASE Section 104(i)(5) of CERCLA, as amended, directs the Administrator of ATSDR (in consultation with the Administrator of EPA and agencies and programs of the Public Health Service) to assess whether adequate information on the health effects of sulfur trioxide and sulfuric acid is available. Where adequate information is not available, ATSDR, in conjunction with the National Toxicology Program (NTP), is required to assure the initiation of a program of research designed to determine the health ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 107 2. HEALTH EFFECTS effects (and techniques for developing methods to determine such health effects) of sulfur trioxide and sulfuric acid. The following categories of possible data needs have been identified by a joint team of scientists from ATSDR, NTP, and EPA. They are defined as substance-specific informational needs that if met would reduce the uncertainties of human health assessment. This definition should not be interpreted to mean that all data needs discussed in this section must be filled. In the future, the identified data needs will be evaluated and prioritized, and a substance-specific research agenda will be proposed. 2.10.1 Existing Information on Health Effects of Sulfur Trioxide and Sulfuric Acid The existing data on health effects of inhalation, oral, and dermal exposure of humans and animals to sulfur trioxide and sulfuric acid are summarized in Figure 2-4. The purpose of this figure is to illustrate the existing information concerning the health effects of sulfuric acid. Each dot in the figure indicates that one or more studies provide information associated with that particular effect. The dot does not necessarily imply anything about the quality of the study or studies, nor should missing information in this figure be interpreted as a "data need." A data need, as defined in ATSDR’s Decision Guide for Identifying Substance-Specific Data Needs Related to Toxicological Profiles (ATSDR 1989), is substance-specific information necessary to conduct comprehensive public health assessments. Generally, ATSDR defines a data gap more broadly as any substance-specific information missing from the scientific literature. Because sulfur trioxide reacts with water to form sulfuric acid, studies of the health effects of sulfuric acid are applicable to sulfur trioxide. Therefore, a separate figure for the limited studies of sulfur trioxide is not presented. 2.10.2 Identification of Data Needs On contact with water, sulfur trioxide forms sulfuric acid. Therefore, exposure to sulfur trioxide results in effects that are the same as observed following exposure to sulfuric acid. The following discussion on data needs focusses on studies of sulfuric acid. Separate studies of the effects of sulfur trioxide are not needed. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 108 2. HEALTH EFFECTS FIGURE 2-4. Existing Information on Health Effects of Sulfuric Acid SYSTEMIC 2 2 o =z @ 3° © 5 > §° $$ 7 02 SSS SS SSS FEES ES ESE SRS Inhalation ® ° ° oe | eo ™ Oral ° ® Dermal ° ® Human SYSTEMIC N 3° Fo = 2 x oO NN O “oO S/o S/S & StS 32 SAS SL OE ° & oo & QW ® QE co? oo? Inhalation ® ° ° ° ® | eo Oral ° ° } ° Dermal ° Animal ® Existing Studies ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 109 2. HEALTH EFFECTS Acute-Duration Exposure. Sulfuric acid is a direct-acting toxicant, resulting in effects in the tissues with which it comes into contact. There are numerous acute-duration inhalation studies regarding the respiratory effects of sulfuric acid in both asthmatic (Anderson et al. 1992; Aris et al. 1991; Avol et al. 1988, 1990; Fine et al. 1987; Frampton et al. 1995; Hanley et al. 1992; Koenig et al. 1985, 1992, 1993; Linn et al. 1986, 1994; Utell et al. 1983, 1989) and healthy volunteers (Amdur et al. 1952b; Anderson et al. 1992; Avol et al. 1988; Bowes et al. 1995; Culp et al. 1995; Frampton et al. 1992, 1995; Gamble et al. 1984a; Horvath et al. 1987; Knapp et al. 1991; Kulle et al. 1982; Laube et al. 1993; Leikauf et al, 1981, 1984; Linn et al. 1994; Newhouse et al. 1978; Sim and Pattle 1957; Spektor et al. 1989; Stacy et al. 1983; Utell et al. 1984). These studies indicate that asthmatics are more sensitive to respiratory effects following sulfuric acid exposure than healthy subjects. These studies also indicate that aerosol size, relative humidity, and subject factors, including breathing rate and depth, method of breathing (e.g., oral, nasal, oronasal), and respiratory tract ammonia, all influence the response to inhalation of sulfuric acid aerosols. A study on healthy asthmatics demonstrated changes in pulmonary function at a sulfuric acid concentration of 0.45 mg/m’, but not 0.1 mg/m’ (Utell et al. 1983). Accidental acute oral exposure of humans to concentrated sulfuric acid indicates that it is highly corrosive to the gastrointestinal tract (Aktug et al. 1995; Dilawari et al. 1984). Dermal corrosions result when the skin of humans comes into contact with sulfuric acid of sufficient concentration (Branday et al. 1996; Schultz et al. 1968). In an experimental study, no skin effects were observed when 10% sulfuric acid was placed on the skin of volunteers (Nixon et al. 1975). There are numerous acute-duration inhalation studies in animals regarding the respiratory effects of sulfuric acid (Amdur 1958, 1959; Amdur et al. 1952a, 1978; Cavender et al. 1977; Chen et al. 1992a, 1992b; Cockrell et al. 1978; El-Fawal and Schlesinger 1994; Grose et al. 1982; Kobayashi and Shinozaki 1993; Lee et al. 1995; Mannix et al. 1991; Schlesinger 1990a; Schlesinger and Gearhart 1986; Schlesinger et al. 1984, 1990b; Stengel et al. 1993; Warren and Last 1987; Wolff et al. 1979: Zelikoff and Schlesinger 1992; Zelikoff et al. 1994). These studies indicate that guinea pigs are the most sensitive species and that the measurement of mucociliary clearance of tracer particles is a more sensitive technique than pulmonary function tests. Studies in animals also indicate that the effects of inhalation of sulfuric acid aerosols are dependent on aerosol size. Acute-duration oral studies concerning the concentration of sulfuric acid required to cause gastrointestinal tract effects were not “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 110 2. HEALTH EFFECTS identified. A 14-day study of chicks fed sulfuric acid in the diet revealed that by this route of exposure sulfuric acid was relatively well tolerated (Capdevielle and Scanes 1995b). Acute-duration dermal studies of sulfuric acid do not agree on the concentration that results in dermal effects. One study reported erosion of the skin at 10% with no effects at 2.5% (Sekizawa et al. 1994), while another study reported no dermal effects at 10% (Nixon et al. 1975). Following direct application of sulfuric acid to the eyes of animals, one study reported severe corneal opacities at 10% with minimal effects at 5% (Murphy et al. 1982), while a second study reported no effects at 10% (Jacobs 1992). Although there are numerous acute-duration inhalation studies of sulfuric acid in both humans and animals, an acute-duration MRL was not derived. An MRL was not derived because the methodology for derivation does not incorporate all the variables in addition to concentration that determine the response to sulfuric acid. Rather than additional acute-duration inhalation studies, additional work regarding methodology for developing MRLs for hygroscopic aerosols and acute inhalation irritants is needed. Further development of models that examine the effect of changing aerosol size on the deposition of sulfuric acid aerosols in the lungs (Martonen and Patel 1981; Martonen and Zhang 1993) would also be useful for development of an acute-duration inhalation MRL. Data are not sufficient for the development of an acute-duration oral MRL for sulfuric acid. Additional studies to determine the concentration of sulfuric acid that can be tolerated by the gastrointestinal tract would be of value to poison control centers. Additional dermal and ocular studies that clarify the threshold sulfuric acid concentration resulting in skin and eye irritation are needed. Intermediate-Duration Exposure. There are no intermediate-duration inhalation, oral, or dermal studies of sulfuric acid in humans. Respiratory effects have been studied in animals following intermediate-duration inhalation exposure. The focus of these studies has been histopathological changes in the respiratory tract (Cavender et al. 1977; Thomas et al. 1958) and clearance of test particles (Schlesinger and Gearhart 1986; Schlesinger et al. 1979, 1992a). The only intermediate- duration oral study is a 15-day study in which no systemic (growth, liver, kidney, endocrine) effects were observed in ducklings fed sulfuric acid in the diet (Capdevielle and Scanes 1995a). No intermediate-duration dermal studies in animals were identified. The data are not sufficient for developing an intermediate-duration inhalation MRL. A study that examines pulmonary function in persons occupationally exposed to sulfuric acid, in which the exposure conditions are well defined (e.g., concentrations, aerosol size, relative humidity), is needed. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 111 2. HEALTH EFFECTS This study should examine changes in pulmonary function over time, including intermediate-duration exposure. Data are not sufficient for the development of an intermediate-duration oral MRL for sulfuric acid. Additional acute studies that clarify the threshold sulfuric acid concentration resulting in direct irritation of the gastrointestinal tract, skin, and eyes, should also identify thresholds that would be protective for intermediate-duration exposure. Chronic-Duration Exposure and Cancer. Chronic occupational exposure to sulfuric acid aerosols has been associated with a small decrease in FVC (Gamble et al. 1984b), increased reports of bronchitis (Kitagawa 1984; Williams 1970), increased tooth erosion (El-Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961), and an increase in periodontal pockets (Tuominen 1991). No chronic-duration studies were identified regarding the effects of sulfuric acid in humans following oral or dermal exposure. The only animal studies that examine a wide range of systemic effects in addition to respiratory effects (cardiovascular, hematological, hepatic, renal, body weight) are chronic studies in cynomolgus monkeys (Alarie et al. 1973) and guinea pigs (Alarie et al. 1973, 1975). The effects noted in these studies were histopathological changes in the lungs of monkeys at 4.79 mg/m* (MMD 0.73 um) and 0.38 mg/m’ (MMD 2.15 pm). At a concentration of 2.43 mg/m’ (MMD 3.6 um) histopathological changes were observed in the alveoli as well as the bronchioles in exposed monkeys, and a decrease in arterial oxygen was also observed. No effects, including histopathological changes in the respiratory tract, were observed in guinea pigs who were exposed to a maximum concentration of 0.9 mg/m’ (MMD 0.49 pm) (Alarie et al. 1975). Although these studies clearly report effects that were treatment-related, data for end points that did not show treatment-related effects, for example liver enzyme data, were not reported. Increased bronchial sensitivity to acetylcholine (Gearhart and Schlesinger 1986) and decreased clearance of test particles (Schlesinger et al. 1992a) were reported following a 1-year exposure of rabbits to sulfuric acid aerosols. No chronic-duration studies were identified regarding the effects of sulfuric acid in animals following oral or dermal exposure. The data are not sufficient for developing a chronic-duration inhalation MRL. A study that examines pulmonary function in persons occupationally exposed to sulfuric acid for chronic durations, in which the exposure conditions are well defined (e.g., concentrations, aerosol size, relative humidity), is needed. This study should examine changes in pulmonary function over time and should include chronic-duration exposure. Data are not sufficient for the development of a chronic-duration oral “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 112 2. HEALTH EFFECTS MRL for sulfuric acid. Additional studies that clarify the threshold sulfuric acid concentration resulting in direct irritation of the gastrointestinal tract, skin, and eyes, should also identify thresholds that would be protective for chronic-duration exposure. Occupational exposure to mineral acid aerosols containing sulfuric acid has been associated with the development of respiratory tract cancers, especially laryngeal and lung cancers (Alderson and Rattan 1980; Beaumont et al. 1987; Coggon et al. 1996; Forastiere et al. 1987; Houghton and White 1994; Soskolne et al. 1984, 1992; Steenland and Beaumont 1989; Steenland et al. 1988). However, most of the cancers were in smokers who were also exposed to other chemicals. There is no information that exposure to sulfuric acid by itself is carcinogenic, and there are no clear data on exposure concentrations of sulfuric acid associated with cancer in humans. Environmental exposure of humans to sulfuric acid has not been associated with cancer (Abbey et al. 1995). The carcinogenicity of sulfuric acid alone has not been studied in animals after exposure by any route. Combined sulfuric acid and nitrogen dioxide exposure has been shown to act as a promoter of lung tumors in rats (Ichinose and Sagai 1992). Based on the limited human data, which associate occupational exposure to sulfuric acid aerosols with the development of lung and laryngeal cancers, IARC (1992) considers occupational exposure to strong-inorganic-acid mists containing sulfuric acid carcinogenic to humans (Group 1). The DHHS (1994) and EPA have not classified sulfuric acid for carcinogenic effects. Because repeated irritation of the lungs by sulfuric acid exposure is likely to act as a promoter, and because sulfuric acid exposure generally occurs in the presence of other pollutants, further research on the ability of sulfuric acid aerosols to act as a promoter is needed. The carcinogenicity of sulfuric acid has not been studied after exposure by any other route. Because chronic-duration oral and dermal exposure to irritating concentrations of sulfuric acid is unlikely, cancer studies following exposure by these routes are not needed. Genotoxicity. In vivo studies regarding the genotoxicity of sulfuric acid were not identified. Sulfuric acid did not increase gene mutation in bacteria (Cipollaro et al. 1986; Demerec et al. 1951). Increases in chromosomal aberrations were observed in root meristimatic tissue of the plant Vicia faba (Zura and Grant 1981), in Chinese hamster ovary cells (Morita et al. 1989), and in sea urchins (Cipollaro et al. 1986) exposed to sulfuric acid. Other in vitro studies in which pH was adjusted with other acids indicate that acidic pH is genotoxic, resulting in chromosomal anomalies in human lymphocytes (Shimada and Ingalls 1975) and mouse lymphoma cells (Cifone et al. 1987) and a ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 113 2. HEALTH EFFECTS transformed-like morphology in Syrian hamster cells (LeBoeuf and Kerckaert 1986). Further studies regarding the mechanism of genotoxic effects following exposure to low pH are needed. Reproductive Toxicity. Reproductive effects following exposure to sulfuric acid by any route have not been studied in humans. No significant effects on the mean numbers of implants/dam or resorptions/litter were noted in mice or rabbits exposed by inhalation to sulfuric acid aerosols during gestation (Murray et al. 1979). Changes in testes weight were not observed in chicks (Capdevielle and Scanes 1995b) or ducklings (Capdevielle and Scanes 1995a) fed sulfuric acid in the diet. No additional studies were identified regarding reproductive effects of sulfuric acid in animals following exposure by any route. Because inhalation of sulfuric acid aerosols is the most common route of exposure, a reproductive study in animals exposed by inhalation is needed. Developmental Toxicity. The developmental effects of sulfuric acid have not been studied in humans by any route of exposure. No significant effects were observed on fetal body weights or on the incidence of major or minor malformations in mice or rabbits exposed by inhalation to sulfuric acid aerosols during gestation (Murray et al. 1979). Because sulfuric acid is a direct-acting toxicant, and because it is unlikely to reach developing mammals, developmental effects in mammals are not likely following exposure to sulfuric acid by any route. Therefore, additional developmental toxicity studies of sulfuric acid are not needed at this time. Immunotoxicity. The function of alveolar macrophages collected from humans following inhalation exposure to sulfuric acid aerosols for 2 hours was not affected (Frampton et al. 1992). Immunological effects have not been studied in humans following exposure by other routes. Alveolar macrophage function has been shown to be affected in animals following inhalation exposure to sulfuric acid aerosols (Chen et al. 1992a, 1995; Schlesinger et al. 1992b; Zelikoff and Schlesinger 1992). The effects on alveolar macrophage function were not concentration related. Once a critical level of sulfuric acid was reached, no further effects were observed. Effects were greater following exposure to smaller sized aerosols (MMD 0.04 pm versus 0.3 pm), leading Chen et al. (1992a) to suggest that the smaller droplets deliver a higher dose to the macrophages than the larger droplets. Inhalation exposure to sulfuric acid aerosols has also been shown to enhance antigen-induced histamine release from mast cells collected from exposed guinea pigs (Fujimaki et al. 1992). Mice challenged with Streptococcus pyrogens directly after ultrafine sulfuric acid aerosol (2 hours/day for 5 days) exposure did not experience increased mortality (Grose et al. 1982). Additional studies regarding susceptibility “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 114 2. HEALTH EFFECTS of animals to respiratory infections (bacterial, viral) following intermediate- and chronic-duration exposure to sulfuric acid exposure are needed. Immunological and lymphoreticular effects have not been studied following oral or dermal exposure to sulfuric acid. Because sulfuric acid is a direct-acting toxicant, system-wide effects on the immune system are not likely following exposure to sulfuric acid by any route. Neurotoxicity. Fatigue and headaches were reported more frequently in asthmatic volunteers when they were exposed to sulfuric acid aerosols (Avol et al. 1988). Neurological effects have not been studied following oral or dermal exposure of humans or animals by any route of exposure. Because sulfuric acid is a direct-acting toxicant, neurological effects other than subjective symptoms associated with irritation and pulmonary function changes are not likely following exposure to sulfuric acid by any route. Studies of neurological effects following sulfuric acid exposure are not needed at this time. Epidemiological and Human Dosimetry Studies. Increased mortality, especially of elderly persons and those with preexisting cardiac and respiratory disease, has been reported during or shortly after air pollution episodes (reviewed in Costa and Amdur 1996). In general, increased mortality in these studies correlates more closely with particulate matter, including sulfuric acid aerosols. In a study that tried to distinguish the effects of sulfuric acid aerosols from those of sulfur dioxide and of British smoke (a measure of particulates), the log of sulfuric acid aerosol concentrations in London was more strongly correlated with total mortality than that of sulfur dioxide or British smoke (Thurston et al. 1989). The authors of the study concluded that their study was consistent with the hypothesis that sulfuric acid is the portion of the particulate mass with the greatest health significance. An association between mortality and environmental sulfate concentrations was not observed among 6,340 non-smoking persons living in California (Abbey et al. 1995). An increase in asthma symptoms has been associated with increases in environmental sulfate concentrations (Abbey et al. 1993, 1995). Overall mortality of workers was not associated with acid exposure at steel factories (Beaumont et al. 1987) or at a sulfuric acid plant (Englander et al. 1988). Additional studies that examine environmental sulfuric acid concentration and death and respiratory effects in humans would be useful if exposure to other pollutants is taken into consideration. Occupational exposure to mineral acid aerosols including sulfuric acid has been associated with the development of respiratory tract cancers, especially laryngeal and lung cancers (Alderson and Rattan ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 115 2. HEALTH EFFECTS 1980; Beaumont et al. 1987; Coggon et al. 1996; Forastiere et al. 1987; Houghton and White 1994; Soskolne et al. 1984, 1992; Steenland and Beaumont 1989; Steenland et al. 1988). However, most of the cancers were in smokers who were also exposed to other chemicals. There is no information that exposure to sulfuric acid by itself is carcinogenic, and there is no clear data on exposure concentrations of sulfuric acid associated with cancer in humans. Additional studies of cancer in persons occupationally exposed to sulfuric acid aerosols, especially in a population with detailed exposure information, are needed. Exposure models for sulfate and hydrogen ion have been developed to provide better predictions of human exposure compared to outdoor air concentrations alone (Suh et al. 1993). When the sulfate model was compared to actual personal exposure data, it was found that sulfate exposure could be adequately predicted by the outdoor concentration, activity of the person, and knowledge about air conditioning. The hydrogen ion model included a neutralization term and was better at predicting personal exposure when indoor air concentrations of hydrogen ion and personal ammonia levels were also included. Because of the importance of personal ammonia levels for predicting hydrogen ion exposure, and because of similar difficulties in measuring personal ammonia and hydrogen ion concentrations, the study authors suggested that direct measurement of personal hydrogen ion exposure may be the only method to accurately determine personal hydrogen ion exposure. Additional studies that examine personal exposure to sulfuric acid are needed to determine the relationship between ambient exposure concentrations and personal exposures. Biomarkers of Exposure and Effect Exposure. There are no established biomarkers of exposure for sulfur trioxide or sulfuric acid. The pH of saliva is decreased in persons occupationally exposed to sulfuric acid (El-Sadik et al. 1972). The pH of respiratory mucus may also decrease following inhalation exposure to sulfuric acid (Holma 1985). Additional research examining the relationship between sulfuric acid exposure concentration and saliva pH may be useful. Effect. Changes in pulmonary function tests following acute inhalation exposure of humans to sulfuric acid (Avol et al. 1988; Hanley et al. 1992; Koenig et al. 1985, 1992; Utell et al. 1984), and tooth etching following occupational exposure to sulfuric acid, have been reported (El-Sadik et al. 1972; Gamble et al. 1984b; Malcolm and Paul 1961). These effects are not unique to sulfuric acid exposure, ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 116 2. HEALTH EFFECTS and clear concentration—response relationships have not been established for these effects. Because the effects of sulfuric acid exposure are dependent on many factors in addition to concentration, including aerosol size, relative humidity, and breathing factors, a population-based concentration-response relationship for these effects would be difficult to establish. Absorption, Distribution, Metabolism, and Excretion. Sulfuric acid inhaled by humans is retained by the lungs (Amdur et al. 1952b). The regional deposition of sulfuric acid in the lungs is determined by aerosol size as well as the method (oral, nasal, oronasal) and rate of breathing (Bowes et al. 1995). The effect of hygroscopic growth within the respiratory tract on the deposition of sulfuric acid aerosols has been modeled in adults (Martonen and Patel 1981) and children (Martonen and Zhang 1993). Excess sulfate is excreted in the urine (Vander et al. 1975). Sulfur from instilled sulfuric acid is readily absorbed from the lungs but poorly absorbed from the nose of dogs (Dahl et al. 1983). Additional studies and/or models regarding the deposition of sulfuric acid aerosols in the lungs are needed. Because sulfuric acid is a direct-acting toxicant, additional studies regarding absorption into the bloodstream, distribution within the body, metabolism, and excretion would not provide insight into the toxic effects of sulfuric acid. Comparative Toxicokinetics. Models that compare the deposition of sulfuric acid aerosols in various species were not identified. Additional models that examine the effect of aerosol size and of hygroscopic growth within the respiratory tract are needed to examine the effects of sulfuric acid aerosols in the various species tested. Methods for Reducing Toxic Effects. The toxicity of sulfuric acid can be reduced or prevented if the acid is neutralized or diluted (Gosselin et al. 1984). Further research regarding the best first aid method to dilute sulfuric acid is necessary. Water generates heat; saline or another solution may generate less heat and leave less tissue damage. 2.10.3 Ongoing Studies Dockery at Harvard University is continuing his research concerning the adverse effects of acid aerosols including sulfuric acid on urban populations (CRISP 1996). Additional ongoing studies regarding the health effects of sulfur trioxide and sulfuric acid were not identified. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 117 3. CHEMICAL AND PHYSICAL INFORMATION 3.1 CHEMICAL IDENTITY Information regarding the chemical identity of sulfur trioxide, sulfuric acid, and oleum (fuming sulfuric acid) is located in Table 3-1. The acid strength of sulfuric acid is designated as percentage sulfuric acid or degrees Baumé (°B¢) (IARC 1992). Degrees Baumé is a mathematical relationship with specific gravity (Bé = 145- [145/specific gravity]) that is consistent at concentrations below 93.2% sulfuric acid. At higher concentrations, the acid is referred to in terms of percentage sulfuric acid. The strength of oleum is indicated by the percentage of free dissolved sulfur trioxide, or as the equivalent percentage of 100% sulfuric acid. 3.2 PHYSICAL AND CHEMICAL PROPERTIES Information regarding the physical and chemical properties of sulfur trioxide, sulfuric acid, and oleum (fuming sulfuric acid) is located in Table 3-2. ***DRAFT FOR PUBLIC COMMENT*** «++LNJWWOD O1718Nd HOH 14VHQA... Table 3-1. Chemical Identity of Sulfur Trioxide, Sulfuric Acid, and Oleum Characteristic Sulfur trioxide Sulfuric acid Oleum Reference Synonyms Sulphur trioxide, sulfuric Sulphine acid; battery Fuming sulfuric acid; HSDB 1997; oxide; sulfur oxide; sulfuric acid; hydrogen sulfate; disulphuric acid; IRIS 1996 anhydride oil of vitriol; dithionic acid; dihydrogen sulfate; pyrosulphuric acid BOV; and others Registered trade name(s) Sulfan® No data No data HSDB 1997 Chemical formula SO, H,SO4 H,SO, with free SO, HSDB 1997 Chemical structure Identification numbers: CAS registry 7446-11-9 7664-93-9 8014-95-7 HSDB 1997 NIOSH RTECS WT4830000 WS5600000 WS5605000 HSDB 1997 EPA hazardous waste No data No data No data OHM/TADS No data 7216915 No data DOT/UN/NA/IMCO UN1829, UN1830(<65.25%), UN1831, IMO 8.0 HSDB 1997 shipping IMO 8.0 (inhibited), UN1832 (spent), IMO 2.0 (uninhibited) IMO 8.0 HSDB 6338 1811 1236 HSDB 1997 NCI No data No data No data CAS = Chemical Abstracts Service; DOT/UN/NA/IMCO = Department of Transportation/United Nations/North America/International Maritime Dangerous Goods Code; EPA = Environmental Protection Agency; HSDB = Hazardous Substances Data Bank; NCI = National Cancer Institute; NIOSH = National Institute for Occupational Safety and Health; OHM/TADS = Oil and Hazardous Materials/Technical Assistance Data System; RTECS = Registry of Toxic Effects of Chemical Substances NOILYWHOSNI TVOISAHd ANV TVOIW3HO '€ aiov 21dN4INS ANY 3aIX0oldL ’UN4Ins 8h ++ LNIWWOD O178Nd HOH 14VHOuss Table 3-2. Physical and Chemical Properties of Sulfur Trioxide, Sulfuric Acid, and Oleum Property Sulfur trioxide Sulfuric acid Oleum Reference Molecular weight 80.07 98.08 178.14 HSDB 1997 Color Colorless (liquid); asbestos- Colorless to dark colorless or slightly NIOSH 1994b like needles (a, PB); ice- brown, oily colored like moss (Y) Physical state Gas, liquid, or solid liquid heavy, oily liquid NIOSH 1994b Melting point 16.8°C (ay); 62.4°C (B) 10.36°C No data HSDB 1997 Boiling point 44.8°C (0); 50°C (B) 290°C No data HSDB 1997 Density -357 g/L at 0°C, 1.92 g/cm’ 1.841 114.70 Ib/fe HSDB 1997 at 20°C, 2.29 g/cm’ at -10°C Odor No data Odorless No data HSDB 1997 Odor threshold: Water No data No data No data Air No data Low: 1.0 mg/m’, No data IARC 1992 high: 1.0 mg/m’; irritating: 1.10 mg/m’ Solubility: Water at 0°C No data No data No data Water at 20°C No data No data No data Water at 25°C No data No data No data Organic solvent(s) No data Watery, ethyl alcohol No data HSDB 1997 Partition coefficients: Log K,,, No data No data No data Log K,. No data No data No data Vapor pressure 73 mm Hg at 25°C (a); 1 mm Hg at 145.8°C No data HSDB 1997 344 mm Hg at 25°C (B) Henry’s law constant No data No data No data Autoignition temperature No data No data No data Flashpoint No data No data No data Flammability limits No data No data No data Conversion factors 1 ppm = 0.31 mg/m’ 1 ppm = 4.08 mg/m’ No data NIOSH 1994b NOILYWHOSNI TVOISAHd ANV TVOIN3HO ‘€ aidy J1dN4INS ANY 3aIXOldL HN4INs 611 «+LNIWWOD OI78Nd HOH 14vHQ... Table 3-2 (continued) Property Explosive limits Sulfur trioxide No data Sulfuric acid No data Oleum No data Reference HSDB 1997 NOILYWHOCNI TVOISAHd ANY TVOIN3HO ‘€ aiov J1HN4TINS ANY 3AIXOldL JN4INS oct SULFUR TRIOXIDE AND SULFURIC ACID 121 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL 4.1 PRODUCTION Table 4-1 lists the facilities in each state that manufacture or process sulfuric acid, the intended use, and the range of maximum amounts of sulfuric acid that are stored on site. The data listed in Table 4-1 are derived from the Toxics Release Inventory (TRI) (TRI94 1996). Only certain types of facilities were required to report. Therefore, this is not an exhaustive list. According to the 1994 TRI, 3,769 facilities in the United States and 28 facilities in the Commonwealth of Puerto Rico manufac- tured or processed sulfuric acid in 1994 (TRI94 1996). Similar data were not available for sulfur trioxide. Because sulfur trioxide is produced as a precursor to sulfuric acid in the principal method of producing sulfuric acid, sulfur trioxide is likely to be present at the facilities listed in Table 4-1. From 1972 until 1993, the quantity of sulfuric acid produced in the United States increased, 2.83x107 metric tons were produced in 1972, 2.94x10” metric tons were produced in 1975, and 3.60x107 metric tons were produced in 1985. Production from 1990 to 1993 varied from 2.99x10’ metric tons to 3.35x10’ metric tons. In 1995, sulfuric acid was the most produced chemical in the United States at 3.56x10” metric tons which was a significant increase over 1994 production (3.34x10’ metric tons) (C&EN 1996). There are two major processes that have been used to produce sulfuric acid, the chamber process and the contact process. The chamber process was once the predominant method for sulfuric acid production in North America and western Europe; however, its use in these regions has dropped from 80% in 1910 to 15% in 1960 to virtually zero (IARC 1992). In the chamber process, sulfur dioxide is oxidized to sulfur trioxide, which combines with water vapor to form sulfuric acid in the following way: 2NO + O, = 2 NO,, 2 NO,+ 2 SO, + 2H,0 — 2H,SO, + 2NO. Nitrogen dioxide acts as the oxidant. The end products of this process are sulfuric acid and nitrogen oxides. With this process, sulfuric acid of a concentration of about 78% can be produced. Sulfuric acid can also be produced by the contact process. This process is based on technology that was developed around 1900 and has become the primary method of sulfuric acid production ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 122 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL Table 4-1. Facilities That Manufacture or Process Sulfuric Acid Range of maximum amounts on site Number of in thousands State” facilities of pounds ® Activities and uses ° AK 5 10-10000 1,2,3,6,13 AL 84 0-50000 1,2,3,4,5,6,7,8,11,12, 13 AR 58 1-10000 1,3,4,5,6,7,8,11,12, 13 AZ 43 0-100000 1,2,3,5,7,8,10, 11,12, 13 CA 355 0-50000 1,2,3,4,56,7,8,9,10, 11,12, 13 CO 39 0-1000 2,3,4,7,9,10, 11,12, 13 CT 60 0-1000 1,3,5,7,8,9,11,12,13 DC 1 10-100 13 DE 13 1-100000 1,2,3,4,7,8,9, 10,11, 12,13 FL 93 0-500000 1,2.3.4,5.6,7.8,9,10, 11,12. 13 GA 149 0-50000 1,2,3,4,5,6,7,8,9,10, 11,12, 13 HI 5 0-1000 1.3.9.12.13 1A 54 0-10000 1,3,4,57,8,10, 11,12, 13 1D 13 1-50000 1.3.7, 11.12. 13 IL 249 0-50000 1,2,3,4,56,7,8,9, 10, 11,12, 13 IN 146 0-10000 1,2,3,4,5,6,7,8,9, 10,11, 12,13 KS 43 1-100000 1,4,5,7,8,9, 10, 11,12, 13 KY 84 0-50000 1,2,3,4,5,6,7,8,9,10, 11,12, 13 LA 79 0-1000000 1.2.3,4,5.6,7,.8,9,10, 11, 12.13 MA 110 0-10000 1,2,3,5,7,8,9, 10, 11, 12,13 MD 3 1-50000 1,2,3,4,5,7, 8,10, 11,12, 13 ME 24 0-1000 1,5,6,7,11, 12,13 MI 160 0-10000 1,2,3,5,6,7,8,9,10, 11,12, 13 MN 55 0-1000 1,2,3,5,6,7,8,9,10, 11,12, 13 MO 90 0-50000 1,2,3,4,5,7,8,9,10, 11,12, 13 MS 49 1-50000 1,2,3,4,5,6,7,8,9,10, 11,12, 13 MT 5 1-50000 1,4,5 11,12, 13 NC 127 0-100000 1.2,3,4,5,6,7.8,9,11,12,13 ND 6 1-100000 2,3,7,8,11,12,13 NE 28 1-1000 2,3,7,8,9 11,12, 13 NH 22 0-1000 1,5,6,7,10, 11, 12, 13 NJ 102 0-50000 1,2,3,4,5,7,8,9,10, 11,12, 13 NM 1 1-500000 1. 4,5, 11,12, 13 NV 8 10-1000 1,5,7,10, 11,12, 13 NY 140 0-10000 1,2,3,4,5,6,7,8,9,10, 11,12, 13 OH 203 0-50000 1,2,3,4,5,6,7,8,9,10, 11,12, 13 OK 41 0-50000 1,2,3,4,5,6,7,8,10, 11,12, 13 OR 46 0-1000 1,5,6,7,8,9, 11,12, 13 “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 123 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL Table 4-1. Facilities That Manufacture or Process Sulfuric Acid (continued) Range of maximum amounts on site Number of in thousands State® facilities of pounds ® Activities and uses © PA 172 0-50000 1,2,3,4,56,7,8,9,10, 11,12, 13 PR 28 0-10000 1,3,4,6,7,8, 11,12, 13 RI 24 0-1000 2,3,7,8,10,11,12, 13 SC 93 0-10000 1.2.3.5,6.7.8.9,10, 11,12, 13 SD 1 10-100 13 TN 107 0-100000 1,2,3,4,5/6,7,8,9,10, 11, 12, 13 ™> 202 0-100000 1,2.3,4,56,7,.8,9.10,11, 12, 13 uT 32 1-500000 1,3,4,7,8,10, 11,12, 13 VA 62 0-50000 1,2,3,4,56,7,8,10, 11,12, 13 Vi 2 1000-50000 1.2.3,12,.13 VT 6 1-10000 1,5,8,9 12,13 WA 61 1-10000 1,2,3,4,5,6,7,8,9, 10, 11, 12, 13 wi 142 0-100000 1,5,6,7,8,9 10, 11, 12, 13 wv 28 1-10000 1,3,7,8,11,12,13 WY 6 1-10000 7.3,4.7.8, 71,12. 13 Source: TRI94 1996 * Post office state abbreviations used ® Data in TRI are maximum amounts on site at each facility © Activities/Uses: 1. Produce 2. Import 3. For on-site use/processing 4. For sale/distribution 5. As a by-product 6. As an impurity 7. As a reactant 8. As a formulation component 9. As a product component 10. For repackaging only 11. As a chemical processing aid 12. As a manufacturing aid 13. Ancillary or other uses “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 124 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL (IARC 1992). The principal steps in the contact process are (1) oxidation of sulfur to sulfur dioxide with dry air, (2) cooling of the gases, (3) conversion or oxidation of the sulfur dioxide to sulfur trioxide, (4) cooling of the sulfur trioxide gas, and (5) absorption of the sulfur trioxide in water to produce sulfuric acid. The heart of the contact process is the converter in which sulfur dioxide is converted catalytically to sulfur trioxide. A variety of catalysts can be used including platinum, oxides of iron, chromium, copper, manganese, titanium, vanadium, and other metals. Presently, vanadium catalysts in various forms are most widely used. Current methods allow for conversion rates as high as 99.5-99.7% (IARC 1992). Sulfuric acid is most commonly marketed in four grades: commercial, electrolyte (high purity for batteries), textile (low organic content), and chemically pure or reagent grades (IARC 1992). Fuming sulfuric acid (oleum) is produced at contact process plants in special towers by adding sulfur trioxide to sulfuric acid (IARC 1992). 4.2 IMPORT/EXPORT Import/export data for the 1990s indicate that the United States imports more sulfuric acid and fuming sulfuric acid (oleum) than it exports. During 1990-1994, U.S. imports of sulfuric acid and fuming sulfuric acid in million metric tons were 1.7, 1.8, 2, 2.4, and 2.1 in 1990, 1991, 1992, 1993, and 1994, respectively (NTDB 1996). Import data for 1995 were not available. During 1991-1995, U.S. exports of sulfuric acid and fuming sulfuric acid in metric tons were 147,470, 139,790, 144,865, 136,874, and 170,201 in 1991, 1992, 1993, 1994, and 1995, respectively (NTDB 1996). 4.3 USE Sulfur trioxide is primarily used as an intermediate in the production of sulfuric acid. It is also used for sulfonation in the formation of additional compounds with amines and in the manufacture of explosives (Budavari 1989). Sulfur trioxide can also be used in the sulfonation of organic compounds (especially non-ionic detergents), as a component of solar energy collectors, and as a powerful but indiscriminate oxidizing agent (HSDB 1996). In the United States, the main use of sulfuric acid is in phosphate fertilizer production where it used to convert phosphate rock to phosphoric acid (IARC 1992). Sulfuric acid is consumed in the production ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 125 4. PRODUCTION, IMPORT/EXPORT, USE, AND DISPOSAL of fertilizer, while in many other uses the sulfuric acid can be recovered and reused. Sulfuric acid is also used in the manufacture of explosives, dyestuffs, other acids, parchment paper, glue, purification of petroleum, and the pickling of metals (Budavari 1989; IARC 1992). It is also used in electroplating baths, nonferrous metallurgy, in the production of rayon and film, as a laboratory reagent and etchant, and in storage batteries (HSDB 1996). Sulfuric acid is also a general purpose food additive (HSDB 1996). In the United States in 1988, the percentages of sulfuric acid used in various processes were estimated as 68% for phosphate fertilizers; 7% for petroleum refining; 4% for ore processing; 3.5% for industrial organic chemicals; 2.5% for synthetic rubber and plastics; 2.5% for pulp and paper; and 9% for other unidentified uses (IARC 1992). 4.4 DISPOSAL Spent sulfuric acid can often be reprocessed to obtain a product of virgin quality. Enormous amounts of spent sulfuric acid are reprocessed since most of the sulfuric acid used for industrial processes acts only as a reagent and does not form part of the final product. One exception to this is the fertilizer industry (IARC 1992). It has been suggested that waste sulfuric acid can also be recycled using sulfate-reducing bacteria to produce hydrogen sulfide (Stucki et al. 1993). It is not recommended that sulfuric acid or sulfur trioxide be placed in a landfill. Environmental regulatory agencies should be consulted for acceptable disposal practices (HSDB 1996). Sulfuric acid has been disposed of by being placed in sealed containers and by being absorbed in vermiculite, dry sand, or earth. Sulfuric acid may also be neutralized and diluted. One method of neutralization is to add the acid slowly to a solution of soda ash and slaked lime, and to then flush with a large volume of water. Once sulfuric acid is neutralized and diluted with a large volume of water, it can be discharged to a sewer. When diluting sulfuric acid, the acid should always be added to a large volume of water because the heat released when a small bolus of water is added to sulfuric acid can cause the water to turn to steam, and the resulting effervescence can splatter the acid. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 127 5. POTENTIAL FOR HUMAN EXPOSURE 5.1 OVERVIEW Sulfuric acid is a common chemical that is widely used in industry and is found in consumer products (e.g., car batteries, cleaning products). In the United States sulfuric acid is ranked number one in terms of production volume. Sulfur trioxide is a precursor to the production of sulfuric acid, and oleum (fuming sulfuric) acid is sulfur trioxide dissolved in sulfuric acid. Sulfur trioxide and sulfuric acid are sometimes released to the environment during production and use. Sulfur dioxide released during the burning of fossil fuels is also a major source of atmospheric sulfuric acid. In the atmosphere, sulfuric acid is generally in the form of small droplets, or it is adsorbed onto small particles. Sulfuric acid leaves the air through both dry and wet deposition processes. Because of its widespread use, and the widespread release of sulfur dioxide, the potential for human exposure to sulfuric acid is substantial. Sulfuric acid has been found in at least 47 of the 1,430 current or former EPA National Priorities List (NPL) hazardous waste sites (HazDat 1996). The frequency of these sites within the United States can be seen in Figure 5-1. 5.2 RELEASES TO THE ENVIRONMENT According to the TRI, in 1994, releases of sulfuric acid to the environment from 3,775 large processing facilities totalled 11,634,922 kg (25,855,382 pounds) (TRI94 1996). Table 5-1 lists ranges of the amounts released from these facilities. The TRI data should be used with caution because only certain types of facilities are required to report. This is not an exhaustive list. 5.2.1 Air According to the TRI, in 1994, releases of sulfuric acid to the air from 3,775 large processing facilities totalled 10,630,632 kg (23,623,627 pounds) (TRI94 1996). Table 5-1 lists amounts released from these facilities. The TRI data should be used with caution because only certain types of facilities are required to report. This is not an exhaustive list. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 128 5. POTENTIAL FOR HUMAN EXPOSURE Frequency of NPL Sites With Sulfuric Acid Contamination ™N = © 0 Voor a w ii} TT Mn ~ wd ~__ NE * Derived from HazDat 1995 Figure 5-1. ***DRAFT FOR PUBLIC COMMENT*** ++ LNFWNOD O1718Nd HOH L4VHO.ux Table 5-1. Releases to the Environment from Facilities That Manufacture or Process Sulfuric Acid Range of reported amounts released in pounds per year * , umbel of Underground Total POTW Off-site State facilities Alr Water Land injection environment transfer waste transfer AK 5 0-120800 0-120000 0 0-5 0-125500 0-37850 0 AL 84 0-380000 0-5 0 0 0-380000 0-18400 0-446000 AR 58 0-131700 0-5 0-5 0 0-131700 0-11200 0-43000000 AZ 43 0-176400 0 0-5 0 0-176400 0-79000 0-87175 CA 355 042550 0-5 0-16767 0 0-42550 0-422760 0-1733500 CO 39 0-1135 0-5 0 0 0-1135 0-46765 0-103031 CT 60 0-7000 0 0 0 0-7000 0-79100 0-563859 DC 1 0 0 0 0 0 0 0 DE 13 0-19250 0 0 0 0-19250 0 0 FL 93 0657105 0 0-96000 0 0-657105 0-8712 0-365395 GA 149 0-362400 0-1700 0-250 0 0-362400 0-250 0-546000 HI 5 0-3700 0 0 0 0-3700 0 0 IA 54 0-175950 0-6437 0-876 0 0-175950 0-13573 0490000 ID 13 0-12983 0 0-220000 0 0-221502 0-1300 0-8157 IL 249 0-289615 0-1200 04515 0 0-289615 0-3070169 0-41475890 IN 146 041219 0-10639 0-250 0 041219 0-110000 0-334185 KS 43 0-44100 0-5 0-200 0-1517215 0-1517215 0-750 0-1570000 KY 84 0-38661 0 0 0 0-38661 0-42075 0-1455560 LA 79 0-630000 0-750 0-15250 0-2 0-630000 0 0-5449320 MA 110 0-58655 0 0 0 0-58655 0-123397 0-87000 MD 3H 0-380000 0-100 0-250 0 0-380000 0-250 0-26700000 ME 24 0-570000 0 0-400 0 0-570000 0-5 0-76300 MI 160 0-163005 0-1205 0 0-5 0-163005 0-27520 0-5014000 MN 55 0-37000 0-1500 0 0 0-37000 0-6405 0-54912 3FHNSOdX3 NVWNH HO4 TVILN3LOd 'S alov 2idN41NS ANY 3aiXoldl 8ndns 6c} + LNTJWWNOD O179Nd HOA L14VH.us Table 5-1. Releases to the Environment from Facilities That Manufacture or Process Sulfuric Acid (continued) Range of reported amounts released in pounds per year * y Numbers of Underground Total POTW Off-site State faciivies Air Water Land injection environment transfer waste transfer MO 90 0-17220 0-116 0-116 0 0-17220 0-628 0-2850000 MS 49 0-71888 0-152 0-20156 0 0-71888 0-250 0-2800000 MT 5 0-30300 0 0-5 0 0-30300 0 0 NC 127 0-352700 0 0-1000 0 0-353700 0-166200 0-1299000 ND 6 0-750 0 0 0 0-750 0 0 NE 28 0-703 0 0-5 0 0-703 0-69366 0-652 NH 22 0-155264 0 0 0 0-155264 0 0-3600 NJ 102 0-12186 0-5 0 0 0-12186 0-15302 0-313472 NM 1 0481374 0 0-5 0 0-481374 0-10860 0 NV 8 0-12500 0 0-673 0 0-12500 0 0-90 NY 140 0-34005 04225 0-750 0 0-34005 0-16500 0-831819 OH 203 0-420000 0 0 0 0-420000 0-60120 0-3631792 OK 41 0-77000 0 0-75147 0-619 0-77000 0-14400 0-1287700 OR 46 0-46725 0-1 0 0 0-46725 0-250 0-37000 PA 172 0-330087 0-250 0-250 0 0-330087 0-43460 0-30100000 PR 28 0-18000 0-250 0-4500 0 0-18000 0-250 0-1230 RI 24 0-500 0 0 0 0-500 0-750 0-13881 SC 93 0-173677 0-250 0-9500 0 0-173677 0-31873 0-1278000 SD 1 250 0 0 0 250 0 0 TN 107 0-150525 0-5800 0-250 0 0-150525 0-3576 0-149181 LDS 202 0-190000 0-652 0-19814 0 0-190000 0-59408 0-121539 ut 32 0-152000 0 0 0 0-152000 0-750 0-2400000 VA 62 0-368282 0-38850 0-20 0 0-368282 0-1950 0-24130 Vi 2 0 0 0 0 0 0 0 3HNSOdX3 NYIWNH HOH TVILN3LOd 'S aidv J1dN47INS ANY 3AIXOIdL UN41NS oEl ««»1INIWWOO O1N8Nd HOH 14VHA... Table 5-1. Releases to the Environment from Facilities That Manufacture or Process Sulfuric Acid (continued) Number of Range of reported amounts released in pounds per year * State’ facilities Air Water Land Ura iroura are) ail pony waste, re VT 6 0-34341 0 0 0 0-34341 0 0-32800 WA 61 0-114000 0-400 0-170 0 0-114000 0-50000 0-34000 wi 142 0-618000 0-5 0 0 0-618000 0-480000 0-596586 wv 28 0-8255 0-5 0-250 0 0-8255 0-184793 0-320879 wy 6 0-24380 0 0-6690 0 0-24380 0 0 Source: TRI94 1996 ® Data in TRI are maximum amounts released by each facility. ® Post office state abbreviations used ¢ The sum of all releases of the chemical to air, land, water, and underground injection wells by a given facility POTW = publicly owned treatment works FHNSOdX3 NYWNH HOH TVILNILOd °S diov 2ldN4INS ANV 3aiXOoldl HNndIns EL SULFUR TRIOXIDE AND SULFURIC ACID 132 5. POTENTIAL FOR HUMAN EXPOSURE Additional data concerning the release of sulfur trioxide or sulfuric acid to the air were not identified. Data regarding emissions of sulfur dioxide, which reacts with water in air to form sulfuric acid, were identified and are summarized below. Perhaps the largest natural source of sulfur dioxide is volcanic eruptions. Major volcanic eruptions which inject sulfur dioxide into the stratosphere are the dominant source of sulfuric acid aerosol in the stratosphere (Hofmann 1990). In the stratosphere, at temperatures ranging from -80°C to -45°C, aqueous spherical droplets are generally composed of 60-80% sulfuric acid. The oceans, which contain about 2.65 mg sulfate/g of water, are also an important source of atmospheric sulfate (Kellogg et al. 1972). In the United States, much of the sulfur dioxide is emitted from electric plants in rural sites. These plants have high stacks and emit plumes with low particle concentrations; these conditions facilitate the production of sulfuric acid in gas and aqueous phases and facilitate the long-range transport of acid aerosols (Spengler et al. 1990). The production of acid aerosols is principally a summertime occurrence because it is driven by photochemistry and the demand for electricity for air conditioning. Aerosols formed from coal combustion have a high concentration of sulfates at the surface (Amdur et al. 1986). This occurs because sulfates condense late, concentrating on the surface. Sulfate concentrations increase with decreasing particle size. Some of the sulfate associated with the aerosols is in the form of sulfuric acid. The amount of sulfuric acid formed is dependent on coal type and the temperature history of particles in the furnace. The differences among coal types are attributed to differences in the ability of the ash to catalyze the oxidation of sulfur dioxide and neutralize the resulting acid. Acid production is highest at a furnace temperature of 1,000°K. In an experimental furnace that produced zinc oxide particles, water vapor was shown to be required for the production of sulfuric acid. The estimated amount of sulfur dioxide emitted in the United States has gone down in recent years (EPA 1995a). In the early 1970s the estimated total emission of sulfur dioxide in the United States was about 28 million metric tons. In 1994 the level had declined to about 18 million metric tons, which is approximately the same amount that was emitted in 1940. The decreases are in part a result of emission controls and a switch to low-sulfur coal by electric utilities. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 133 5. POTENTIAL FOR HUMAN EXPOSURE When sulfur dioxide emissions were at their maximum, it was estimated that approximately 95% of the sulfur emitted to the atmosphere by humans was in the form of sulfur dioxide (Kellogg et al. 1972). Much of this (about 70%) resulted from the burning of coal. It was estimated that about 93.5% of the sulfur dioxide was produced in the Northern Hemisphere, with only about 6.5% produced in the Southern Hemisphere. Kellogg et al. (1972) concluded that humans were contributing about half as much as nature to the total sulfur burden of the atmosphere. Atmospheric emissions of sulfur dioxide by 25 countries in Asia east of Afghanistan and Pakistan were estimated based on fuel consumption, sulfur content in fuels, and emission factors for the fuels in each emission category (Kato and Akimoto 1992). From 1975 to 1987 the emission of sulfur dioxide in these countries increased by a factor of 1.59 (from 18.3x10° to 29.1x10° tons). The six countries of China, India, South Korea, Japan, Thailand, and Taiwan accounted for 92% of the sulfur dioxide released in Asia. 5.2.2 Water The three major sources of sulfur compounds in bodies of water are rocks, fertilizers, and the atmosphere (Kellogg et al. 1972). The largest contribution is thought to be from the atmosphere. A correlation between sulfate in surface water and sulfate concentrations in precipitation has been observed over a wide range of concentrations (EPA 1985). Background sulfate concentrations in North American lakes are estimated at 20-40 microequivalents/L (peq/L). In eastern North America where acid deposition occurs, sulfate concentrations are 80-100 peq/L. Surface water closer to sources of emission has even higher concentrations. For example, lakes near Sudbury, Ontario, Canada, have concentrations of about 400 peq/L, and lakes east of the Rhine-Rhone industrial region of Germany can have concentrations of >1,000 peq/L (EPA 1985). According to the TRI, in 1994, releases of sulfuric acid to water from 3,775 large processing facilities totalled 90,813 kg (201,807 pounds) (TRI94 1996). Table 5-1 lists amounts released from these facilities. The TRI data should be used with caution because only certain types of facilities are required to report. This is not an exhaustive list. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 134 5. POTENTIAL FOR HUMAN EXPOSURE 5.2.3 Soil According to the TRI, in 1994, releases of sulfuric acid to the soil from 3,775 large processing facilities totalled 230,444 kg (512,097 pounds) (TRI94 1996). Table 5-1 lists amounts released from these facilities. The TRI data should be used with caution because only certain types of facilities are required to report. This is not an exhaustive list. Additional data regarding the release of sulfuric acid to soil were not identified. As indicated for releases to water, rocks, fertilizers, and fallout from the atmosphere would be expected to contribute to the release of sulfuric acid to soil. 5.3 ENVIRONMENTAL FATE 5.3.1 Transport and Partitioning Factors that affect the dispersion of sulfur compounds and other air pollutants include the temperature and efflux velocity of the emissions, stack height, topography and the proximity of other buildings, and meteorology. Meteorological conditions that result in temperature inversions can result in the trapping of pollutants, which increases concentrations up to several hundred times the concentrations usually found (WHO 1979). Sulfates, including sulfuric acid, are removed from the air by both dry and wet deposition processes. Wet deposition processes including rainout (a process that occurs within the clouds) and washout (removal by precipitation below the clouds) contribute to the removal of sulfate from the atmosphere (Kellogg et al. 1972). In the stratosphere, sulfuric acid aerosols have lifetimes of about 14 and 2.4 days at altitudes of 15 and 20 km, respectively (Kellogg et al. 1972). At cloud level, the residence time is about 6 days, with shorter residence times in surface air. In a study of rain chemistry in southwestern Pennsylvania in August of 1983, Pierson et al. (1987a) concluded that on average about half of the rain sulfate resulted from scavenging of sulfur dioxide, while the rest was from scavenging of aerosol sulfate. The site where the study was completed was about 150 km downwind of the highest density of sulfur dioxide emissions in the United States. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 135 5. POTENTIAL FOR HUMAN EXPOSURE Sulfuric acid is soluble in water. In water, sulfuric acid dissociates and the sulfate anion may combine with other cations. In soil, the ions from sulfuric acid can adsorb to soil particles or leach into surface water and groundwater. Sulfates can be taken up by plants and be incorporated into the parenchyma of the plant. 5.3.2 Transformation and Degradation 5.3.2.1 Air Sulfuric acid is formed in the atmosphere from sulfur dioxide. Both gaseous and aqueous phase reactions can occur, with gas phase reactions accounting for only about 5% of the sulfur dioxide oxidized during the summer (Pienaar and Helas 1996). In the process of sulfuric acid formation, sulfur trioxide is formed. After sulfur trioxide is formed, it rapidly reacts with water vapor to form sulfuric acid, so that processes that form sulfur trioxide in moist atmospheres are equivalent to the formation of sulfuric acid (Pienaar and Helas 1996). In the gaseous phase, substances that react with sulfur dioxide resulting in the production of sulfuric acid include O, HO-, HO,:, and CH,0,-. Substances that result in the oxidation of sulfur dioxide in the aqueous phase include ozone and hydrogen peroxide. Metal ions including CrO,*, VO*, Fe**, Fe**, Mn*", and Ni** could also directly oxidize SO;%, or catalyze SO,” oxidation by molecular oxygen. In a study using electron spin resonance, spin trapping, and high-performance liquid chromatography, Shi (1994) found that reactions of SO;* with NO, also generate SO," radicals. The major reactions that form sulfuric acid from sulfur dioxide require light. Therefore, levels of sulfuric acid in the atmosphere show both seasonal and diurnal variations. The production of sulfuric acid from sulfur dioxide can become limited if the concentrations of oxidants are less than the concentrations of sulfur dioxide. Oxidant limitations of the formation of sulfuric acid were shown in a study of sulfur dioxide and hydrogen peroxide concentrations over Columbus, Ohio, and the study authors suggested that similar conditions exist over a large area of the eastern United States (Kleinman and Daum 1991). A deficiency of hydrogen peroxide relative to sulfur dioxide was also shown in a study completed at Whiteface Mountain, NY (Dutkiewicz et al. 1995). These results suggest that there would be a non-linear relationship between sulfur dioxide emissions and downwind acid precipitation in the northeastern United States where aqueous-phase oxidation by hydrogen peroxide is the principal mechanism for forming sulfuric acid. The aqueous “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 136 5. POTENTIAL FOR HUMAN EXPOSURE oxidation of sulfur dioxide to sulfuric acid in precipitation has been estimated to account for 50-80% of the sulfuric acid found in precipitation (Fung et al. 1991). Acid aerosols react with gaseous ammonia to form partially neutralized ammonium salts. If ammonia is present, sulfuric acid will react to form ammonium sulfate, which is considered neutral for most practical purposes (Wyzga and Folinsbee 1995). The intermediate reaction products ammonium bisulfate and ammonium hemisulfate, which are fairly stable and may be present in abundance, are acidic. Aerosol neutralization is dependent on the rate of sulfur dioxide oxidation to sulfate and on the ambient concentrations of ammonia (Lui et al. 1996). Among three sites in Pennsylvania with varying degrees of urbanization, H* was the lowest and ammonia was the highest in the most urbanized area. Concentrations of both H* and sulfate were higher during the daytime, probably a result of daytime conversion of sulfur dioxide to sulfate. Diurnal variations in ammonia concentrations were not observed. The effect of wind speed on the ammonia neutralization of sulfuric acid was studied under chamber conditions (Clark et al. 1995). During exposure to an average sulfate ion concentration of 0.105 mg/m’, about 25% of the breathing-zone acid was neutralized without wind, while 10% was neutralized with a wind of 4 or 16 km/hour. In air, submicron-sized sulfuric acid aerosol droplets rapidly take up water from the atmosphere. For example, the growth of a sulfuric acid droplet of 1 pm, concentration 98%, was complete in 0.1 second after exposure to an atmosphere of relative humidity 50% at 20°C (Carabine and Maddock 1976). 5.3.2.2 Water In water, sulfuric acid dissociates. The sulfate anion may associate with other cations including calcium, magnesium, and aluminum. Sulfur that is in water may be oxidized to sulfuric acid by sulfur bacteria (Thiobacilli) that use sulfur to obtain energy for growth (Takeuchi and Suzuki 1994). Sulfate in water can also be reduced. Because sulfur can be transformed in water, the effect of sulfur on aquatic systems is not dependent on the chemical or physical form of deposition (EPA 1985). “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 137 5. POTENTIAL FOR HUMAN EXPOSURE In the surface layer of the ocean the sulfate anion may be formed from dissolved sulfur dioxide (sulfurous acid). Because of the relative lack of salt in freshwater, the oxidation of sulfur dioxide to sulfate is less likely to occur in freshwater. In the depths of the ocean, sulfate is reduced to sulfur dioxide, sulfur, and hydrogen sulfide by bacteria (Kellogg et al. 1972). 5.3.2.3 Sediment and Soil The ions (sulfate, hydrogen) can adsorb to soil particles or be converted to gases (EPA 1985). Anaerobic bacteria in sediments and soil can reduce sulfate to sulfur and hydrogen sulfide (Kellogg et al. 1972). 5.4 LEVELS MONITORED OR ESTIMATED IN THE ENVIRONMENT 5.4.1 Air Air monitoring results are often reported in terms of hydrogen ion or sulfate concentrations, or sulfuric acid equivalents, rather than sulfuric acid concentrations. The local concentration of acidity is dependent on the balance between acids and bases and is difficult to estimate using meteorological dispersion models (Lipfert et al. 1989). Peak sulfuric acid concentrations that have been reported include 240 pg/m’ in the Los Angeles area in 1950, an hourly average of 678 pug/m’ in London during an episode in 1962, and an hourly average of 50 ug/m® in Ontario during the summer of 1986 (Amdur 1989b). The highest concentrations of aerosol acidity are found in the eastern United States and southern Ontario, Canada. This results because of the major power plants in the Ohio River Valley region and the ability of the acid precursors to be transported. (Spengler et al. 1990). Usually, acid aerosol concentrations are higher during the day than at night and higher during the summer. Acid concentrations may be higher in rural areas because of higher ammonia emissions in urban areas that result in greater neutralization of the acid. Arithmetic annual average sulfate concentrations measured from 1964 to 1968 were 13.5 pg/m’ for urban sites in the eastern United States and 6.4 pg/m’ for urban sites in the western United States (Altshuller 1973). At eastern sites, 7% of the annual averages were above 20 pg/m®, while no annual averages were above 20 pug/m’ at western sites. The minimum detectable concentration of sulfate during this study period was 0.6 pg/m’. The average ratio of sulfur “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 138 5. POTENTIAL FOR HUMAN EXPOSURE dioxide to sulfate was 4.7:1, with a ratio of 4.9:1 at eastern urban sites, and a ratio of 3.4:1 for western urban sites (Altshuller 1973). A review of studies of the measurement of sulfuric acid or hydrogen ion (as sulfuric acid) in the United States from 1974 to 1986 indicated that the concentra- tions were generally below 5 pg/m’ (Lioy and Waldman 1989). The highest concentration reported in these studies was a 1-hour average of 41 ug/m’ in 1984 at a site in St. Louis, MO. Lioy and Waldman (1989) cautioned that periods of high acid do not necessarily occur at the same time as periods of high atmospheric sulfate. For example, in a study of hydrogen ion and sulfuric acid, the median level of sulfuric acid was about 15% of the median level of hydrogen ion (Lipfert et al. 1989). Outdoor, indoor, and personal sulfate, hydrogen ion, and ammonia levels were measured in State College, PA (Suh et al. 1993). The samples were collected over 12-hour daytime periods. The indoor samples were taken from 47 homes, 21 with air conditioning. As indicated in Table 5-2, the outdoor concentrations of sulfate and hydrogen ion were greater than the indoor concentrations, while the personal values were close to the results from indoor measurements. Ammonia levels were higher inside than outside, and personal ammonia monitors indicated even higher levels of exposure. Daily distributions of acid aerosol concentrations were examined in Kingston, TN, and St. Louis, MO, in 1986, and in Steubenville, OH, and Portage, WI, in 1987 (Spengler et al. 1989). Elevated acid aerosol concentrations occurred more frequently in the summer months. Approximately 50% of the days, acid aerosol concentrations expressed as equivalents of sulfuric acid in pg/m’® were about 1, 0.2, 0.6, and 0.1 in Kingston, St. Louis, Steubenville, and Portage, respectively. The maximum concentra- tions in pg/m® were about 10, 3.5, 10.5, and 2.5 in Kingston, St. Louis, Steubenville, and Portage, respectively. Measurements of sulfuric acid aerosols in the stratosphere over Laramie, WY, indicate increases of about 5+2% per year from 1979 to 1990 (Hofmann 1990). It is not yet known if this increase is a result of natural or anthropogenic sources. Above the Atlantic Ocean, sulfate concentrations of 2-5 pg/m® have been reported (Kellogg et al. 1972). Acidic acid aerosols were measured in Erfurt in east Germany and Sokolov in the Czech Republic during December 1990 until June 1992 (Cyrys et al. 1995). Concentrations of sulfur dioxide, sulfate, and H* (as H,SO,) in pg/m* averaged 84.6, 9.6, and 0.3, respectively, in Erfurt, and 62.1, 8.8, and 0.4, respectively, in Sokolov. These results and other studies reviewed by the study authors indicate that “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 5. POTENTIAL FOR HUMAN EXPOSURE TABLE 5-2. Outdoor, Indoor, and Personal Concentrations of Sulfate, Hydrogen lon, and Ammonia? 139 Geometric mean Geometric standard Sample type Sample size (nmol/m?*) deviation Sulfate Outdoor 76 90.98 2.45 Indoor 214 69.13 2.62 Personal 209 71.53 2.40 Hydrogen ion Outdoor 75 72.39 2.87 Indoor 168 9.10 3.51 Personal 174 18.39 3.03 Ammonia Outdoor 78 2.94 0.43 Indoor 214 19.86 2.20 Personal 200 28.05 2.08 Modified from Suh et al. 1993 ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 140 5. POTENTIAL FOR HUMAN EXPOSURE acidity in Europe is generally lower than in North America. The investigators noted that in eastern Europe sulfur dioxide and ammonia are emitted at the same height so that acidic sulfate will be neutralized. In the European cities, days with noticeable acidity were more prevalent during the winter than during the summer. Measurements of acid aerosols at eight sites in The Netherlands from October 1987 to April 1990 showed concentrations occasionally in excess of 1 pg/m’, but never exceeding 10 pg/m’ (Hoek et al. 1996). The size range of acid droplets collected in the environment is large. Acid droplets can be found on all stages of a cascade impactor (0.5-23 pm). The larger droplets often appear to be associated with solid particles (Waller 1963). The largest number of droplets is usually collected at relative humidities of about 90%. 5.4.2 Water The levels of sulfate in the water are highly dependent on nearby emissions of sulfur containing compounds which can be converted to sulfuric acid. Background sulfate concentrations in North American lakes are estimated at 20-40 peq/L (EPA 1985). In eastern North America where acid deposition occurs, sulfate concentrations are 80-100 peq/L. Surface water closer to sources of emission has even higher concentrations. For example, lakes near Sudbury, Ontario, Canada, have concentrations of about 400 peg/L, and lakes east of the Rhine-Rhone industrial region of Germany can have concentrations of >1,000 peq/L (EPA 1985). 5.4.3 Sediment and Soil Data regarding the levels of sulfuric acid in sediment and soil were not identified. 5.4.4 Other Environmental Media Data regarding the levels of sulfuric acid in other environmental media were not identified. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 141 5. POTENTIAL FOR HUMAN EXPOSURE 5.5 GENERAL POPULATION AND OCCUPATIONAL EXPOSURE Occupational exposures to sulfuric acid mists (particle size measurements not available) in pickling, electroplating, and other acid treatment of metals are frequently above 0.5 mg/m’, with lower concentrations generally found in the production of phosphate fertilizer and in the manufacture of lead- acid batteries (IARC 1992). Sulfuric acid exposure also occurs when it is manufactured and when isopropanol, synthetic ethanol, and detergents are produced. Other industries where there is potential exposure to sulfuric acid include building and construction, electric and electronic equipment, food products, health services, instruments, leather, oil and gas extraction, petroleum and coal products, photography shops, printing and publishing, paper and allied products, rubber and plastic products, steel, and textile products (IARC 1992). The National Occupational Exposure Survey (NOES), conducted by NIOSH from 1981 to 1983, estimated that 56,103 and 775,348 U.S. workers may be exposed to sulfur trioxide and sulfuric acid, respectively (NOES 1990). The NOES database does not contain information regarding the frequency, concentration, or duration of exposure; the survey provides only estimates of workers potentially exposed to chemicals in the workplace, and is based on sample populations only. At five lead-acid battery plants in the United States, the average sulfuric acid concentration was 0.18 mg/m’ with a range of nondetectable (detection limit not stated) to 1.7 mg/m® (Jones and Gamble 1984). The MMAD of the sulfuric acid mist was about 5 um. Low levels of stibine, arsine, and arsenic in particulate form were also detected. The average lead concentration was 0.72 mg/m’. Workers at two battery manufacturing plants in Egypt were exposed to sulfuric acid vapor at concentrations of 12.55-35.02 mg/m® (El-Sadik et al. 1972). The particle sizes were not provided. A study of kerosene heaters indicates that they can be a source of acidic aerosols in indoor air. The emission rate for acid aerosols calculated as sulfuric acid ranged from 0.6 to 63.1 ug/g of fuel (Leaderer et al. 1990). The particles produced by the four heaters used in this study were less than 2.5 ym in diameter. The investigators noted that the heater that produced the highest levels of acid aerosols "showed evidence of considerable use and may have been maltuned." Measurements of personal exposure to hydrogen ion and sulfate were completed for 24 days during the summer of 1988 in Boston, MA, and were compared to nearby outdoor stationary site sampling “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 142 5. POTENTIAL FOR HUMAN EXPOSURE data (Brauer et al. 1989). The total number of persons involved in this study was not stated, but there were a total of 31 indoor 24-hour sulfate samples, and a total of 13 indoor 24-hour hydrogen ion samples. Personal measurements of sulfate were similar to those at the outdoor site. Personal measurements of hydrogen ion were lower than the outdoor samples as a result of neutralization of acidic particles and of the incomplete penetration into indoor locations. Similar results were observed for hydrogen ion and sulfate when personal monitors were used by 24 children living in Uniontown, PA (Suh et al. 1992). Air conditioning was found to reduce indoor hydrogen ion concentrations, a result of increased ammonia levels resulting from reduced air exchange rates. Exposure models for sulfate and hydrogen ion have been developed to provide better predictions of exposure relative to outdoor air concentrations of sulfate and hydrogen ion (Suh et al. 1993). These models were developed and validated using air monitoring data and data from children living in rural and semi-rural environments (Uniontown and State College, PA). Because the models were developed in specific environments, the authors cautioned that the models were only applicable to those environments, and that before being used in an urban setting, the model should be validated with urban data. When the sulfate model was compared to actual personal exposure data, it was found that sulfate exposure could be adequately predicted by the outdoor concentration, activity of the person, and knowledge about air conditioning. This model accounted for about 91% of the variability in personal sulfate exposure. The hydrogen ion model included a neutralization term and was better at predicting personal exposure when indoor air concentrations of hydrogen ion and personal ammonia levels were also included. With all the information included in the model, the model accounted for 63% of the variability in personal hydrogen ion exposure. When outdoor concentrations and activity data were used in the model, with the assumption that indoor air concentrations were zero, the model explained only 47% of the variability in measured personal hydrogen ion exposure. Because of the importance of personal ammonia levels on predicting hydrogen ion exposure, and because of similar difficulties in measuring personal ammonia and hydrogen ion concentrations, the study authors suggest that direct measurement of personal hydrogen ion exposure may be the only method to accurately determine personal hydrogen ion exposure. The relationship between hydrogen ion, sulfate, ozone, and population density has been examined using measurements from across the United States and Canada (Ozkaynak et al. 1996). Significant site-specific and regional relationships between hydrogen ion and sulfate and population density were observed. The relationships were stronger in the eastern United States compared to the west or ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 143 5. POTENTIAL FOR HUMAN EXPOSURE midwest, where local pollution, agricultural activities, and industrial sources of ammonia had a greater impact on the lower hydrogen ion levels. The relationships were also stronger during the summer compared to the winter. The study authors concluded that reasonable estimates of hydrogen ion levels could be made using sulfate data and data on local population density. Exposure to sulfuric acid and oleum can also occur through accidental releases. Among states reporting accidental events during the time period 1990-1996 (5 states 1990-1991, 9 states 1992-1994, 14 states 1995-1996) 905 events occurred which involved only sulfuric acid and oleum (3 oleum releases), and 173 events occurred which involved mixtures or multi-chemical releases that included sulfuric acid or oleum (HSEES 1997). The 14 states that are presently participating are Alabama, Colorado, Iowa, Minnesota, Missouri, Mississippi, New Hampshire, New York, North Carolina, Oregon, Rhode Island, Texas, Washington, and Wisconsin. The majority of the releases occurred at a fixed facility rather than a result of a transportation accident. For events with sulfuric acid or oleum alone, 78.7% of the events occurred at fixed facilities, while 81.5% of the events with mixtures including sulfuric acid or oleum occurred at fixed facilities. A spill was the most frequent type of release (85.1% sulfuric acid or oleum only; 63.6% mixture including sulfuric acid or oleum). Among the events in which only sulfuric acid and oleum were released, 53 required evacuation (information not available for 39 events), there was 1 death, and a total of 203 victims. Chemical burns (38.5%), respiratory irritation (21.6%), and eye irritation (15.4%) were the most frequently reported effects following these releases. Among the mixture or multi-chemical releases that included sulfuric acid or oleum, 40 required evacuation (information not available for 3 events), there were 3 deaths, and a total of 322 victims. The most frequently reported effects following the release of mixtures were respiratory irritation (56.5%), eye irritation (17.8%), and nausea and vomiting (5.1%). The general population can also be exposed to sulfuric acid through the use of lead-acid batteries (including car batteries) and cleaners (especially toilet bowl cleaners that contain sodium bisulfate, which produces sulfuric acid when it contacts water). People can also be exposed to sulfuric acid when they cut onions. Cutting onions releases the compound propanethiol S-oxide which reacts with water in the eyes to form sulfuric acid, which causes the eyes to water (Hillman 1989). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 144 5. POTENTIAL FOR HUMAN EXPOSURE 5.6 POPULATIONS WITH POTENTIALLY HIGH EXPOSURES In addition to persons working in industries where sulfuric acid is used, persons living in industrialized areas, especially those living near electric power plants, may be exposed to higher levels of sulfuric acid. Persons who frequently work with car batteries and other lead-acid batteries may also be exposed to higher levels of sulfuric acid. Toilet bowl cleaners often contain sodium bisulfate which produces sulfuric acid when it contacts water. Therefore, misuse of these products may result in higher than normal exposure to sulfuric acid. Sulfuric acid levels are generally lower indoors than outdoors. Therefore, persons who spend most of their time outside may be exposed to higher levels. This may be especially true for persons who engage in considerable outdoor physical activity. Physical activity not only increases breathing rate but increases the amount of oral breathing which would increase the amount of sulfuric acid aerosols reaching the lungs. 5.7 ADEQUACY OF THE DATABASE Section 104(i)(5) of CERCLA, as amended, directs the Administrator of ATSDR (in consultation with the Administrator of EPA and agencies and programs of the Public Health Service) to assess whether adequate information on the health effects of sulfur trioxide/sulfuric acid is available. Where adequate information is not available, ATSDR, in conjunction with the NTP, is required to assure the initiation of a program of research designed to determine the health effects (and techniques for developing methods to determine such health effects) of sulfur trioxide and sulfuric acid. The following categories of possible data needs have been identified by a joint team of scientists from ATSDR, NTP, and EPA. They are defined as substance-specific informational needs that if met would reduce the uncertainties of human health assessment. This definition should not be interpreted to mean that all data needs discussed in this section must be filled. In the future, the identified data needs will be evaluated and prioritized, and a substance-specific research agenda will be proposed. ***DRAFT FOR PUBLIC COMMENT"** SULFUR TRIOXIDE AND SULFURIC ACID 145 5. POTENTIAL FOR HUMAN EXPOSURE 5.7.1 Identification of Data Needs Physical and Chemical Properties. The physical and chemical properties of sulfur trioxide, sulfuric acid, and fuming sulfuric acid are generally well characterized (HSDB 1996; NIOSH 1994b). Further research on the aerosol size of sulfuric acid at occupational settings and in the environment is needed. Production, Import/Export, Use, Release, and Disposal. More sulfuric a The carcinogenicity of sulfuric acid alone has not been classified by IARC. No inhalation MRLs were derived for sulfur trioxide or sulfuric acid exposure. The only inhalation study regarding sulfur trioxide exposure is a report of respiratory irritation in persons accidently exposed (Stueven et al. 1993). Exposure concentrations were not provided in this report. Several acute-duration human exposure studies have reported respiratory effects including bronchoconstriction resulting in changes in lung function tests, and changes in bronchial mucociliary clearance. The lowest concentration that resulted in changes in lung function tests was 0.07 mg/m’ (MMAD 0.72 pm), a concentration at which transient decreases in FVC and FEV, were observed in asthmatics exposed for 40-45 minutes with intermittent exercise (Hanley et al. 1992). Increased respiratory resistance, decreased maximum flow at 50% and 75% of total vital capacity, and decreased FEV, have also been reported in asthmatics exposed to 0.1 mg/m’ (MMAD 0.6 um) for 50 minutes with exercise (Koenig et al. 1985). Although asthmatics are considered more sensitive to changes in lung function following exposure to sulfuric acid, all studies have not reported changes in lung function tests in asthmatics exposed to sulfuric acid aerosols. For example, changes in lung function tests were not observed in asthmatics exposed to 0.1 mg/m’ sulfuric acid aerosols (MMAD 0.5 pm) for 1 hour with intermittent exercise (Anderson et al. 1992). Lung function was affected in 1 of the 15 exposed subjects leading the study authors to conclude that there may be a subgroup of asthmatics that are more sensitive to sulfuric acid exposure. Bronchial mucociliary clearance has only been studied in normal individuals. Decreased clearance was observed in subjects exposed to sulfuric acid aerosols (MMD 0.5 um) with a nasal mask for 1 hour at 0.98 mg/m’ for test particles of 7.6 um (Leikauf et al. 1981), and at 0.108 mg/m’ for test particles of 4.2 pm (Leikauf et al. 1984). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 146 5. POTENTIAL FOR HUMAN EXPOSURE These studies are not being used as the basis of an MRL because physiological factors and conditions under which humans are exposed are just as important in determining the response to sulfuric acid aerosols as the aerosol concentration and aerosol size. Factors which will affect the response to sulfuric acid include aerosol size, relative humidity, condition of the subject (e.g. asthmatic), amount of ammonia present in the mouth, breathing rate, and depth of breathing. Bowes et al. (1995) estimated the deposition of hydrogen ion in 7 healthy male adults exposed to 0.471 mg/m” sulfuric acid aerosols (MMAD 10 pm) using a head-dome that allowed continuous measurement of frequency, tidal volume, and minute ventilation, as well as the onset and persistence of oronasal breathing. They indicated that of the parameters used to estimate the dose of hydrogen ion delivered to the lung, 70% of the variability was accounted for by physiologic parameters (minute ventilation during oronasal breathing 36%; time in minutes of oronasal breathing 34%), and the environmental hydrogen ion concentration accounted for only 30% of the variation. Because the response to sulfuric acid aerosol exposure is so dependent on individual factors rather than exposure concentrations it would be very difficult to identify a NOAEL for human exposure. Intermediate-duration inhalation studies are limited to animal studies (Fujimaki et al. 1992; Gearhart and Schlesinger 1986; Lewis et al. 1969; Schlesinger et al. 1979; Thomas et al. 1958), and chronic- duration inhalation studies include human occupational studies (El Sadik et al. 1972; Gamble et al. 1984; Kitagawa 1984; Kremer et al. 1994; Malcolm and Paul 1961; Williams 1970) and animal studies (Alarie et al. 1973, 1975; Schlesinger et al. 1992a). Because the occupational studies identified NOAELSs higher than LOAELSs in acute-duration studies they were not considered appropriate for MRL derivation. The methodology for extrapolating from inhalation exposure of animals to hygroscopic aerosols has yet to be developed (EPA 1994). Therefore, inhalation MRLs could not be developed from animal studies.is produced in the United States than any other chemical (C&EN 1996). Sulfuric acid is used in many industries, with phosphate fertilizer production the largest user of sulfuric acid in the United States (IARC 1992). Much of the sulfuric acid used in industry is recycled. Small amounts of sulfuric acid can be disposed of safely if it is neutralized and diluted with large amounts of water. Although sulfuric acid can be directly released to the environment, much of the sulfuric acid in the air forms from sulfur dioxide. The percentage of sulfuric acid in the air from direct release, relative to the percentage from sulfur dioxide, was not available. Because of the widespread use of sulfuric acid, and the formation of sulfur trioxide and sulfuric acid from sulfur dioxide, human exposure to sulfuric acid is widespread. Additional data concerning the production, import/export, use, release, and disposal of sulfur trioxide and sulfuric acid are not needed at this time. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 147 5. POTENTIAL FOR HUMAN EXPOSURE According to the Emergency Planning and Community Right-to-Know Act of 1986, 42 U.S.C. Section 11023, industries are required to submit chemical release and off-site transfer information to the EPA. The Toxics Release Inventory (TRI), which contains this information for 1994, became available in May of 1996. This database will be updated yearly and should provide a list of industrial production facilities and emissions. Environmental Fate. Once sulfuric acid enters the environment, the sulfur enters the natural sulfur cycle which is well defined (Kellogg et al. 1972). Additional research regarding the environmental fate of sulfuric acid does not appear to be necessary at this time. Bioavailability from Environmental Media. As part of the natural sulfur cycle, sulfur compounds can be taken up by plants. The adsorption of sulfuric acid on small particles increases the toxicity of sulfuric acid (Amdur 1989b). This effect is thought to result at least in part from a change in the deposition of sulfuric acid in the respiratory tract, not an increase in bioavailability. Because sulfuric acid is a direct-acting toxicant, rather than a substance that causes toxic effects after being absorbed into the blood stream, bioavailability from different media is not an important issue for sulfur trioxide and sulfuric acid. Food Chain Bioaccumulation. Sulfur is an important constituent of normal biomolecules. Food chain bioaccumulation is not an important issue for either sulfur trioxide or sulfuric acid. Exposure Levels in Environmental Media. Air is the environmental media most relevant to human exposure to sulfuric acid. Air monitoring results are often reported in terms of hydrogen ion or sulfate concentrations, or sulfuric acid equivalents, rather than sulfuric acid concentrations. Additional data concerning the aerosol size of sulfuric acid in air is needed. Exposure Levels in Humans. Models for personal sulfate and hydrogen ion exposure have been developed (Suh et al. 1993). Improvement in personal ammonia monitoring would improve the ability to predict personal hydrogen ion exposure. This information is necessary for assessing the need to conduct health studies on these populations. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 148 5. POTENTIAL FOR HUMAN EXPOSURE There is no biomarker for human exposure to sulfuric acid. The only potential biomarker may be measurement of pH in saliva. Because saliva has some buffering capacity, decreases in saliva pH would only be apparent at relatively high-level sulfuric acid exposures. Exposure Registries. No exposure registries for sulfuric acid were located. This substance is not currently one of the compounds for which a subregistry has been established in the National Exposure Registry. The substance will be considered in the future when chemical selection is made for subregistries to be established. The information that is amassed in the National Exposure Registry facilitates the epidemiological research needed to assess adverse health outcomes that may be related to exposure to this substance. 5.7.2 Ongoing Studies The production of sulfuric acid by various reactions in the upper troposphere and lower stratosphere is being studied further by Somorjai and Johnston (FEDRIP 1996). Tabatabai is studying wet deposition, including sulfuric acid deposition in central Iowa (FEDRIP 1996). Xiong and coworkers at the New York University Medical Center in Tuxedo, New York, are studying the effect of organic films on the reactivity and hygroscopicity of sulfuric acid aerosols (Xiong et al. 1997). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 149 6. ANALYTICAL METHODS The purpose of this chapter is to describe the analytical methods that are available for detecting, and/or measuring, and/or monitoring sulfur trioxide and sulfuric acid, its metabolites, and other biomarkers of exposure and effect to sulfur trioxide and sulfuric acid. The intent is not to provide an exhaustive list of analytical methods. Rather, the intention is to identify well-established methods that are used as the standard methods of analysis. Many of the analytical methods used for environmental samples are the methods approved by federal agencies and organizations such as EPA and the National Institute for Occupational Safety and Health (NIOSH). Other methods presented in this chapter are those that are approved by groups such as the Association of Official Analytical Chemists (AOAC) and the American Public Health Association (APHA). Additionally, analytical methods are included that modify previously used methods to obtain lower detection limits, and/or to improve accuracy and precision. 6.1 BIOLOGICAL SAMPLES No methods for determining sulfur trioxide or sulfuric acid in biological materials were located. Studies in which plasma sulfate was measured after exposure to sulfuric acid were not identified. Sulfate is a normal constituent in the blood found at concentrations of 0.8—1.2 mg/dL in humans (Hensyl 1990). Increases in blood sulfate would result in increased sulfate excretion in the urine. Therefore, the measurement of plasma sulfate would not be a very useful indicator of sulfuric acid exposure. The pH of saliva is decreased in persons occupationally exposed to sulfuric acid (El-Sadik et al. 1972). Because the effects of sulfuric acid are a result of pH changes, measurement of sulfuric acid in saliva may be a useful biomarker following exposure to sulfuric acid. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 150 6. ANALYTICAL METHODS 6.2 ENVIRONMENTAL SAMPLES Methods for measuring sulfur trioxide and sulfuric acid in air, and sulfate in water, are summarized in Table 6-1. Sulfuric acid in air is usually measured as H,SO, or as titratable hydrogen ion (Lioy and Waldman 1989). Measurements are usually made by the collection of aerosols on filters, with subsequent analysis of the concentration of sulfate and other ions, or by continuous analysis. A cascade impactor, which has stages to separate aerosols of different sizes, is often used to measure aerosol size. Because of the reactive nature of sulfuric acid, air sampling poses some unique challenges. Difficulties encountered in collecting samples for acid measurements include reversible or irreversible sorption losses onto filters, and equilibrium-driven loss or gain of species as a result of non-steady- state conditions in the atmosphere of the time period of measurement (Lioy and Waldman 1989). To help avoid sorption losses, treated quartz and teflon filters are recommended rather than glass-fiber filters which contain a larger number of free basic sites. The loss of strong acid by reactions between co-collected basic and acidic particles can be eliminated by using a coarse particle separator (e.g., a cyclone or impactor inlet) or by sampling for shorter time periods. To prevent neutralization, a denuder is used to scavenge neutralizing species. Once the samples are collected, the methods used to measure acid aerosols include aqueous extraction of soluble particles collected on the filter, and the determination of the concentration of sulfate and other ions using methods such as ion chromatography, pH measurement, or titration (Lipfert et al. 1989). NIOSH recommends ion chromatography (Method 7903) for the determination of sulfuric acid in ambient air (NIOSH 1994a). Method 7903 is a method for the determination of inorganic acids. This method measures the total concentration of six airborne anions. Particulate salts of all of the acids will give a positive interference (NIOSH 1994a). The working range is approximately 0.01-5 mg/m’ for a 50-L air sample (NIOSH 1994a). Most of the acid aerosol measurements are completed on a 12- or 24-hour basis. With 24-hour sampling, peaks may be underestimated by as much as 50%, and Lipfert et al. (1989) recommend that ambient sampling be conducted for the shortest practical averaging times on an every-day basis. ***DRAFT FOR PUBLIC COMMENT*** «+LNIWWNOD O1N8Nd HOH 14vHA... in Environmental Samples TABLE 6-1. Analytical Methods for Determining Sulfur Trioxide and Sulfuric Acid Sample detection Percent Sample matrix Preparation method Analytical method limit recovery Reference Air (H,SO,) Pass through a heater Continuous FPD 1-2 pg/m’ NR Appel et al. 1987 (120° C); then through a diffusion denuder; then through a detector Draw through silica gel IC 0.9 pg/sample NR NIOSH 19%94a tube; desorb with (Method 7903) NaHCO,/NaCO; and heat Collect on cellulose filter Colorimetry 15 pg/sample NR NIOSH 1979 paper; heat for 72 hours; (=0.2 mg/m?) (Method 267) compare charring colora- tion to standard Absorb in water in Turbidimetry 10 pg NR NIOSH 1977 midget impinger; (0.1 mg/m?) (Method 187) precipitate as barium sulfate; measure turbidity at 420 nm Air collected into mixing IC 2.2 ng/m’ sulfate 96.97%, Simon and Dasgupta chamber; mixed with MMAD 1995 superheated steam; enters 0.5 pm; a maze where it is 99.95%, cooled; intertial air/liquid MMAD separator separates 0.7 pm dissolved and insoluble particles Collection on Colorimetry 26 ppb NR Zeilweger Analytics Chemcassette 1996 SAOHL3W TIVOILATTVYNY 9 alov 21HN4INS ANY 3aIXoid.L ’4n4Ins ISH +«LNIJWWOD O178Nd HOS 14vHQ... TABLE 6-1 (continued) Sample matrix Preparation method Analytical method Sample detection limit Percent recovery Reference Air — personal exposure (SO,%, strong H') Stack gases (H,S0,) Stack gases (S0O,, H,S0,) Water, wastes (sulfate) Air collected through a borosilicate glass impactor, two glass annular denuders, and a Teflon filter pack Collect via impinger (using controlled condensation method); titrate using NaOH and bromophenol blue indicator Extract isokinetically; separate sulfuric acid mist (including sulfur trioxide) and sulfur dioxide; add isopropanol, titrate using 0.01 M Ba(ClO,), and Thorin indicator Pass through a sodium- form cation-exchange column; react with ethanol solution of barium chloride and methylthymol blue at pH 2.5-3.0; raise to pH 12.5-13.0; measure color intensity IC AT Titration Automated colorimetry 12.7 nmol/m? sulfate; 49 nmol/m® H* 40-24,250 mg/m’ 0.05 mg/m’ SO; NR H,SO, 0.5 mg sulfate/L NR NR 90-110% Brauer et al. 1989; Koutrakis et al. 1988, 1989 Knapp et al. 1987 EPA 1988 EPA 1993 SAOHL3IW TVOILATVYNY “9 aiov OI"dN4TINS ANY 3aIXOold.1l ’Hn4d1Ns est ««LNIFWWOD OI78Nd HOH 14VvHQ... TABLE 6-1 (continued) Sample detection Percent Sample matrix Preparation method Analytical method limit recovery Reference Water, wastes Separate ions of interest IC 2.85 mg/L 75-125% EPA 1993 (sulfate) on an ion chromatograph; then pass through a conductivity detector AT = alkalimetric titration; Ba(ClO,), = barium perchlorate; FPD = flame photometric detection; H* = hydrogen ion; H,SO, = sulfuric acid; IC = ion chromatography; M = molar; MMAD = mass median aerodynamic diameter; NaCO, = sodium carbonate; NaHCO, = sodium bicarbonate; NaOH = sodium hydroxide; NR = not reported; SO, = sulfur trioxide; SO, = sulfate SAOHL3INW TVOILATVYNY 9 aiov OlHN4INS aNV 3aIXoldl JndIns €S1 SULFUR TRIOXIDE AND SULFURIC ACID 154 6. ANALYTICAL METHODS Sulfuric acid in air may also be determined using a continuous flame photometric detector with a diffusion denuder tube for sulfur dioxide removal before the detector (Appel et al. 1987). The time resolution for this method is about 6-8 minutes (Lioy and Waldman 1989). The sensitivity of this method is enhanced if sulfur hexafluoride—doped hydrogen gas is used (Lioy and Waldman 1989). The advantages of using flame photometric detector analysis include low maintenance, high sensitivity, fast response, and no interference from non-sulfur species. However, this method is unable to discriminate between sulfur species. A method has been developed for measuring personal exposure to sulfate, strong acidity (strong H"), as well as other gases including sulfur dioxide and ammonia (Brauer et al. 1989; Koutrakis et al. 1988, 1989). In this method air is collected by a pump at a rate of 4 L/minute and passes through a borosilicate glass impactor that collects coarse particles, through two glass denuders that collect the gases, and through a Teflon filter pack that collects the fine aerosols. The filters are then analyzed for ions using ion chromatography. The personal monitors can be worn in a backpack with a total weight of about 5 pounds (Suh et al. 1992). In water, sulfate can be measured by colorimetry anion chromatography (EPA 1993). Sulfur trioxide is not found in water because it is hydrated to sulfuric acid in water. Colorimetric analyzers are simple and highly sensitive. Colorimetric analyzers measure a solution’s optical absorbance spectrophotometrically; the absorbance is proportional to the concentration of the colored species. However, color intensity is sensitive to temperature, pH, development time, purity of reagents, and age of solutions. Specificity may improve with development time but does not allow a fast response. EPA (1993) recommends that for the ion chromatography method, the samples be stored at 4°C for a maximum of 28 days before analysis. 6.3 ADEQUACY OF THE DATABASE Section 104(i)(5) of CERCLA, as amended, directs the Administrator of ATSDR (in consultation with the Administrator of EPA and agencies and programs of the Public Health Service) to assess whether adequate information on the health effects of sulfur trioxide and sulfuric acid is available. Where adequate information is not available, ATSDR, in conjunction with the NTP, is required to assure the initiation of a program of research designed to determine the health effects (and techniques for developing methods to determine such health effects) of sulfur trioxide and sulfuric acid. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 155 6. ANALYTICAL METHODS The following categories of possible data needs have been identified by a joint team of scientists from ATSDR, NTP, and EPA. They are defined as substance-specific informational needs that if met would reduce the uncertainties of human health assessment. This definition should not be interpreted to mean that all data needs discussed in this section must be filled. In the future, the identified data needs will be evaluated and prioritized, and a substance-specific research agenda will be proposed. 6.3.1 Identification of Data Needs Methods for Determining Biomarkers of Exposure and Effect. Biomarkers that show a concentration-related response have not been developed for exposure to sulfuric acid. The pH of saliva is decreased in persons occupationally exposed to sulfuric acid (El-Sadik et al. 1972). Further studies to examine the relationship between air concentrations of sulfuric acid and saliva pH are needed. Methods for Determining Parent Compounds and Degradation Products in Environmental Media. Methods are available for measuring sulfur trioxide and sulfuric acid in air (Appel et al. 1987; Knapp et al. 1987; NIOSH 1977, 1979, 1994a; Simon and Dasgupta 1995) and sulfuric acid in water (EPA 1993). The development of additional methods to distinguish between sulfuric acid in air and ammonium bisulfate (sulfuric acid partially neutralized by ammonia) are needed (Lioy and Waldman 1989). 6.3.2 Ongoing Studies Dr. Beverly S. Cohen’s group at New York University Medical Center is developing a method to measure ambient acidic particles with a diameter less than 0.05 pum (Cohen 1997). ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 157 7. REGULATIONS AND ADVISORIES The international, national, and state regulations and guidelines regarding sulfur trioxide and sulfuric acid in air, water, and other media are summarized in Table 7-1. The DHHS (1994) and EPA have not classified sulfur trioxide or sulfuric acid for carcinogenic effects. IARC considers occupational exposure to strong inorganic mists containing sulfuric acid to be carcino- genic to humans (Group 1) (IARC 1992). ACGIH has classified sulfuric acid as a suspected human carcinogen (Group A3) (ACGIH 1996). Sulfuric acid is on the list of chemicals in "Toxic Chemicals Subject to Section 313 of the Emergency Planning and Community Right-to-Know Act" (EPA 1995b). The occupational permissible exposure limit (PEL) for sulfuric acid is 1 mg/m? (OSHA 1996). The NIOSH recommended exposure limit (REL) is also 1 mg/m’ (NIOSH 1994b). ACGIH recommends a threshold limit value time-weighted average (TLV-TWA) of 1 mg/m’ and a short-term exposure limit (STEL) of 3 mg/m® (ACGIH 1996). No MRLs have been derived for sulfur trioxide or sulfuric acid. EPA has not derived an oral reference dose (RfD) or an inhalation reference concentration (RfC) for sulfur trioxide or sulfuric acid. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 158 7. REGULATIONS AND ADVISORIES TABLE 7-1. Regulations and Guidelines Applicable to Sulfur Trioxide and Sulfuric Acid Agency Description Information References INTERNATIONAL IARC Carcinogenic classification: Group 1° IARC 1992 sulfuric acid NATIONAL Regulations: a. Air: OSHA PEL TWA (8-hours) sulfuric acid 1 mg/m? OSHA 1996 (58 FR 35340) b. Water: EPA Hazardous substance under the Yes EPA 1996a (54 FR Clean Federal Water Pollution 33488) Control Act Sec 311(b)(2)(A), sulfuric acid c. Food: EPA Exempt from a tolerance for pesti- Yes EPA 1996b (48 FR cide chemicals in or on raw 52914) agricultural commodities, sulfuric acid Exempt from the requirement of a Yes EPA 1996c (47 FR tolerance when used in accor- 13528) dance with good agricultural practice as a herbicide in the production of garlic and onions and as a potato vine dessicant in the production of potatoes, sulfuric acid d. Other: DOT Forbidden for transport on passenger Yes DOT 1996 (55 FR carrying aircraft or railcars 52472) sulfur trioxide sulfuric acid, spent Domestic transportation labels, Yes DOT 1996 (55 FR corrosive: sulfur trioxide, 52472) corrosive: sulfuric acid, sulfuric acid spent ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 7. REGULATIONS AND ADVISORIES TABLE 7-1 (continued) ***DRAFT FOR PUBLIC COMMENT"*** Agency Description Information References NATIONAL (Cont.) EPA CERCLA reportable quantity EPA 1996d (50 FR Sulfur trioxide 100 pounds 13474) Sulfuric acid ~ 1000 pounds Extremely hazardous substance, EPA 1996d (50 FR TPQ: 13474) Sulfur trioxide 100 pounds Sulfuric acid 1000 pounds EPA-OSW Designation of hazardous substance, Yes EPA 1995b (54 FR sulfuric acid 33482) EPA-OTS Toxic chemical release reporting: Yes EPA 1995b (54 FR community-right-to-know, 33482) sulfuric acid Guidelines: a. Air: ACGIH TLV TWA Sulfuric acid 1 mg/m’ ACGIH 1996 TLV STEL Sulfuric acid 3 mg/m’ ACGIH 1996 Carcinogen classification A2° ACGIH 1996 NIOSH REL TWA Sulfuric acid 1 mg/m’ NIOSH 1994b STATE® Regulations: a. Air: Acceptable ambient air concen- NATICH 1996 trations for sulfur trioxides: Arizona (1-hour) 1300 pg/m’ (24-hour) 365 pg/m’ Acceptable ambient air concen- NATICH 1996 trations for sulfuric acid: Arizona (1-hour) 22.5 pg/m’ (24-hour) 7.5 pg/m® Connecticut (8-hour) 20 pg/m’ Kansas (annual) 2.38 ug/m’ Louisiana (8-hour) 23.8 pg/m’ Maine (15-minute) 300 pg/m’ SULFUR TRIOXIDE AND SULFURIC ACID 160 7. REGULATIONS AND ADVISORIES TABLE 7-1 (continued) Agency Description Information References STATE (Cont.) (24-hour) 17 pg/m? Massachusetts (24-hour) 2.72 pg/m’ (annual) 2.72 pg/m’ Nevada (8-hour) 24 pg/m? North Carolina (1-hour) 100 pg/m? (24-hour) 12 pg/m? North Dakota (1-hour) 30 pg/m? (8-hour) 10 pg/m’ Oklahoma (24-hour) 100 pg/m’® South Carolina (24-hour) 10 pg/m’ Vermont (24-hour) 23.8 pug/m’ Virginia (24-hour) 17 pg/m? Washington (24-hour) 3.3 pg/m’ Wisconsin (24-hour) 24 pg/m? ‘The Working Group on the Evaluation of Carcinogenic Risks to Humans concluded that there is sufficient evidence that occupational exposure to strong inorganic acid mists containing sulfuric acid is carcinogenic. *Group A2: suspected human carcinogen ‘State regulations are not necessarily applied state-wide. For specific information as to the areas affected by the regulations refer to NATICH 1996. ACGIH = American Conference of Governmental Industrial Hygienists; CERCLA = Comprehensive Environ- mental Response, Compensation, and Liability Act; DOT = Department of Transportation; EPA = Environmental Protection Agency; FR = Federal Register; IARC = International Agency for Research on Cancer; NIOSH = National Institute for Occupational Safety and Health; OSHA = Occupational Safety and Health Administration; OSW = Office of Solid Wastes; OTS = Office of Toxic Substances; PEL = Permissible Exposure Limit; REL = Recommended Exposure Limit; STEL = Short Term Exposure Limit; TLV = Threshold Limit Value; TPQ = Threshold Planning Quantity; TWA = Time-Weighted Average ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 161 8. REFERENCES *Abbey DE, Lebowitz MD, Mills PK, et al. 1995. Long-term ambient concentrations of particulates and oxidants and development of chronic disease in a cohort of nonsmoking California residents. Inhalation Toxicology 7:19-34. * Abbey DE, Petersen FF, Mills PK, et al. 1993. Chronic respiratory disease associated with long term ambient concentrations of sulfates and other air pollutants. J Expo Anal Environ Epidemiol 3(suppl 1):99-115. ACGIH. 1991. Documentation of the threshold limit values and biological exposure indices. 6th ed. American Conference of Governmental Industrial Hygienists. Cincinnati, OH. 1461-1463. * ACGIH. 1996. 1996 TLVs and BEIs threshold limit values for chemical substances and physical agents: Biological exposure indices. American Conference of Governmental Industrial Hygienists. Cincinnati, OH. *Ahlborg G Jr, Hogstedt C, Sundell L, et al. 1981. Laryngeal cancer and pickling house vapors. Scand J Work Env Health 7:239-240. AIHA. 1989. Oleum, sulfur trioxide, and sulfuric acid. Emergency Response Planning Guidelines. American Industrial Hygiene Association, Fairfax, VA. *Aktug T, Olguner M, Akgur FM. 1995. A case of gastric cicatrization caused by ingestion of sulfuric acid, treated with Hunt-Lawrence jejunal pouch substitution for the stomach. J Pediatr Surg 30:1376-1377. *Alarie Y, Busey WM, Krumm AA, et al. 1973. Long-term continuous exposure to sulfuric acid mist in cynomolgus monkeys and guinea pigs. Arch Environ Health 27:16-24. *Alarie YC, Krumm AA, Busey WM, et al. 1975. Long-term exposure to sulfur dioxide, sulfuric acid mist, fly ash, and their mixtures. Arch Environ Health 30:254-262. * Albert RE, Alessandro D, Lippmann M, et al. 1971. Long-term smoking in the donkey. Arch Environ Health 22:12-19. * Alderson MR, Rattan NS. 1980. Mortality of workers on an isopropyl alcohol plant and two MEK dewaxing plants. Br J Ind Med 37:85-89. *Altshuller AP. 1973. Atmospheric sulfur dioxide and sulfate: Distribution of concentration at urban and nonurban sites in United States. Environmental Science and Technology 7:709-712. * Amdur MO. 1954. Effect of a combination of SO, and H,SO, on guinea pigs. Public Health Rep 69:503-506. *Cited in text ***DRAFT FOR PUBLIC COMMENT"*** SULFUR TRIOXIDE AND SULFURIC ACID 162 8. REFERENCES *Amdur MO. 1958. The respiratory response of guinea pigs to sulfuric acid mist. Arch Ind Health 18:407-414. *Amdur MO. 1959. The physiological response of guinea pigs to atmospheric pollutants. Int J Air Poll 1:170-183. *Amdur MO. 1989a. Health effects of air pollutants: Sulfuric acid, the old and the new. Environ Health Perspect 81:109-113. *Amdur MO. 1989b. Sulfuric acid: The animals tried to tell us. Appl Ind Hyg 4:189-197. Amdur MO, Chen LC. 1989. Furnace-generated acid aerosols: Speciation and pulmonary effects. Environ Health Perspect 79:147-150. *Amdur MO, Dubriel M, Creasia DA. 1978. Respiratory response of guinea pigs to low levels of sulfuric acid. Environ Res 15:418-423. *Amdur MO, Sarofim AF, Neville M, et al. 1986. Coal combustion aerosols and SO,: An interdisciplinary analysis. Environmental Science and Technology 20:138-145. *Amdur MO, Schulz RZ, Drinker P. 1952a. Toxicity of sulfuric acid mist to guinea pigs. AMA Archives of Industrial Hygiene and Occupational Medicine 5:318-329. *Amdur MO, Silverman L, Drinker P. 1952b. Inhalation of sulfuric acid mist by human subjects. AMA Archives of Industrial Hygiene and Occupational Medicine 6:305-313. *Andersen ME, Krishnan K. 1994. Relating in vitro to in vivo exposures with physiologically based tissue dosimetry and tissue response models. In: Salem H, ed. Animal test alternatives: Refinement, reduction, replacement. New York, NY: Marcel Dekker, Inc., 9-25. *Andersen ME, Clewell HJ III, Gargas ML, et al. 1987. Physiologically based pharmacokinetics and the risk assessment process for methylene chloride. Toxicol Appl Pharmacol 87:185-205. *Anderson KR, Avol EL, Edwards SA, et al. 1992. Controlled exposures of volunteers to respirable carbon and sulfuric acid aerosols. J Air Waste Manage Assoc 42:770-776. *Appel BR, Tanner RL, Adams DF, et al. 1987. Semi-continuous determination of atmospheric particulate sulfur, sulfuric acid and ammonium sulfates (Method 713). In: Lodge JP, ed. Methods of air sampling and analysis. 3rd ed. Chelsea, MI: Lewis Publishers, Inc. 529-532. *Aris R, Christian D, Sheppard D, et al. 1991. Lack of bronchoconstrictor response to sulfuric acid aerosols and fogs. Am Rev Respir Dis 143:744-750. *ATSDR. 1989. Agency for Toxic Substances and Disease Registry. Decision guideline for identifying substance-specific data needs related to toxicological profiles. Part V. Federal Register. *ATSDR. 1990. Toxicological profile for ammonia. US Department of Health and Human Services, Public Health Service, Agency for Toxic Substances and Disease Registry. TP-90-3. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 163 8. REFERENCES *ATSDR. 1997. Toxicological profile for sulfur dioxide. US Department of Health and Human Services, Public Health Service, Agency for Toxic Substances and Disease Registry (in preparation). * ATSDR/CDC. 1990. Subcommittee report on biological indicators of organ damage. Agency for Toxic Substances and Disease Registry, Centers for Disease Control and Prevention, Atlanta, GA. *Avol EL, Linn WS, Shamoo DA. 1990. Respiratory responses of young asthmatic volunteers in controlled exposures to sulfuric acid aerosol. Am Rev Respir Dis 142:343-348. *Avol EL, Linn WS, Whynot JD, et al. 1988. Respiratory dose-response study of normal and asthmatic volunteers exposed to sulfuric acid aerosols in the sub-micrometer size range. Toxicol Ind Health 4:173-184. *Barnes DG, Dourson M. 1988. Reference dose (RfD): Description and use in health risk assessment. Regul Toxicol Pharmacol 8:471-486. *Bates DV, Sizto R. 1987. Air pollution and hospital admissions in Southern Ontario: The acid summer haze effect. Environ Res 43:317-331. *Beaumont JJ, Leveton J, Knox K, et al. 1987. Lung cancer mortality in workers exposed to sulfuric acid mist and other acid mists. J Natl Cancer Inst 79:911-921. *Botham PA, Hall TJ, Dennett R, et al. 1992. The skin corrosivity test in vitro. Results of an inter- laboratory trial. Toxic in Vitro 6:191-194. *Bowes SM III, Francis M, Laube BL, et al. 1995. Acute exposure to acid fog: Influence of breathing pattern on effective dose. Am Ind Hyg Assoc J 56:143-150. *Branday J, Arscott GDL, Smoot EC, et al. 1996. Chemical burns as assault injuries in Jamaica. Burns 22:154-155. *Brauer M, Koutrakis P, Spengler JD. 1989. Personal exposures to acidic aerosols and gases. Environmental Science and Technology 23:1408-1412. *Bronstein AC, Currance PL. 1988. Emergency care for hazardous materials exposure. St. Louis, MO: The C.V. Mosby Company, 111-112. *Budavari S, ed. 1989. The Merck index. 11th ed. Rahway, NJ: Merck and Co., Inc. 8953-8954 *C&EN (Chemical and Engineering News). 1996. Top 50 chemicals: Organics outpaced inorganics as production of chemicals rose overall. Chemical and Engineering News June 24, 1996. *Capdevielle MC, Scanes CG. 1995a. Effect of dietary acid or aluminum on growth and growth- related hormones in mallard ducklings (Anas platyrhynchos). Arch Environ Contam Toxicol 29:462- 468. *Capdevielle MC, Scanes CG. 1995b. Effect of dietary acid or aluminum on growth and growth- related hormones in young chickens. Toxicol Appl Pharmacol 133:164-171. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 164 8. REFERENCES *Carabine MD, Maddock JEL. 1976. The growth of sulphuric acid aerosol particles when contacted with water vapour. Atmos Environ 10:735-742. *Cavender FL, Steinhagen WH, Ulrich CE, et al. 1977. Effects in rats and guinea pigs of short-term exposures to sulfuric acid mist, ozone, and their combination. J Toxicol Environ Health 35:521-533. *Chen LC, Schlesinger RB. 1983. Response of the bronchial mucociliary clearance system in rabbits exposed to inhaled sulfite and sulfuric acid aerosols. Toxicol Appl Pharmacol 70:123-131. *Chen LC, Fang CP, Qu QS, et al. 1993. A novel system for the in vitro exposure of pulmonary cells to acid sulfate aerosols. Fundam Appl Toxicol 20:170-176. *Chen LC, Fine JM, Qu QS, et al. 1992a. Effects of fine and ultrafine sulfuric acid aerosols in guinea pigs: Alterations in alveolar macrophage function and intracellular pH. Toxicol Appl Pharmacol 113:109-117. *Chen LC, Miller PD, Amdur MO, et al. 1992b. Airway hyperresponsiveness in guinea pigs exposed to acid-coated ultrafine particles. J Toxicol Environ Health 35:165-174. Chen LC, Miller PD, Lam HF, et al. 1991. Sulfuric acid-layered ultrafine particles potentiate ozone- induced airway injury. J Toxicol Environ Health 34:337-352. *Chen LC, Qu Q, Amdur MO, et al. 1995. Alteration of pulmonary macrophage intracellular pH following inhalation exposure to sulfuric acid/ozone mixtures. Exp Lung Res 21:113-128. *Cifone MA, Myhr B, Eiche A, et al. 1987. Effect of pH shift on the mutant frequency at the thymidine kinase locus in mouse lymphoma L5178Y*" cells. Mutat Res 189:39-46. *Cipollaro M, Corsale, G, Esposito A, et al. 1986. Sublethal pH decrease may cause genetic damage to eukaryotic cell: A study on sea urchins and Salmonella typhimurium. Teratog Carcinog Mutagen 6:275-287. *Clark KW, Anderson KR, Linn WS, et al. 1995. Influences of breathing-zone ammonia on human exposures to acid aerosol pollution. J Air Waste Manage Assoc 45:923-925. *Clewell HJ III, Andersen ME. 1985. Risk assessment extrapolations and physiological modeling. Toxicol Ind Health 1:111-131. *Cockrell BY, Busey WM, Cavender FL. 1978. Respiratory tract lesions in guinea pigs exposed to sulfuric acid mist. J Toxicol Environ Health 4:835-844. *Coggon D, Pannett B, Wield G. 1996. Upper aerodigestive cancer in battery manufacturers and steel workers exposed to mineral acid mists. Occup Environ Med 53:445-449. *Cohen BS. 1997. Distribution of H+ and trace metals in ultrafine ambient aerosol. http://es.inel.gov:80/ncerqa/grants/air/aircoh/html. *Costa DL, Amdur MO. 1996. Air pollution. In: Klaassen CD, ed. Casarett and Doull’s toxicology The basic science of poisons, fifth ed. New York: McGraw-Hill, 857-882. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 165 8. REFERENCES *CRISP. 1996. Computer Retrieval of Information on Science Projects. National Library of Medicine, National Institutes of Health, Bethesda, MD. *Culp DJ, Latchney LR, Frampton MW, et al. 1995. Composition of human airway mucins and effects after inhalation of acid aerosols. Am J Physiol 269:L358-L370. *Cyrys J, Gutschmidt K, Brauer M, et al. 1995. Determination of acidic sulfate aerosols in urban atmospheres in Erfurt (F.R.G.) and Sokolov (former C.S.S.R.). Atmos Environ 23:3545-3557. *Dahl AR, Felicetti SA, Muggenburg BA. 1983. Clearance of sulfuric acid-introduced *°S from the respiratory tracts of rats, guinea pigs and dogs following inhalation or instillation. Fundam Appl Toxicol 3:293-297. *Demerec M, Bertani G, Flint J. 1951. A survey of chemicals for mutagenic action on E. coli. The American Naturalist 85:119-136. *Dilawari JB, Singh S, Rao PN, et al. 1984. Corrosive acid ingestion in man - a clinical and endoscopic study. Gut 25:183-187. *DHHS. 1994. Seventh annual report on carcinogens U.S. Department of Health and Human Services, Public Health Service, National Toxicology Program, National Institute of Environmental Health Services, Research Triangle Park, NC. *DOT. 1996. Purpose and use of hazardous materials table. Department of Transportation. Code of Federal Regulations 49 CFR 172.101. *Dutkiewicz VA, Burkhard EG, Husain L. 1995. Availability of H,O, for oxidation of SO, in clouds in the northeastern United States. Atmos Environ 29:3281-3292. *El-Fawal HAN, Schlesinger RB. 1994. Nonspecific airway hyperresponsiveness induced by inhalation exposure to sulfuric acid aerosol: An in vitro assessment. Toxicol Appl Pharmacol 125:70- 76. *El-Fawal HAN, McGovern T, Schlesinger RB. 1995. Nonspecific bronchial responsiveness assessed in vitro following acute inhalation exposure to ozone and ozone/sulfuric acid mixtures. Exp Lung Res 21:129-139. *El-Sadik Y, Osman HA, El-Gazzar RM. 1972. Exposure to sulfuric acid in manufacture of storage batteries. J Occup Med 14:224-226. *Ellenhorn MJ, Barceloux DG. 1988. Medical toxicology: Diagnosis and treatment of human poisoning. New York, NY: Elsevier, 924-929. *Englander V, Sjoberg A, Hagmar L, et al. 1988. Mortality and cancer morbidity in workers exposed to sulphur dioxide in a sulphuric acid plant. Int Arch Occup Environ Health 61:157-162. *EPA. 1985. The acidic deposition phenomenon and its effects: Critical assessment document. United States Environmental Protection Agency, Office of Acid Deposition, Environmental Monitoring, and Quality Assurance, Washington, DC. EPA/600/8-85/001. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 166 8. REFERENCES *EPA. 1988. Quality assurance handbook for air pollution measurement systems: Volume III. stationary sources specific methods. Section 3.7. U.S. Environmental Protection Agency, Environmental Monitoring Systems Laboratory, Research Triangle Park NC. EPA/600/4-77/-27b. *EPA. 1990. Interim methods for development of inhalation reference doses. U.S. Environmental Protection Agency, Office of Research and Development. Washington, DC. EPA 600/8-90-066A. *EPA. 1993. Methods for the determination of inorganic substances in environmental samples. United States Environmental Protection Agency, Office of Research and Development, Washington, DC. EPA/600/8-93/100. Methods 300.0 and 375.2. *EPA. 1994. Methods for derivation of inhalation reference concentrations and application of inhalation dosimetry. Environmental Criteria and Assessment Office, Office of Health and Environment Assessment, Office of Research and Development, U.S. Environmental Protection Agency, Research Triangle Park, NC. EPA/600/8-90-066F. *EPA. 1995a. National air pollutant emission trends, 1900-1994. U.S. Environmental Protection Agency, Office of Air Quality Planning and Standards, Research Triangle Park, NC. EPA-454/R-95-011. *EPA. 1995b. Methods [1-14]. Appendix A. U.S. Environmental Protection Agency. Code of Federal Regulations 40 CFR 60, Test *EPA. 1996a. Table 116.4B - List of hazardous substances by CAS numbers. Environmental Protection Agency. Code of Federal Regulations 40 CFR 116. “EPA. 1996b. Subpart D - Exemptions from the requirement of a tolerance. Environmental Protection Agency. Code of Federal Regulations 40 CFR 180.1001. *EPA. 1996¢c. Sulfuric acid; exemption from the requirement of a tolerance. Environmental Protection Agency. Code of Federal Regulations 40 CFR 180.1019. *EPA. 1996d. The list of extremely hazardous substances and their threshold planning quantities. Environmental Protection Agency. Code of Federal Regulations 40 CFR 355 (Appendix A). Farely JM. 1992. Inhaled toxicants and airway hyperresponsiveness. Annu Rev Pharmacol Toxicol 32:67-88. *FEDRIP. 1996. Federal Research in Progress. National Technical Information Service, Springfield, VA. *Fine JM, Gordon T, Thompson JE, et al. 1987. The role of titratable acidity in acid aerosol-induced bronchoconstriction. Am Rev Respir Dis 135:826-830. *Forastiere F, Valesini S, Salimei E, et al. 1987. Respiratory cancer among soap production workers. Scand J Work Environ Health 13:258-269. *Frampton MW, Morrow PE, Cox C, et al. 1995. Sulfuric acid aerosol followed by ozone exposure in healthy and asthmatic subjects. Environ Res 69:1-14. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 167 8. REFERENCES *Frampton MW, Voter KZ, Roberts NJ, et al. 1992. Sulfuric acid aerosol exposure in humans assessed by bronchoalveolar lavage. Am Rev Respir Dis 146:626-632. *FSTRAC. 1990. Summary of state and federal drinking water standards and guidelines. Prepared by chemical communication subcommittee. Federal State Toxicology and Regulatory Alliance Committee. *Fujimaki H, Katayama N, Wakamori K. 1992. Enhanced histamine release from lung mast cells of guinea pigs exposed to sulfuric acid aerosols. Environ Res 58:117-123. *Fung CS, Misra PK, Bloxam R, et al. 1991. A numerical experiment on the relative importance of H,0, and O; in aqueous conversion of SO, to SO. Atmos Environ 25A:411-423. *Gamble J, Jones W, Hancock J. 1984a. Epidemiological-environmental study of lead-acid battery workers: II. Acute effects of sulfuric acid on the respiratory system. Environ Res 35:11-29. *Gamble J, Jones W, Hancock J, et al. 1984b. Epidemiological-environmental study of lead-acid battery workers: III. Chronic effects of sulfuric acid on the respiratory system and teeth. Environ Res 35:30-52. *Gearhart JM, Schlesinger RB. 1986. Sulfuric acid-induced airway hyperresponsiveness. Fundam Appl Toxicol 7:681-689. Gearhart JM, Schlesinger RB. 1989. Sulfuric acid-induced changes in the physiology and structure of the tracheobronchial airways. Environ Health Perspect 79:127-137. *Gosselin RE, Smith RP, Hodge HC. 1984. Clinical toxicology of commercial products, 5th ed. Baltimore, MD: Williams & Wilkins, I1I-8—IIT12. *Grant WM. 1974. Sulfuric acid. In: Toxicology of the eye. 2nd ed. Springfield, IL: Charles C. Thomas. 959-960. *Grose EC, Richards JH, Illing JW, et al. 1982. Pulmonary host defense responses to inhalation of sulfuric acid and ozone. J Toxicol Environ Health 10:351-362. Gunnison AF, Benton AW. 1971. Sulfur dioxide: Sulfite interaction with mammalian serum and plasma. Arch Environ Health 22:381-388. *Haddad LM, Winchester JF. 1990. Clinical management of poisoning and drug overdose, 2nd ed. Philadelphia, PA: W.B. Saunders Company, 379, 1065-10609. *Hanley QS, Koenig JQ, Larson TV, et al. 1992. Response of young asthmatic patients to inhaled sulfuric acid. Am Rev Respir Dis 145:326-331. *HazDat. 1996. Hazardous Substance Database. Agency for Toxic Substances and Disease Registry (ATSDR), Atlanta, GA. *Hensyl WR ed. 1990. Stedman’s medical dictionary, 25th ed. Baltimore, MD: Williams & Wilkins, 1777. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 168 8. REFERENCES *Hillman H. 1989. Kitchen science: A guide to knowing the hows and whys for fun and success in the kitchen. Boston, MA: Houghton Mifflin Company, 137-138. *Hoek G, Mennen MG, Allen GA, et al. 1996. Concentrations of acidic air pollutants in The Netherlands. Atmos Environ 30:3141-3150. *Hofmann DJ. 1990. Increase in the stratospheric background sulfuric acid aerosol mass in the past 10 years. Science 248:996-1000. *Holekamp TLR, Becker B. 1977. Ocular injuries from automobile batteries. Transactions - American Academy of Ophthalmology and Otolaryngology 83:805-810. *Holma B. 1989. Effects of inhaled acids on airway mucus and its consequences for health. Environ Health Perspect 79:109-113. *Holma B. 1985. Influence of buffer capacity and pH-dependent rheological properties of respiratory mucus on health effects due to acidic pollution. Sci Total Environ 41:101-123. *Horvath SM, Folinsbee LJ, Bedi JF. 1987. Combined effect of ozone and sulfuric acid on pulmonary function of man. Am Ind Hyg Assoc J 48:94-98. *Houghton DJ, White PS. 1994. The carcinogenic risk of exposure to sulphuric acid fumes from lead-acid batteries. J Laryngol Otol 108:881-882. *HSDB. 1997. Hazardous Substances Data Bank. National Library of Medicine, Toxicology Information Program, Bethesda, MD. November 1996. *HSEES. 1997. Hazardous substances emergency events surveillance. U.S. Department of Health and Human Services, Public Health Service, Agency for Toxic Substances and Disease Registry, Atlanta, Georgia. *JARC. 1992. Occupational exposures to mists and vapours from sulfuric acid and other strong inorganic acids. IARC Monogr Eval Carcinogen Risk Chem Hum 54:41-130. *Ichinose T, Sagai M. 1992. Combined exposure to nitrogen dioxide, ozone and sulfuric acid-aerosol and lung tumor formation in rats. Toxicology 74:173-184. *IRIS. 1996. Integrated Risk Information Systems. U.S. Environmental Protection Agency. Office of Health and Environmental Assessment, Environmental Criteria and Assessment Office, Cincinnati, OH. December 1996. *Jacobs GA. 1992. OECD eye irritation tests on two strong acids. J Am Coll Toxicol 11:734. *Jones W, Gamble J. 1984. Epidemiological - environmental study of lead-acid battery workers I. Environmental study of five lead-acid battery plants. Environ Res 35:1-10. *Kato N, Akimoto H. 1992. Anthropogenic emissions of SO, and NO, in Asia: Emission inventories. Atmos Environ 26A:2997-3017. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 169 8. REFERENCES *Kellogg WW, Cadle RD, Allen ER, et al. 1972. The sulfur cycle. Science 175:587-596. Kerminen V-M, Wexler AS. 1996. The occurrence of sulfuric acid-water nucleation in plumes: Urban environment. Tellus 45B:65-82. Khwajy HA, Brudnoy S, Husain L. 1995. Chemical characterization of three summer cloud episodes at Whiteface Mountain. Chemosphere 31:3357-3381. *Kimmel TA, Chen LC, Bosland MC, et al. 1997. Influence of acid aerosol droplet size on structural changes in the rat lung caused by acute exposure to sulfuric and ozone. Toxicol Appl Pharmacol 144:348-355. *Kitagawa T. 1984. Cause analysis of the Yokkaichi asthma episode in Japan. JAPCA 34:743-746. *Kleinman LI, Daum PH. 1991. Oxidant limitation to the formation of H,SO, near a SO, source region. Atmos Environ 25A:2023-2028. *Kleinman MT, Bailey RM, Chang Y-TC, et al. 1981. Exposures of human volunteers to a controlled atmospheric mixture of ozone, sulfur dioxide and sulfuric acid. Am Ind Hyg Assoc J 42:61-69. *Knapp KT, Pierson WR, Dasgupta PK, et al. 1987. Determination of gaseous sulfuric acid and sulfur dioxide in stack gases. In Lodge JP, ed. Methods of air sampling and analysis (Method 711). 3rd ed. Chelsea, MI: Lewis Publishers, Inc. 523-528. *Knapp MJ, Bunn WB, Stave GM. 1991. Adult respiratory distress syndrome from sulfuric acid fume inhalation. South Med J 84:1031-1033. *Kobayashi T, Shinozaki Y. 1993. Effects of sulfuric acid-aerosol on airway responsiveness in guinea pigs: Concentration and time dependency. J Toxicol Environ Health 39:261-272. *Koenig JQ, Covert DS, Larson TV, et al. 1992. The effect of duration on sulfuric acid-induced pulmonary function changes in asthmatic adolescent subjects: A dose-response study. Toxicol Ind Health 8:285-296. *Koenig JQ, Dumler K, Rebolledo V, et al. 1993. Respiratory effects of inhaled sulfuric acid on senior asthmatics and nonasthmatics. Arch Environ Health 48:171-175. *Koenig JQ, Morgan MS, Horike M, et al. 1985. The effects of sulfur oxides on nasal and lung function in adolescents with extrinsic asthma. J Allergy Clin Immunol 76:813-818. *Koutrakis P, Fasano AM, Slater JL, et al. 1989. Design of a personal annular denuder sampler to measure atmospheric aerosols and gases. Atmos Environ 23:2767-2773. *Koutrakis P, Wolfson JM, Slater JL, et al. 1988. Evaluation of an annular denuder/filter pack system to collect acidic aerosols and gases. Environmental Science and Technology 22:1463-1468. *Kremer AM, Pal TM, Boleij JSM, et al. 1994. Airway hyperresponsiveness, prevalence of chronic respiratory symptoms, and lung function in workers exposed to irritants. Occup Environ Med 51:3-13. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 170 8. REFERENCES *Krishnan K, Andersen ME. 1994. Physiologically based pharmacokinetic modeling in toxicology. In: Hayes W, ed. Principles and methods of toxicology. 3rd ed. New York, NY: Raven Press, Ltd., 149-188. *Krishnan K, Andersen ME, Clewell HJ III, et al. 1994. Physiologically based pharmacokinetic modeling of chemical mixtures. In: Yang, RSA, ed. Toxicology of chemical mixtures. New York, NY: Academic Press, 399-437. *Kulle TJ, Kerr DH, Farrell BP, et al. 1982. Pulmonary function and bronchial reactivity in human subjects with exposure to ozone and respirable sulfuric acid aerosol. Am Rev Respir Dis 126:996- 1000. Kulmala M, Kerminen V-M, Laaksonen A. 1995. Simulations on the effect of sulphuric acid formation on atmospheric aerosol concentrations. Atmos Environ 29:377-382. Last JA. 1991. Global atmospheric change: Potential health effects of acid aerosol and oxidant gas mixture. Environ Health Perspect 96:151-157. *Last JA, Warren DL. 1987. Synergistic interaction between nitrogen dioxide and respirable aerosols of sulfuric acid or sodium chloride on rat lungs. Toxicol Appl Pharmacol 90:34-42. *Laube BL, Bowes SM III, Links JM, et al. 1993. Acute exposure to acid fog effects on mucociliary clearance. Am Rev Respir Dis 147:1105-111. *Leaderer BP, Boone PM, Hammond SK. 1990. Total particle, sulfate, and acidic aerosol emissions from kerosene space heaters. Environmental Science and Technology 24:908-912. *LeBoeuf RA, Kerckaert GA. 1986. The induction of transformed-like morphology and enhanced growth in Syrian hamster embryo cells grown at acidic pH. Carcinogenesis 7:1431-1440. *Lee MM, Schurch S, Roth SH, et al. 1995. Effects of acid aerosol exposure on the surface properties of airway mucus. Exp Lung Res 21:835-851. *Leikauf GD, Spektor DM, Albert RE, et al. 1984. Dose-dependent effects of submicrometer sulfuric acid aerosol on particle clearance from ciliated human lung airways. Am Ind Hyg Assoc J 45:285-292. *Leikauf G, Yeates DB, Wales KA, et al. 1981. Effects of sulfuric acid aerosol on respiratory mechanics and mucociliary particle clearance in healthy nonsmoking adults. Am Ind Hyg Assoc J 42:273-282. *Leung H-W. 1993. Physiologically-based pharmacokinetic modeling. In: Ballantyne B, Marrs T, Turner P, eds. General and applied toxicology. New York, NY: Stockton Press, 1:153-164. *Lewis TR, Campbell KI, Vaughan TR. 1969. Effects on canine pulmonary function. Via induced NO, impairment, particulate interaction, and subsequent SO,. Arch Environ Health 18:596-601. *Linn WS, Anderson KR, Shamoo DA, et al. 1995. Controlled exposures of young asthmatics to mixed oxidant gases and acid aerosol. Am J Respir Crit Care Med 152:885-891. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 171 8. REFERENCES *Linn WS, Avol EL, Shamoo DA, et al. 1986. Respiratory responses of exercising asthmatic volunteers exposed to sulfuric acid aerosol. J Air Poll Control Assoc 36:1323-1328. *Linn WS, Shamoo DA, Anderson KR, et al. 1994. Effects of prolonged, repeated exposure to ozone, sulfuric acid, and their combination in healthy and asthmatic volunteers. Am J Resp Crit Care Med 150:431-440. *Lioy PJ, Waldman JM. 1989. Acidic sulfate aerosols: Characterization and exposure. Environ Health Perspect 79:15-34. *Lipfert FW, Morris SC, Wyzga RE. 1989. Acid aerosols: The next criteria air pollutant? Environmental Science and Technology, 23:1316-1322. Lippmann M. 1985. Airborne acidity: Estimates of exposure and human health effects. Environ Health Perspect 63:63-70. *Lippmann M, Gearhart JM, Schlesinger RB. 1987. Basis for a particle size-selective TLV for sulfuric acid aerosols. Appl Ind Hyg 2:188-199. *Lippmann M, Schlesinger RB, Leikauf G, et al. 1982. Effects of sulphuric acid aerosols on respiratory tract airways. Ann Occup Hyg 26:677-690. Lui L-J, Burton R, Wilson WE, et al. 1996. Comparison of acid aerosol acidity in urban and semi- rural environments. Atmos Environ 30:1237-1245. Maddalone RF. 1984. Guidelines for combustion source sulphuric acid emission measurements. Indian J Environmental Protection 4:93-99. *Malcolm D, Paul E. 1961. Erosion of the teeth due to sulphuric acid in the battery industry. Brit J Ind Med 18:63-69. *Mannix RC, Phalen RF, Nguyen TN. 1991. Effects of sulfuric acid on ferret respiratory tract clearance. Inhalation Toxicology 3:277-291. *Martonen TB, Patel M. 1981. Modeling the dose distribution of H,SO, aerosols in the human tracheobronchial tree. Am Ind Hyg Assoc J 42:453-460. *Martonen TB, Zhang Z. 1993. Deposition of sulfate acid aerosols in the developing human lung. Inhalation Toxicology 5:165-187. *Mautz W, Finlayson-Pitts BJ, Messer K, et al. 1991. Effects of ozone combined with components of acid fogs on breathing pattern, metabolic rate, pulmonary surfactant composition, and lung injury in rats. Inhalation Toxicology 3:1-25. *Morita T, Watanabe Y, Takeda K, et al. 1989. Effects of pH in the in vitro chromosomal aberration test. Mutat Res 225:55-60. *Murphy JC, Osterberg RE, Seabaugh VM, et al. 1982. Ocular irritancy responses to various pHs of acids and bases with and without irrigation. Toxicology 23:281-291. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 172 8. REFERENCES *Murray FJ, Schwetz BA, Nitschke KD, et al. 1979. Embryotoxicity of inhaled sulfuric acid aerosol in mice and rabbits. J Environ Sci Health C13:251-266. *NAS/NRC. 1989. Biologic markers in reproductive toxicology. National Academy of Sciences/National Research Council. Washington, DC: National Academy Press, 15-35. *NATICH. 1996. National Air Toxics Information Clearinghouse Database. Environmental Protection Agency, Research Triangle Park, NC. November 1996. *Newhouse MT, Dolovich M, Obminski G, et al. 1978. Effect of TLV levels of SO, and H,SO, on bronchial clearance in exercising man. Arch Environ Health 33:24-32. *NIOSH. 1977. National Institute of Occupational Health and Safety. NIOSH manual of analytical methods, volume 1, method 187. *NIOSH. 1979. National Institute of Occupational Health and Safety. NIOSH manual of analytical methods, volume 7, method 261. *NIOSH. 1994a. Manual of Analytical Methods. 4th ed. Cincinnati, OH: U.S. Department of Health and Human Services, Public Health Service, Centers for Disease Control, National Institute for Occupational Safety and Health. Method 7903. *NIOSH. 1994b. Pocket guide to chemical hazards. Cincinnati, OH: National Institute for Occupational Safety and Health. 290-291. *Nixon GA, Tyson, CA, Wertz WC. 1975. Interspecies comparisons of skin irritancy. Toxicol Appl Pharmacol 31:481-490. *NOES. 1990. National Occupational Exposure Survey (1981-1983). U.S. Department of Health and Human Services, National Institute for Occupational Safety and Health, Cincinnati, OH. July 1, 1990. *NTDB. 1996. National Trade Data Bank. Washington, DC: U.S. Department of Commerce, Economics and Statistics Administration (CD-ROM). *OSHA. 1996. Occupational Safety and Health Administration. Code of Federal Regulations 29 CFR 1910.1000. *OTA. 1990. Neurotoxicity: Identifying and controlling poisons of the nervous system. Office of Technology Assessment, Washington, DC. OTA-BA-438. *Ozkaynak H, Xue J, Zhou H, Spengler JD, et al. 1996. Intercommunity differences in acid aerosol (H")/sulfate (SO,*) ratios. J Expo Anal Environ Epidemiol 6:35-55. *Pattle RE, Burgess F, Cullumbine H. 1956. The effects of a cold environment and of ammonia on the toxicity of sulphuric acid mist to guinea pigs. J Pathio Bacteriol 72:219-232. *Pienaar JJ, Helas G. 1996. The kinetics of chemical processes affecting acidity in the atmosphere. South African Journal of Science 92:128-132. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 173 8. REFERENCES *Pierson WR, Brachaczek WW, Gorse RA, et al. 1987a. Acid rain and atmospheric chemistry at Allegheny Mountain. Environmental Science and Technology 21:679-691. Pierson WR, Dasgupta PK, Adams DF, et al. 1987b. Determination of airborne sulfates (Method 824). In Lodge JP, ed. Methods of air sampling and analysis. 3rd ed. Chelsea, MI: Lewis Publishers, Inc. 639-644. *Qu QS, Chen LC, Gordon T, et al. 1993. Alteration of pulmonary macrophage intracellular pH regulation by sulfuric acid aerosol exposures. Toxicol Appl Pharmacol 121:138-143. Raabe OG, Wilson DW, Al-Bayati MA, et al. 1994. Biological effects of inhaled pollutant aerosols. Ann Occup Hyg 38(suppl 1):323-330. Ruth JH. 1986. Odor thresholds and irritation levels of several chemicals substances: A review. Am Ind Hyg Assoc J 47:A142-A151. *Schlesinger RB. 1987. Functional assessment of rabbit alveolar macrophages following intermittent inhalation exposures to sulfuric acid mist. Fundam Appl Toxicol 8:328-334. Schlesinger RB. 1989. Factors affecting the response of lung clearance systems to acid aerosols: Role of exposure concentration, exposure time, and relative acidity. Environ Health Perspect 79:121-126. *Schlesinger RB. 1990a. Exposure-response pattern for sulfuric acid-induced effects on particle clearance from the respiratory region of rabbit lungs. Inhalation Toxicology 2:21-27. Schlesinger RB. 1990b. The interaction of inhaled toxicants with respiratory tract clearance mechanisms. Crit Rev Toxicol 20:257-286. *Schlesinger RB, Gearhart JM. 1986. Early alveolar clearance in rabbits intermittently exposed to sulfuric acid mist. J Toxicol Environ Health 17:213-220. *Schlesinger RB, Chen L-C, Drisoll KE. 1984. Exposure-response relationship of bronchial mucociliary clearance in rabbits following acute inhalations of sulfuric acid mist. Toxicol Lett 22:249- 254. *Schlesinger RB, Chen L-C, Finkelstein I, et al. 1990a. Comparative potency of inhaled acidic sulfates: Speciation and the role of the hydrogen ion. Environ Res 52:210-224. *Schlesinger RB, Gorczynski JE, Dennison J, et al. 1992a. Long-term intermittent exposure to sulfuric acid aerosol, ozone, and their combination: Alterations in tracheobronchial mucociliary clearance and epithelial secretory cells. Exp Lung Res 18:505-534. *Schlesinger RB, Gunnison AF, Zelikoff JT. 1990b. Modulation of pulmonary eicosanoid metabolism following exposure to sulfuric acid. Fundam Appl Toxicol 15:151-162. *Schlesinger RB, Halpern M, Albert RE, et al. 1979. Effect of chronic inhalation of sulfuric acid mist upon mucociliary clearance from the lungs of donkeys. J Environ Pathol Toxicol 2:1351-1367. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 174 8. REFERENCES *Schlesinger RB, Zelikoff JT, Chen LC, et al. 1992b. Assessment of toxicologic interactions resulting from acute inhalation exposure to sulfuric acid and ozone mixtures. Toxicol Appl Pharmacol 115:183-190. *Schultz G, Henkind P, Gross EM. 1968. Acid burns of the eye. Am J Ophthalmol 66:654-657. *Sekizawa J, Yasuhara K, Suyama Y, et al. 1994. A simple method for screening assessment of skin and eye irritation. J Toxicol Sci 19:25-35. *Shi X. 1994. Generation of SO,” and OH radicals in SO, reactions with inorganic environmental pollutants and its implications to SO,” toxicity. J Inorg Biochem 56:155-165. *Shimada T, Ingalls TH. 1975. Chromosome mutations and pH disturbances. Arch Environ Health 30:196-200. *Sim RE, Pattle RE. 1957. Effect of possible smog irritants on human subjects. JAMA 165:1908- 1913. *Simon PK, Dasgupta PK. 1995. Continuous automated measurement of the soluble fraction of atmospheric particulate matter. Anal Chem 67:71-78. *Smyth HF Jr, Carpenter CP, Weil CS, et al. 1969. Range-finding toxicity data: List VIL. Am Ind Hyg Assoc J 30:470-476. *Soskolne CL, Jhangri GS, Siemiatycki J, et al. 1992. Occupational exposure to sulfuric acid in southern Ontario, Canada, in association with laryngeal cancer. Scand J Work Environ Health 18:225- 234. *Soskolne CL, Pagano G, Cipollaro M, et al. 1989. Epidemiologic and toxicologic evidence for chronic health effects and the underlying biologic mechanisms involved in sub-lethal exposures to acidic pollutants. Arch Environ Health 44:180-191. *Soskolne CL, Zeighami EA, Hanis NM, et al. 1984. Laryngeal cancer and occupational exposure to sulfuric acid. Am J Epidemiol 120:358-369. Speizer FE. 1989. Studies of acid aerosols in six cities and in a new multi-city investigation: Design issues. Environ Health Perspect 79:61-67. *Spektor DM, Yen BM, Lippmann M. 1989. Effect of concentration and cumulative exposure of inhaled sulfuric acid on tracheobronchial particle clearance in healthy humans. Environ Health Perspect 79:167-172. *Spengler JD, Braurer M, Koutrakis P. 1990. Acid air and health. Environmental Science and Technology 24:946-956. *Spengler JD, Keeler, GJ, Koutrakis P, et al. 1989. Exposures to acidic aerosols. Environ Health Perspect 79:43-51. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 175 8. REFERENCES *Stacy RW, Seal E Jr, House DE, et al. 1983. A survey of effects of gaseous and aerosol pollutants on pulmonary function of normal males. Arch Environ Health 38:104-115. *Steenland K, Beaumont J. 1989. Further follow-up and adjustment for smoking in a study of lung cancer and acid mists. Am J Ind Med 16:347-354. *Steenland K, Schnorr T, Beaumont J, et al. 1988. Incidence of laryngeal cancer and exposure to acid mists. Br J Ind Med 45:766-776. *Stengel PW, Bendele AM, Cockerham SL, et al. 1993. Sulfuric acid induces hyperresponsiveness to substance P in the guinea pig. Agents Actions 39(special conference issue):C128-C131. *Stucki G, Hanselmann KW, Hurzeler RA. 1993. Biological sulfuric acid transformation: Reactor design and process optimization. Biotechnol Bioeng 41:303-315. *Stueven HA, Coogan P, Valley V. 1993. A hazardous material episode: Sulfur trioxide. Vet Hum Toxicol 35:37-38. *Stutz DR, Ulin S. 1992. Hazardous materials injuries. Beltsville, MD: Bradford Communications Corporation, 176-177, 372-373. *Suh HH, Koutrakis P, Spengler JD. 1993. Validation of personal exposure models for sulfate and aerosol strong acidity. J Air Waste Manage Assoc 43:845-850. *Suh HH, Spengler JD, Koutrakis P. 1992. Personal exposures to acid aerosols and ammonia. Environmental Science and Technology 26:2507-2517. *Takeuchi TL, Suzuki I. 1994. Effect of pH on sulfite oxidation by Thiobacillus thiooxidans cells with sulfurous acid or sulfur dioxide as a possible substrate. Journal of Bacteriol 176:913-916. *Thomas MD, Hendricks RH, Gunn FD, et al. 1958. Prolonged exposure of guinea pigs to sulfuric acid aerosol. AMA Archives of Industrial Hygiene and Occupational Medicine 17:70-80. Thomas RL, Dharmarajan V, Lundquist GL, et al. 1976. Measurement of sulfuric acid aerosol, sulfur trioxide, and the total sulfate content of the ambient air. Anal Chem 48:339-642. *Thurston GD, Ito K, Lippmann M, et al. 1989. Reexamination of London, England, mortality in relation to exposure to acidic aerosols during 1963-1972 winters. Environ Health Perspect 79:73-82. *Treon JF, Dutra FR, Cappel J, et al. 1950. Toxicity of sulfuric acid mist. AMA Archives of Industrial Hygiene and Occupational Medicine 2:716-734. *TRI94. 1996. Toxic Chemical Release Inventory. National Library of Medicine, National Toxicology Program, Bethesda, MD. *Tuominen M. 1991. Occurrence of periodontal pockets and oral soft tissue lesions in relation to sulfuric acid fumes in the working environment. Acta Odontol Scand 49:261-266. "**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 176 8. REFERENCES Utell MJ. 1985. Effects of inhaled acid aerosols on lung mechanics: an analysis of human exposure studies. Environ Health Perspect 63:39-44. *Utell MJ, Frampton MW. 1992. Sulfur dioxide and sulfuric acid aerosols. In: Rom WN, ed. Environmental and occupational medicine, 2nd ed., Boston, MA: Little Brown and Company, 519-527. *Utell MJ, Mariglio JA, Morrow PE, et al. 1989. Effects of inhaled acid aerosols on respiratory function: The role of endogenous ammonia. J Aerosol Med 2:141-147. *Utell MJ, Morrow PE, Hyde RW. 1984. Airway reactivity to sulfate and sulfuric acid aerosols in normal and asthmatic subjects. J Air Pollut Control Assoc 34:931-935. *Utell MJ, Morrow PE, Speers DM, et al. 1983. Airway responses to sulfate and sulfuric acid aerosols in asthmatics. Am Rev Respir Dis 128:444-450. *Vander AJ, Sherman JH, Luciano DS. 1975. Energy and cellular metabolism. In: Human physiology: The mechanisms of body function. New York, NY: McGraw Hill, Inc. 86-88. *Vernot EH, MacEwen JD, Haun CC, et al. 1977. Acute toxicity and skin corrosion data for some organic and inorganic compounds and aqueous solutions. Toxicol Appl Phamacol 42:417-423. Vollmuth TA, Schlesinger RB. 1984. Measurement of respiratory tract ammonia in the rabbit and implications to sulfuric acid inhalation studies. Fund Appl Toxicol 4:455-464. *Waller RE. 1963. Acid droplets in town air. Int J Air Wat Poll 7:773-338. *Warren DL, Last JA. 1987. Synergistic interaction of ozone and respirable aerosols on rat lungs: III. Ozone and sulfuric acid aerosol. Toxicol Appl Pharmacol 88:203-216. *Zeilweger Analytics, Inc. 1996. Single point monitor: Technical note. Zeilweger Analytics, Inc. Lincolnshire, IL. *WHO. 1979. Environmental health criteria 8: Sulfur oxides and suspended particulate matter. World Health Organization. Geneva, Switzerland. *Williams MK. 1970. Sickness absence and ventilatory capacity of workers exposed to sulphuric acid mist. Br J Ind Med 27:61-66. *Witschi HR, Last JA. 1996. Toxic responses of the respiratory system. In: Klaassen CD, ed. Casarett and Doull’s toxicology The basic science of poisons, Sth ed. New York: McGraw-Hill, 443- 462. *Wolff RK, Silbaugh SA, Brownstein DG, et al. 1979. Toxicity of 0.4- and 0.8-pm sulfuric acid aerosols in the guinea pig. J Toxicol Environ Health 5:1037-1047. *Wyzga RE, Folinsbee LJ. 1995. Health effects of acid aerosols. Water Air Soil Pollut 85:177-188. *Xiong JQ, Fang CP, Chen LC, et al. 1997. Influence of organic films on reactivity and hygroscopicity of sulfuric acid aerosol. The Toxicologist 36:1664. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 177 8. REFERENCES *Zelikoff JT, Schlesinger RB. 1992. Modulation of pulmonary immune defense mechanism by sulfuric acid: Effects on macrophage-derived tumor necrosis factor and superoxide. Toxicology 76:271-281. *Zelikoff JT, Sisco MP, Yang Z, et al. 1994. Immunotoxicity of sulfuric acid aerosol: Effects on pulmonary macrophage effector and functional activities critical for maintaining host resistance against infectious diseases. Toxicology 92:269-286. *Zura KD, Grant WF. 1981. The role of the hydronium ion in the induction of chromosomal aberrations by weak acid solutions. Mutat Res 84:349-364. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 179 9. GLOSSARY Acute Exposure—Exposure to a chemical for a duration of 14 days or less, as specified in the Toxicological Profiles. Adsorption Coefficient (K,)—The ratio of the amount of a chemical adsorbed per unit weight of organic carbon in the soil or sediment to the concentration of the chemical in solution at equilibrium. Adsorption Ratio (Kd)—The amount of a chemical adsorbed by a sediment or soil (i.e., the solid phase) divided by the amount of chemical in the solution phase, which is in equilibrium with the solid phase, at a fixed solid/solution ratio. It is generally expressed in micrograms of chemical sorbed per gram of soil or sediment. Bioconcentration Factor (BCF)—The quotient of the concentration of a chemical in aquatic organisms at a specific time or during a discrete time period of exposure divided by the concentration in the surrounding water at the same time or during the same period. Cancer Effect Level (CEL)—The lowest dose of chemical in a study, or group of studies, that produces significant increases in the incidence of cancer (or tumors) between the exposed population and its appropriate control. Carcinogen—A chemical capable of inducing cancer. Ceiling Value—A concentration of a substance that should not be exceeded, even instantaneously. Chronic Exposure—Exposure to a chemical for 365 days or more, as specified in the Toxicological Profiles. Developmental Toxicity—The occurrence of adverse effects on the developing organism that may result from exposure to a chemical prior to conception (either parent), during prenatal development, or postnatally to the time of sexual maturation. Adverse developmental effects may be detected at any point in the life span of the organism. Embryotoxicity and Fetotoxicity—Any toxic effect on the conceptus as a result of prenatal exposure to a chemical; the distinguishing feature between the two terms is the stage of development during which the insult occurred. The terms, as used here, include malformations and variations, altered growth, and in utero death. EPA Health Advisory—An estimate of acceptable drinking water levels for a chemical substance based on health effects information. A health advisory is not a legally enforceable federal standard, but serves as technical guidance to assist federal, state, and local officials. Immediately Dangerous to Life or Health (IDLH)—The maximum environmental concentration of a contaminant from which one could escape within 30 min without any escape-impairing symptoms or irreversible health effects. Intermediate Exposure—Exposure to a chemical for a duration of 15-364 days, as specified in the Toxicological Profiles. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 180 9. GLOSSARY Immunologic Toxicity—The occurrence of adverse effects on the immune system that may result from exposure to environmental agents such as chemicals. In Vitro—Isolated from the living organism and artificially maintained, as in a test tube. In Vivo—Occurring within the living organism. Lethal Concentration, o, (LC, ,)—The lowest concentration of a chemical in air which has been reported to have caused death in humans or animals. Lethal Concentration, (LCs)—A calculated concentration of a chemical in air to which exposure for a specific length of time is expected to cause death in 50% of a defined experimental animal population. Lethal Dose, o, (LD, ,)—The lowest dose of a chemical introduced by a route other than inhalation that is expected to have caused death in humans or animals. Lethal Doses, (LDs)—The dose of a chemical which has been calculated to cause death in 50% of a defined experimental animal population. Lethal Times, (LTs)—A calculated period of time within which a specific concentration of a chemical is expected to cause death in 50% of a defined experimental animal population. Lowest-Observed-Adverse-Effect Level (LOAEL)—The lowest dose of chemical in a study, or group of studies, that produces statistically or biologically significant increases in frequency or severity of adverse effects between the exposed population and its appropriate control. Malformations—Permanent structural changes that may adversely affect survival, development, or function. Minimal Risk Level—An estimate of daily human exposure to a dose of a chemical that is likely to be without an appreciable risk of adverse noncancerous effects over a specified duration of exposure. Mutagen—A substance that causes mutations. A mutation is a change in the genetic material in a body cell. Mutations can lead to birth defects, miscarriages, or cancer. Neurotoxicity—The occurrence of adverse effects on the nervous system following exposure to chemical. No-Observed-Adverse-Effect Level (NOAEL)—The dose of chemical at which there were no statistically or biologically significant increases in frequency or severity of adverse effects seen between the exposed population and its appropriate control. Effects may be produced at this dose, but they are not considered to be adverse. Octanol-Water Partition Coefficient (K,,)—The equilibrium ratio of the concentrations of a chemical in n-octanol and water, in dilute solution. Permissible Exposure Limit (PEL)—An allowable exposure level in workplace air averaged over an 8-hour shift. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE AND SULFURIC ACID 181 9. GLOSSARY q,*—The upper-bound estimate of the low-dose slope of the dose-response curve as determined by the multistage procedure. The q,* can be used to calculate an estimate of carcinogenic potency, the incremental excess cancer risk per unit of exposure (usually pg/L for water, mg/kg/day for food, and pg/m® for air). Reference Dose (RfD)—An estimate (with uncertainty spanning perhaps an order of magnitude) of the daily exposure of the human population to a potential hazard that is likely to be without risk of deleterious effects during a lifetime. The RfD is operationally derived from the NOAEL (from animal and human studies) by a consistent application of uncertainty factors that reflect various types of data used to estimate RfDs and an additional modifying factor, which is based on a professional judgment of the entire database on the chemical. The RfDs are not applicable to nonthreshold effects such as cancer. Reportable Quantity (RQ)—The quantity of a hazardous substance that is considered reportable under CERCLA. Reportable quantities are (1) 1 pound or greater or (2) for selected substances, an amount established by regulation either under CERCLA or under Sect. 311 of the Clean Water Act. Quantities are measured over a 24-hour period. Reproductive Toxicity—The occurrence of adverse effects on the reproductive system that may result from exposure to a chemical. The toxicity may be directed to the reproductive organs and/or the related endocrine system. The manifestation of such toxicity may be noted as alterations in sexual behavior, fertility, pregnancy outcomes, or modifications in other functions that are dependent on the integrity of this system. Short-Term Exposure Limit (STEL)—The maximum concentration to which workers can be exposed for up to 15 min continually. No more than four excursions are allowed per day, and there must be at least 60 min between exposure periods. The daily TLV-TWA may not be exceeded. Target Organ Toxicity—This term covers a broad range of adverse effects on target organs or physiological systems (e.g., renal, cardiovascular) extending from those arising through a single limited exposure to those assumed over a lifetime of exposure to a chemical. Teratogen—A chemical that causes structural defects that affect the development of an organism. Threshold Limit Value (TLV)—A concentration of a substance to which most workers can be exposed without adverse effect. The TLV may be expressed as a TWA, as a STEL, or as a CL. Time-Weighted Average (TWA)—An allowable exposure concentration averaged over a normal 8- hour workday or 40-hour workweek. Toxic Dose (TD4))—A calculated dose of a chemical, introduced by a route other than inhalation, which is expected to cause a specific toxic effect in 50% of a defined experimental animal population. Uncertainty Factor (UF)—A factor used in operationally deriving the RfD from experimental data. UFs are intended to account for (1) the variation in sensitivity among the members of the human population, (2) the uncertainty in extrapolating animal data to the case of human, (3) the uncertainty in extrapolating from data obtained in a study that is of less than lifetime exposure, and (4) the uncertainty in using LOAEL data rather than NOAEL data. Usually each of these factors is set equal to 10. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID A-1 APPENDIX A ATSDR MINIMAL RISK LEVEL The Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA) [42 U.S.C. 9601 et seq.], as amended by the Superfund Amendments and Reauthorization Act (SARA) [Pub. L. 99-499], requires that the Agency for Toxic Substances and Disease Registry (ATSDR) develop jointly with the U.S. Environmental Protection Agency (EPA), in order of priority, a list of hazardous substances most commonly found at facilities on the CERCLA National Priorities List (NPL); prepare toxicological profiles for each substance included on the priority list of hazardous substances; and assure the initiation of a research program to fill identified data needs associated with the substances. The toxicological profiles include an examination, summary, and interpretation of available toxicological information and epidemiologic evaluations of a hazardous substance. During the development of toxicological profiles, Minimal Risk Levels (MRLs) are derived when reliable and sufficient data exist to identify the target organ(s) of effect or the most sensitive health effect(s) for a specific duration for a given route of exposure. An MRL is an estimate of the daily human exposure to a hazardous substance that is likely to be without appreciable risk of adverse noncancer health effects over a specified duration of exposure. MRLs are based on noncancer health effects only and are not based on a consideration of cancer effects. These substance-specific estimates, which are intended to serve as screening levels, are used by ATSDR health assessors to identify contaminants and potential health effects that may be of concern at hazardous waste sites. It is important to note that MRLs are not intended to define clean-up or action levels. MRLs are derived for hazardous substances using the no-observed-adverse-effect level/uncertainty factor approach. They are below levels that might cause adverse health effects in the people most sensitive to such chemical-induced effects. MRLs are derived for acute (1-14 days), intermediate (15-364 days), and chronic (365 days and longer) durations and for the oral and inhalation routes of exposure. Currently, MRLs for the dermal route of exposure are not derived because ATSDR has not yet identified a method suitable for this route of exposure. MRLs are generally based on the most sensitive chemical-induced end point considered to be of relevance to humans. Serious health effects (such as irreparable damage to the liver or kidneys, or birth defects) are not used as-a basis for ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID A-2 APPENDIX A establishing MRLs. Exposure to a level above the MRL does not mean that adverse health effects will occur. MRLs are intended only to serve as a screening tool to help public health professionals decide where to look more closely. They may also be viewed as a mechanism to identify those hazardous waste sites that are not expected to cause adverse health effects. Most MRLs contain a degree of uncertainty because of the lack of precise toxicological information on the people who might be most sensitive (e.g., infants, elderly, nutritionally or immunologically compromised) to the effects of hazardous substances. ATSDR uses a conservative (i.e., protective) approach to address this uncertainty consistent with the public health principle of prevention. Although human data are preferred, MRLs often must be based on animal studies because relevant human studies are lacking. In the absence of evidence to the contrary, ATSDR assumes that humans are more sensitive to the effects of hazardous substance than animals and that certain persons may be particularly sensitive. Thus, the resulting MRL may be as much as a hundredfold below levels that have been shown to be nontoxic in laboratory animals. Proposed MRLs undergo a rigorous review process: Health Effects MRL Workgroup reviews within the Division of Toxicology, expert panel peer reviews, and agencywide MRL Workgroup reviews, with participation from other federal agencies and comments from the public. They are subject to change as new information becomes available concomitant with updating the toxicological profiles. Thus, MRLs in the most recent toxicological profiles supersede previously published levels. For additional information regarding MRLs, please contact the Division of Toxicology, Agency for Toxic Substances and Disease Registry, 1600 Clifton Road, Mailstop E-29, Atlanta, Georgia 30333. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID B-1 APPENDIX B USER’S GUIDE Chapter 1 Public Health Statement This chapter of the profile is a health effects summary written in non-technical language. Its intended audience is the general public especially people living in the vicinity of a hazardous waste site or chemical release. If the Public Health Statement were removed from the rest of the document, it would still communicate to the lay public essential information about the chemical. The major headings in the Public Health Statement are useful to find specific topics of concern. The topics are written in a question and answer format. The answer to each question includes a sentence that will direct the reader to chapters in the profile that will provide more information on the given topic. Chapter 2 Tables and Figures for Levels of Significant Exposure (LSE) Tables (2-1, 2-2, and 2-3) and figures (2-1 and 2-2) are used to summarize health effects and illustrate graphically levels of exposure associated with those effects. These levels cover health effects observed at increasing dose concentrations and durations, differences in response by species, minimal risk levels (MRLs) to humans for noncancer end points, and EPA’s estimated range associated with an upper- bound individual lifetime cancer risk of 1 in 10,000 to 1 in 10,000,000. Use the LSE tables and figures for a quick review of the health effects and to locate data for a specific exposure scenario. The LSE tables and figures should always be used in conjunction with the text. All entries in these tables and figures represent studies that provide reliable, quantitative estimates of No-Observed-Adverse- Effect Levels (NOAELSs), Lowest-Observed-Adverse-Effect Levels (LOAELSs), or Cancer Effect Levels (CELs). The legends presented below demonstrate the application of these tables and figures. Representative examples of LSE Table 2-1 and Figure 2-1 are shown. The numbers in the left column of the legends correspond to the numbers in the example table and figure. LEGEND See LSE Table 2-1 (1) Route of Exposure One of the first considerations when reviewing the toxicity of a substance using these tables and figures should be the relevant and appropriate route of exposure. When sufficient data exists, three LSE tables and two LSE figures are presented in the document. The three LSE tables present data on the three principal routes of exposure, i.e., inhalation, oral, and dermal (LSE Table 2-1, 2-2, and 2-3, respectively). LSE figures are limited to the inhalation (LSE Figure 2-1) and oral (LSE Figure 2-2) routes. Not all substances will have data on each route of exposure and will not therefore have all five of the tables and figures. “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID B-2 (2) 3) 4) 3) (6) (7 (3) 9) (10) APPENDIX B Exposure Period Three exposure periods - acute (less than 15 days), intermediate (15-364 days), and chronic (365 days or more) are presented within each relevant route of exposure. In this example, an inhalation study of intermediate exposure duration is reported. For quick reference to health effects occurring from a known length of exposure, locate the applicable exposure period within the LSE table and figure. Health Effect The major categories of health effects included in LSE tables and figures are death, systemic, immunological, neurological, developmental, reproductive, and cancer. NOAELs and LOAELs can be reported in the tables and figures for all effects but cancer. Systemic effects are further defined in the "System" column of the LSE table (see key number 18). Key to Figure Each key number in the LSE table links study information to one or more data points using the same key number in the corresponding LSE figure. In this example, the study represented by key number 18 has been used to derive a NOAEL and a Less Serious LOAEL (also see the 2 "18r" data points in Figure 2-1). Species The test species, whether animal or human, are identified in this column. Section 2.5, "Relevance to Public Health," covers the relevance of animal data to human toxicity and Section 2.3, "Toxicokinetics," contains any available information on comparative toxicokinetics. Although NOAELs and LOAELSs are species specific, the levels are extrapolated to equivalent human doses to derive an MRL. Exposure Frequency/Duration The duration of the study and the weekly and daily exposure regimen are provided in this column. This permits comparison of NOAELs and LOAELs from different studies. In this case (key number 18), rats were exposed to 1,1,2,2-tetrachloroethane via inhalation for 6 hours per day, 5 days per week, for 3 weeks. For a more complete review of the dosing regimen refer to the appropriate sections of the text or the original reference paper, 1.e., Nitschke et al. 1981. System This column further defines the systemic effects. These systems include: respiratory, cardiovascular, gastrointestinal, hematological, musculoskeletal, hepatic, renal, and dermal/ocular. "Other" refers to any systemic effect (e.g., a decrease in body weight) not covered in these systems. In the example of key number 18, 1 systemic effect (respiratory) was investigated. NOAEL A No-Observed-Adverse-Effect Level (NOAEL) is the highest exposure level at which no harmful effects were seen in the organ system studied. Key number 18 reports a NOAEL of 3 ppm for the respiratory system which was used to derive an intermediate exposure, inhalation MRL of 0.005 ppm (see footnote "b"). LOAEL A Lowest-Observed-Adverse-Effect Level (LOAEL) is the lowest dose used in the study that caused a harmful health effect. LOAELSs have been classified into "Less Serious" and "Serious" effects. These distinctions help readers identify the levels of exposure at which adverse health effects first appear and the gradation of effects with increasing dose. A brief description of the specific endpoint used to quantify the adverse effect accompanies the LOAEL. The respiratory effect reported in key number 18 (hyperplasia) is a Less serious LOAEL of 10 ppm. MRLs are not derived from Serious LOAELSs. Reference The complete reference citation is given in chapter 8 of the profile. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID B-3 APPENDIX B (11) CEL A Cancer Effect Level (CEL) is the lowest exposure level associated with the onset of carcinogenesis in experimental or epidemiologic studies. CELs are always considered serious effects. The LSE tables and figures do not contain NOAELs for cancer, but the text may report doses not causing measurable cancer increases. (12) Footnotes Explanations of abbreviations or reference notes for data in the LSE tables are found in the footnotes. Footnote "b" indicates the NOAEL of 3 ppm in key number 18 was used to derive an MRL of 0.005 ppm. LEGEND See Figure 2-1 LSE figures graphically illustrate the data presented in the corresponding LSE tables. Figures help the reader quickly compare health effects according to exposure concentrations for particular exposure periods. (13) Exposure Period The same exposure periods appear as in the LSE table. In this example, health effects observed within the intermediate and chronic exposure periods are illustrated. (14) Health Effect These are the categories of health effects for which reliable quantitative data exists. The same health effects appear in the LSE table. (15) Levels of Exposure concentrations or doses for each health effect in the LSE tables are graphically displayed in the LSE figures. Exposure concentration or dose is measured on the log non scale "y" axis. Inhalation exposure is reported in mg/m’ or ppm and oral exposure is reported in mg/kg/day. (16) NOAEL In this example, 18r NOAEL is the critical endpoint for which an intermediate inhalation exposure MRL is based. As you can see from the LSE figure key, the open-circle symbol indicates to a NOAEL for the test species-rat. The key number 18 corresponds to the entry in the LSE table. The dashed descending arrow indicates the extrapolation from the exposure level of 3 ppm (see entry 18 in the Table) to the MRL of 0.005 ppm (see footnote "b" in the LSE table). (17) CEL Key number 38r is 1 of 3 studies for which Cancer Effect Levels were derived. The diamond symbol refers to a Cancer Effect Level for the test species-mouse. The number 38 corresponds to the entry in the LSE table. (18) Estimated Upper-Bound Human Cancer Risk Levels This is the range associated with the upper-bound for lifetime cancer risk of 1 in 10,000 to 1 in 10,000,000. These risk levels are derived from the EPA’s Human Health Assessment Group’s upper-bound estimates of the slope of the cancer dose response curve at low dose levels (q,*). (19) Key to LSE Figure The Key explains the abbreviations and symbols used in the figure. ***DRAFT FOR PUBLIC COMMENT*** «+ LNIJWWOD O178Nd HOH L4VH(... TABLE 2-1. Levels of Significant Exposure to [Chemical x] — Inhalation Exposure Key to frequency/ NOAEL figure® Species duration System (ppm) LOAEL (effect) Less serious (ppm) Serious (ppm) Reference INTERMEDIATE EXPOSURE Systemic { { 18 Rat 13 wk 3 5d/wk 6hr/d CHRONIC EXPOSURE Cancer 38 Rat 18 mo 5d/wk 7hr/d 39 Rat 89-104 wk S5d/wk 6hr/d 40 Mouse 79-103 wk 5d/wk 6hr/d 1 Nitschke et al. 1981 20 (CEL, multiple organs) Wong et al. 1982 10 (CEL, lung tumors, NTP 1982 nasal tumors) 10 (CEL, lung tumors, NTP 1982 hemangiosarcomas) # The number corresponds to entries in Figure 2-1. ® Used to derive an intermediate inhalation Minimal Risk Level (MRL) of 5 x 10° ppm; dose adjusted for intermittent exposure and divided by an uncertainty factor of 100 (10 for extrapolation from animal to humans, 10 for human variability). CEL = cancer effect level; d = days(s); hr = hour(s); LOAEL = lowest-observed-adverse-effect level; mo = month(s); NOAEL = no- observed-adverse-effect level; Resp = respiratory; wk = week(s) 9 XION3ddv aidv JIHN4INS/3AIX0IdL HN4INS v-9 «= LNJWWOD O118Nd HOS L4VHQuxs —— > Figure 2-1. Levels of Significant Exposure to [Chemical X] — Inhalation Acute Intermediate (14 days) (15-364 days) Systemic Systemic N " > ya 4% 4 <& oO 1000 o . o 37m 10) Bp e—— ° Oo oO @ 30 oO 3 100 7 23, 2Md Boom ate Q xm MW og Sg 91g. 22g21r O 28m® 29 27r 40m 10 3 33r 22 Q er 1 1 | : 104 — ! . 0.1 ! 105 Estimated <— | Y Upper Bound : 0.01 6 | Human Cancer Key 10 Risk Levels 0.001 r Rat @ LOAEL for serious effects (animals) I Minimal risk level for effects 1077 1 m Mouse (DP LOAEL for less serious effects (animals) | Other than cancer 0.0001 h Rabbit (QO NOAEL (animals) g Guinea Pig CEL - Cancer Effect Level The number next to each point 0.00001 k Monkey * corresponds to entries in the accompanying table. 0.000001 * Doses represent the lowest dose tested per study that produced a tumorigenic response and do not imply the existence of a threshold for the cancer end point. 0.0000001 9 XION3ddVY aiov 21HN4INS/3AIXold.L 4N4INs 5-9 SULFUR TRIOXIDE/SULFURIC ACID B-6 APPENDIX B Chapter 2 (Section 2.5) Relevance to Public Health The Relevance to Public Health section provides a health effects summary based on evaluations of existing toxicologic, epidemiologic, and toxicokinetic information. This summary is designed to present interpretive, weight-of-evidence discussions for human health end points by addressing the following questions. 1. What effects are known to occur in humans? 2. What effects observed in animals are likely to be of concern to humans? 3. What exposure conditions are likely to be of concern to humans, especially around hazardous waste sites? The section covers end points in the same order they appear within the Discussion of Health Effects by Route of Exposure section, by route (inhalation, oral, dermal) and within route by effect. Human data are presented first, then animal data. Both are organized by duration (acute, intermediate, chronic). In vitro data and data from parenteral routes (intramuscular, intravenous, subcutaneous, etc.) are also considered in this section. If data are located in the scientific literature, a table of genotoxicity information is included. The carcinogenic potential of the profiled substance is qualitatively evaluated, when appropriate, using existing toxicokinetic, genotoxic, and carcinogenic data. ATSDR does not currently assess cancer potency or perform cancer risk assessments. Minimal risk levels (MRLs) for noncancer end points (if derived) and the end points from which they were derived are indicated and discussed. Limitations to existing scientific literature that prevent a satisfactory evaluation of the relevance to public health are identified in the Data Needs section. Interpretation of Minimal Risk Levels Where sufficient toxicologic information is available, we have derived minimal risk levels (MRLs) for inhalation and oral routes of entry at each duration of exposure (acute, intermediate, and chronic). These MRLs are not meant to support regulatory action; but to acquaint health professionals with exposure levels at which adverse health effects are not expected to occur in humans. They should help physicians and public health officials determine the safety of a community living near a chemical emission, given the concentration of a contaminant in air or the estimated daily dose in water. MRLs are based largely on toxicological studies in animals and on reports of human occupational exposure. MRL users should be familiar with the toxicologic information on which the number is based. Chapter 2.5, "Relevance to Public Health," contains basic information known about the substance. Other sections such as 2.7, "Interactions with Other Substances,” and 2.8, "Populations that are Unusually Susceptible" provide important supplemental information. MRL users should also understand the MRL derivation methodology. MRLs are derived using a modified version of the risk assessment methodology the Environmental Protection Agency (EPA) provides (Barnes and Dourson 1988) to determine reference doses for lifetime exposure (RfDs). “**DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID B-7 APPENDIX B To derive an MRL, ATSDR generally selects the most sensitive endpoint which, in its best judgement, represents the most sensitive human health effect for a given exposure route and duration. ATSDR cannot make this judgement or derive an MRL unless information (quantitative or qualitative) is available for all potential systemic, neurological, and developmental effects. If this information and reliable quantitative data on the chosen endpoint are available, ATSDR derives an MRL using the most sensitive species (when information from multiple species is available) with the highest NOAEL that does not exceed any adverse effect levels. When a NOAEL is not available, a lowest-observed- adverse-effect level (LOAEL) can be used to derive an MRL, and an uncertainty factor (UF) of 10 must be employed. Additional uncertainty factors of 10 must be used both for human variability to protect sensitive subpopulations (people who are most susceptible to the health effects caused by the substance) and for interspecies variability (extrapolation from animals to humans). In deriving an MRL, these individual uncertainty factors are multiplied together. The product is then divided into the inhalation concentration or oral dosage selected from the study. Uncertainty factors used in developing a substance-specific MRL are provided in the footnotes of the LSE Tables. ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID C1 ACGIH ADME AMAD AML atm ATSDR BCF BEI BSC C CDC CEL CERCLA CFR Ci CLP cm CMD CML CNS d DHEW DHHS DOL ECG EEG EPA EKG F F, FAO FEMA FEV, FIFRA fpm ft FR FVC GC gen HPLC APPENDIX C ACRONYMS, ABBREVIATIONS, AND SYMBOLS American Conference of Governmental Industrial Hygienists Absorption, Distribution, Metabolism, and Excretion activity median aerodynamic diameter acute myeloid leukemia atmosphere Agency for Toxic Substances and Disease Registry bioconcentration factor Biological Exposure Index Board of Scientific Counselors Centigrade Centers for Disease Control Cancer Effect Level Comprehensive Environmental Response, Compensation, and Liability Act Code of Federal Regulations curie Contract Laboratory Program centimeter count median diameter chronic myeloid leukemia central nervous system day Department of Health, Education, and Welfare Department of Health and Human Services Department of Labor electrocardiogram electroencephalogram Environmental Protection Agency see ECG Fahrenheit first filial generation Food and Agricultural Organization of the United Nations Federal Emergency Management Agency forced expiratory volume in 1 second, air from a maximal inspiration that can be exhaled forcefully in 1 second Federal Insecticide, Fungicide, and Rodenticide Act feet per minute foot Federal Register forced vital capacity, the amount of air that can be exhaled forcefully and rapidly after a maximal inspiration gram gas chromatography generation high-performance liquid chromatography ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID hr IDLH IARC ILO LD,, LDy, LOAEL LSE m MA mCi mg min mL mm mm Hg MMAD mmol MMD mo mppcf MRL MS NCE NIEHS NIOSH NIOSHTIC ng nm NHANES nmol NOAEL NOES NOHS NPL NRC NTIS NTP OSHA APPENDIX C hour Immediately Dangerous to Life and Health International Agency for Research on Cancer International Labor Organization inch adsorption ratio kilogram metric ton organic carbon partition coefficient octanol-water partition coefficient liter liquid chromatography lethal concentration, low lethal concentration, 50% kill lethal dose, low lethal dose, 50% kill lowest-observed-adverse-effect level Levels of Significant Exposure meter trans,trans-muconic acid millicurie milligram minute milliliter millimeter millimeters of mercury mass median aerodynamic diameter millimole mass median diameter month millions of particles per cubic foot Minimal Risk Level mass spectrometry normochromatic erythrocytes National Institute of Environmental Health Sciences National Institute for Occupational Safety and Health NIOSH’s Computerized Information Retrieval System nanogram nanometer National Health and Nutrition Examination Survey nanomole no-observed-adverse-effect level National Occupational Exposure Survey National Occupational Hazard Survey National Priorities List National Research Council National Technical Information Service National Toxicology Program Occupational Safety and Health Administration ***DRAFT FOR PUBLIC COMMENT*** SULFUR TRIOXIDE/SULFURIC ACID PEL PCE Pg pmol PHS PMR ppb ppm ppt REL RfD RTECS sec SCE SIC SMR SRaw STEL STORET TLV TSCA TRI TWA UMDNJ U.S. UF VMD WHO wk yr RXR OR KINA NIV YV pum HE APPENDIX C permissible exposure limit polychromatic erythrocytes picogram picomole Public Health Service proportionate mortality ratio parts per billion parts per million parts per trillion recommended exposure limit Reference Dose Registry of Toxic Effects of Chemical Substances second sister chromatid exchange Standard Industrial Classification standard mortality ratio specific airway resistance short term exposure limit STORAGE and RETRIEVAL threshold limit value Toxic Substances Control Act Toxics Release Inventory time-weighted average : University of Medicine and Dentistry New Jersey United States uncertainty factor volume median diameter World Health Organization week year greater than greater than or equal to equal to less than less than or equal to percent alpha beta delta gamma micrometer microgram ***DRAFT FOR PUBLIC COMMENT*** C-3 ¥ U. S. GOVERNMENT PRINTING OFFICE: 1997-538-074 PUBLIC HEALTH LIBRARY OC 05 10: —_— aly a 2 3 i : a } ois a i : em ra v Y Ea or ; ” ‘ \ El Bh o -w on oa - - . ed = -- 3 4 adh a , a 3 - mst 4 - U.C. BERKELEY LIBRARIES C095475k43